搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

基于微波透射法的金属薄膜方块电阻测量理论及其应用

王露 叶鸣 赵小龙 贺永宁

引用本文:
Citation:

基于微波透射法的金属薄膜方块电阻测量理论及其应用

王露, 叶鸣, 赵小龙, 贺永宁

Theory and verification of a microwave transmission method of measuring sheet resistance of metallic thin film

Wang Lu, Ye Ming, Zhao Xiao-Long, He Yong-Ning
PDF
导出引用
  • 贝尔不等式在定域性和实在性的双重假设下,对于被分隔的粒子同时被测量时其结果的可能关联程度建立了一个严格的限制,违反贝尔不等式确保量子态存在纠缠.本文利用量子相干性的l1和相对熵测度构建了四体量子贝尔不等式,发现一般实系数Greenberger-Horne-Zeilinger纯态和簇纯态总是违反四体相对熵相干性测度贝尔不等式,因此违反四体相对熵相干性测度贝尔不等式的这些态是纠缠态.
    Metallic thin films deposited on non-conductive substrates are widely used in areas like microwave absorbers, photovoltaic, packaging, electromagnetic shielding, and integrated circuits. From scientific and engineering point of view, measuring sheet resistance of metallic thin films is important. In this study, we develop a theory of evaluating sheet resistance by using transmission coefficient of a rectangular waveguide (RG) and verify it with sputtered silver films of various thickness values. According to the field distribution of RG working under the fundamental mode and corresponding electromagnetic boundary conditions, we first analytically derive the transmission coefficient of an RG with the metallic thin film exactly occupying its cross section. Comparing existing theory, we take the effect of the non-conductive substrate supporting the metallic thin film into consideration. According to this derivation, we establish a method to calculate the sheet resistance of metallic thin films from the amplitude of RG transmission coefficient. To verify our derivation, we also conduct full-wave simulations of a standard WR-75 RG used for characterizing the metallic thin film at 13.65 GHz. Both the analytical derivations and full-wave simulations show that the amplitude of the transmission coefficient depends on the logarithm of the sheet resistance in a linear manner. It is also demonstrated that the substrate effect may not be ignored. To facilitate measurement, we propose a sandwiched structure by placing the metallic thin film between two waveguide flanges. This modification removes the stringent requirements for sample preparation. Simulations of this sandwiched structure indicate that it is possible to realize non-contact measurement if the air gap between metallic thin film and waveguide flange is below 0.1 mm. Through full-wave simulations, we also show the feasibility of metallic thin film evaluation by using such transmission lines as dielectric filled RG, circular waveguide, and coaxial line. Finally, we prepare various silver films with sheet resistances ranging from 20 m/square to 1 /square (measured by the four-point probe technique) on the top of high resistance silicon and glass substrates, respectively. We measure the amplitudes of transmission coefficient of these metal films in RG by using vector network analyzer. The obtained experimental results are well consistent with the derivation and simulation results, thereby verifying the proposed method. It is recommended that the proposed method is suitable for conductive films with sheet resistances ranging from 0.05 /square to 0.5 /square. The results of this study are of potential value for characterizing the conductive thin films in micro/nano fabrication and relevant areas.
      通信作者: 叶鸣, yeming057@mail.xjtu.edu.cn
    • 基金项目: 国家自然科学基金(批准号:61501364)资助的课题.
      Corresponding author: Ye Ming, yeming057@mail.xjtu.edu.cn
    • Funds: Project supported by the National Natural Science Foundation of China (Grant No. 61501364).
    [1]

    Qu Z, Meng Y, Zhao Q 2015 Front. Mech. Eng. 10 1

    [2]

    Hudaya C, Park J H, Lee J K 2012 Nanoscale. Res. Lett. 7 17

    [3]

    Liu Y, Tan J 2013 Prog. Eletromagn. Res. 140 353

    [4]

    Wang S, Divan R, Rosenmann D, Ocola L E, Sun J, Wang P 2013 IEEE. Microw. Wirel. Co. 23 84

    [5]

    Pan Y L, Tai C C 2012 IEEE. Trans. Magn 48 347

    [6]

    Evseev S B, Nanver L K, Milosaviljevic S 2012 IEEE. Trans. Microw. Theory 60 3542

    [7]

    Krupka J, Usydus L, Koltuniak H 2012 19th International Conference on Microwave Radar and Wireless Communications Warsaw, Poland, May 21-23, 2012 p149

    [8]

    Das R, Goswami S, Borgohain R, Baruah S 2015 International Conference on Energy, Power and Environment:Towards Sustainable Growth Meghalaya, Indian, June 12-15, 2015 p1

    [9]

    Enderling S, Brown C L, Smith S, Dicks M H 2006 IEEE. Trans. Semiconduct. M 19 2

    [10]

    Reznik A N, Demidov E V 2013 J. Appl. Phys. 113 2026

    [11]

    Fan M B, Cao B H, Yang X F 2010 Acta Phys. Sin. 59 7570 (in Chinese)[范孟豹, 曹丙花, 杨雪锋2010物理学报59 7570]

    [12]

    Lee M H J, Collier R J 2005 IEEE. Trans. Instrum. Meas. 54 2412

    [13]

    Jan K 2011 Meas. Sci. Technol. 22 085703

    [14]

    Galin M A, Demidov E V, Reznik A N 2014 J. Surf. Investig. 8 477

    [15]

    Li W, Wang H, Feng Z 2016 Rev. Sci. Instrum. 87 045005

    [16]

    Shaforost O, Wang K, Goniszewski S, Adabi M, Guo Z 2015 J. App. Phys. 117 024501

    [17]

    Wang Z, Kelly M A, Shen Z X, Shao L, Chu W K 2005 Appl. Phys. Lett. 86 153118

    [18]

    Krupka J, Mazierska J E, Jacob M V, Hartnett J G, Tobar M E 2003 Microw. Opt. Technol. Lett. 2004 311

    [19]

    Ramey R L, Lewis T S 1968 J. App. Phys. 39 1747

    [20]

    Ramey R L, Kitchen Jr. W J, Lloyd J M, Landes H S 1968 J. App. Phys. 39 3883

    [21]

    Pozar D M (Zhang Z Y, Zhou L Z, Wu D M, Transl) 2006 Microwave Engineering (3rd Ed.) (Beijing:Publishing House of Electronics Industry) pp92-96(in Chinese)[波扎(张肇仪, 周乐柱, 吴德明译) 2006微波工程(三版) (北京:电子工业出版社)第9296页]

  • [1]

    Qu Z, Meng Y, Zhao Q 2015 Front. Mech. Eng. 10 1

    [2]

    Hudaya C, Park J H, Lee J K 2012 Nanoscale. Res. Lett. 7 17

    [3]

    Liu Y, Tan J 2013 Prog. Eletromagn. Res. 140 353

    [4]

    Wang S, Divan R, Rosenmann D, Ocola L E, Sun J, Wang P 2013 IEEE. Microw. Wirel. Co. 23 84

    [5]

    Pan Y L, Tai C C 2012 IEEE. Trans. Magn 48 347

    [6]

    Evseev S B, Nanver L K, Milosaviljevic S 2012 IEEE. Trans. Microw. Theory 60 3542

    [7]

    Krupka J, Usydus L, Koltuniak H 2012 19th International Conference on Microwave Radar and Wireless Communications Warsaw, Poland, May 21-23, 2012 p149

    [8]

    Das R, Goswami S, Borgohain R, Baruah S 2015 International Conference on Energy, Power and Environment:Towards Sustainable Growth Meghalaya, Indian, June 12-15, 2015 p1

    [9]

    Enderling S, Brown C L, Smith S, Dicks M H 2006 IEEE. Trans. Semiconduct. M 19 2

    [10]

    Reznik A N, Demidov E V 2013 J. Appl. Phys. 113 2026

    [11]

    Fan M B, Cao B H, Yang X F 2010 Acta Phys. Sin. 59 7570 (in Chinese)[范孟豹, 曹丙花, 杨雪锋2010物理学报59 7570]

    [12]

    Lee M H J, Collier R J 2005 IEEE. Trans. Instrum. Meas. 54 2412

    [13]

    Jan K 2011 Meas. Sci. Technol. 22 085703

    [14]

    Galin M A, Demidov E V, Reznik A N 2014 J. Surf. Investig. 8 477

    [15]

    Li W, Wang H, Feng Z 2016 Rev. Sci. Instrum. 87 045005

    [16]

    Shaforost O, Wang K, Goniszewski S, Adabi M, Guo Z 2015 J. App. Phys. 117 024501

    [17]

    Wang Z, Kelly M A, Shen Z X, Shao L, Chu W K 2005 Appl. Phys. Lett. 86 153118

    [18]

    Krupka J, Mazierska J E, Jacob M V, Hartnett J G, Tobar M E 2003 Microw. Opt. Technol. Lett. 2004 311

    [19]

    Ramey R L, Lewis T S 1968 J. App. Phys. 39 1747

    [20]

    Ramey R L, Kitchen Jr. W J, Lloyd J M, Landes H S 1968 J. App. Phys. 39 3883

    [21]

    Pozar D M (Zhang Z Y, Zhou L Z, Wu D M, Transl) 2006 Microwave Engineering (3rd Ed.) (Beijing:Publishing House of Electronics Industry) pp92-96(in Chinese)[波扎(张肇仪, 周乐柱, 吴德明译) 2006微波工程(三版) (北京:电子工业出版社)第9296页]

  • [1] 王慧莹, 王智, 崔粲, 李航天, 李强, 詹翔空, 王健, 吴重庆. 非互易旋电材料硅基矩形波导的色散特性研究. 物理学报, 2019, 68(15): 154203. doi: 10.7498/aps.68.20190109
    [2] 刘俊, 张天恩, 张伟, 雷龙海, 薛晨阳, 张文栋, 唐军. 平面环形谐振腔微光学陀螺结构设计与优化. 物理学报, 2015, 64(10): 107802. doi: 10.7498/aps.64.107802
    [3] 王瑞琴, 宫箭, 武建英, 陈军. 对称双势垒量子阱中自旋极化输运的时间特性. 物理学报, 2013, 62(8): 087303. doi: 10.7498/aps.62.087303
    [4] 李林茜, 石雁祥, 王飞, 魏兵. 弱电离尘埃等离子体层反射与透射的SO-FDTD方法分析. 物理学报, 2012, 61(12): 125201. doi: 10.7498/aps.61.125201
    [5] 乔建良, 常本康, 钱芸生, 王晓晖, 李飙, 徐源. GaN真空面电子源光电发射机理研究. 物理学报, 2011, 60(12): 127901. doi: 10.7498/aps.60.127901
    [6] 徐慧, 崔麦玲, 马松山. 含有格点势的一维Fibonacci链热传导性质的研究. 物理学报, 2010, 59(10): 7266-7270. doi: 10.7498/aps.59.7266
    [7] 席光义, 郝智彪, 汪 莱, 李洪涛, 江 洋, 赵 维, 任 凡, 韩彦军, 孙长征, 罗 毅. 非故意掺杂GaN薄膜方块电阻与载气中N2比例关系研究. 物理学报, 2008, 57(11): 7233-7237. doi: 10.7498/aps.57.7233
    [8] 褚庆昕, 龚建强. TE10矩形波导中填充金属线阵和铁氧体合成的新型左手媒质. 物理学报, 2008, 57(5): 2925-2929. doi: 10.7498/aps.57.2925
    [9] 孟繁义, 吴 群, 傅佳辉, 杨国辉. 各向异性超常媒质矩形波导的导波特性研究. 物理学报, 2008, 57(9): 5476-5484. doi: 10.7498/aps.57.5476
    [10] 路志刚, 魏彦玉, 宫玉彬, 吴周淼, 王文祥. 具有任意槽的矩形波导栅慢波结构高频特性的研究. 物理学报, 2007, 56(6): 3318-3323. doi: 10.7498/aps.56.3318
    [11] 殷海荣, 宫玉彬, 魏彦玉, 路志刚, 巩华荣, 岳玲娜, 黄民智, 王文祥. 非截面二维光子晶体排列矩形波导的全模式分析. 物理学报, 2007, 56(3): 1590-1597. doi: 10.7498/aps.56.1590
    [12] 路志刚, 宫玉彬, 魏彦玉, 王文祥. 介质加载矩形波导栅行波管的小信号增益计算. 物理学报, 2007, 56(12): 6931-6936. doi: 10.7498/aps.56.6931
    [13] 罗宇峰, 钟 澄, 张 莉, 严学俭, 李 劲, 蒋益明. 方块电阻法原位表征Cu薄膜氧化反应动力学规律. 物理学报, 2007, 56(11): 6722-6726. doi: 10.7498/aps.56.6722
    [14] 曾 晖, 胡慧芳, 韦建卫, 谢 芳, 彭 平. 含有五边形—七边形缺陷的单壁纳米碳管的输运性质研究. 物理学报, 2006, 55(9): 4822-4827. doi: 10.7498/aps.55.4822
    [15] 王洪梅, 张亚非. Airy传递矩阵法与偏压下多势垒结构的准束缚能级. 物理学报, 2005, 54(5): 2226-2232. doi: 10.7498/aps.54.2226
    [16] 张维佳, 王天民, 钟立志, 吴小文, 崔 敏. ITO导电膜红外发射率理论研究. 物理学报, 2005, 54(9): 4439-4444. doi: 10.7498/aps.54.4439
    [17] 颜家壬, 黄国翔, 黄念宁. 矩形波导中两层流体界面上的非传播孤立波. 物理学报, 1988, 37(5): 874-880. doi: 10.7498/aps.37.874
    [18] 胡佩康. 含有铁氧体圆杆的矩形波导的散射矩阵及其等效线路. 物理学报, 1966, 22(9): 1069-1076. doi: 10.7498/aps.22.1069
    [19] 林为干. 矩形波导与圆柱波导或圆柱谐振腔间的小孔耦合. 物理学报, 1959, 15(7): 368-376. doi: 10.7498/aps.15.368
    [20] 林为干. 矩形波导一个不连续性的等效电路. 物理学报, 1956, 12(5): 459-476. doi: 10.7498/aps.12.459
计量
  • 文章访问数:  4693
  • PDF下载量:  202
  • 被引次数: 0
出版历程
  • 收稿日期:  2017-04-19
  • 修回日期:  2017-06-19
  • 刊出日期:  2017-10-05

/

返回文章
返回