Micro-damage characteristics of incipient spall in high-purity copper

Peng Hui; Pei Xiao-Yang; Li Ping; He Hong-Liang; Bai Jin-Song

doi:10.7498/aps.64.216201

Abstract

Dynamic damage of material is a complex process that is dependent on lots of effects on a mesoscale, including grain size, morphology and micro-voids. In order to study the shocked lead micro-damage characteristics in oxygen-free high-purity copper, the variational thickness values of flyers and samples are designed to vary pulse duration and strain rate in plate-impact experiment, and the special recovery chamber and surface profile measurement system are used for soft-recovery and cross-section measure respectively. Based on the reconstruction, quantitative and statistical analysis, it is found that the longer pulse duration and higher shock loading stress bring about more serious local damage in oxygen-free high-purity copper. The mensurable damage width of sample cross-section results from the damage evolution on a sub-micron scale. Critical evolution time of sub-micron is observed to decrease with strain rate increasing, suggesting that damage evolution speed of sub-micron becomes faster as strain rate increases. The void size distribution of recovered sample is presented, and the topological characteristic transition accompanied with nucleation, growth, and coalescence processes of microscopic voids is also discussed. Through a comparison of difference between this work and the literature of previous research, a physical explanation of voids size distribution characteristics of oxygen-free high-purity copper is presented.

Keywords:

Authors and contacts

1.
Key Laboratory of Shock Wave and Detonation Physics, Institute of Fluid Physics, China Academy of Engineering Physics, Mianyang 621900, China;
2.
State Key Laboratory of Explosion and Technology, Beijing Institute of Technology, Beijing 100081, China

Corresponding author: Li Ping, lp0703@263.net

Funds: Project supported by the National Natural Science Foundation of China (Grant Nos. 11202196, 11532012, 11372294), National Defense Basic Scientific Research program of China (Grant No. B1520132013), the National Key Laboratory of Shock Wave and Detonation Physics (Grant No. 9140C670301150C67290), and the Foundation of President of China Academy of Engineering Physics (Grant No. 201402084).

References

[1]	Lu K 2010 Science 328 319
[2]	Chen M W, McCauley J W, Dandekar D P, Bourne N K 2006 Nat. Mater. 5 614
[3]	Kawamura H, Hatano T, Kato N, Biswas S, Chakrabarti B K 2012 Rev. Mod. Phys. 84 839
[4]	Sagis L M C 2011 Rev. Mod. Phys. 83 1367
[5]	Zhang Z F, Wang Z G 2008 Prog. Mater. Sci. 53 1025
[6]	Han W Z, An Q, Luo S N, Germann T C, Tonks D L, Goddard W A 2012 Phys. Rev. B 85 024107
[7]	Jarmakani H, Maddox B, Wei C T, Kalantar D, Meyers M A 2010 Acta Mater. 58 4604
[8]	Kanel G I 2010 Int. J. Fracture 163 173
[9]	Lebensohn R A, Escobedo J P, Cerreta E K, Dennis-Koller D, Bronkhorst C A, Bingert J F 2013 Acta Mater. 61 6918
[10]	Mayer A E, Krasnikov V S 2011 Eng. Fract. Mech. 78 1306
[11]	Shao J L, Wang P, He A M, Zhang R, Qin C S 2013 J. Appl. Phys. 114 173501
[12]	Wang Y G, He H L, Wang L L 2013 Mech. Mater. 56 131
[13]	Cuitino A M, Ortiz M 1995 Acta Mater. 44 427
[14]	Fensin S J, Escobedo-Diaz J P, Brandl C, Cerreta E K, GrayIII G T, Germann T C, Valone S M 2014 Acta Mater. 64 113
[15]	Razorenov S V, Zaretsky E B, Savinykh A S 2014 Journal of Physics: Conference Series 500 112053
[16]	Whelchel R L, Sanders T H, Thadhani N N 2014 Scr. Mater. 92 59
[17]	Curran D R, Seaman L, Shockey D A 1987 Phys. Rep. 147 253
[18]	Qi M L, Luo C, He H L, Wang Y G, Fan D, Yan S L 2012 J. Appl. Phys. 111 043506
[19]	Kondrokhina I N, Podurets A M, Ignatova O N, Nadezhin S S, Skokov V I, Malyshev A N,Bat'kov Y V 2012 19th European Conference on Fracture p1
[20]	Bontaz-Carion J, Pellegrini Y 2006 Adv. Eng. Mater. 8 480
[21]	Qi M L, Zhong S, He H L, Fan D, Zhao L 2013 Chin. Phys. B 22 046203
[22]	Peng H, Li P, Pei X Y, He H L, Cheng H P, Qi M L 2013 Acta Phys. Sin. 62 226201 (in Chinese) [彭辉, 李平, 裴晓阳, 贺红亮, 程和平, 祁美兰 2013 物理学报 62 226201]
[23]	Qi M L, Bie B X, Zhao F P, Hu C M, Fan D, Ran X X, Xiao X H, Yang W G, Li P, Luo S N 2014 AIP Advances 4 077118
[24]	Peng H, Li P, Pei X Y, He H L, Qi M L 2013 Opt. Pre. Eng. 21 3008 (in Chinese) [彭辉, 李平, 裴晓阳, 贺红亮, 祁美兰 2013 光学精密工程 21 3008]
[25]	Williams C L 2012 Ph. D. Dissertation (Baltimore, Maryland: Johns Hopkins University)
[26]	Tuler F R, Butcher B M 1968 Int. J. Fracture 4 431
[27]	Molinari A, Wright T W 2005 J. Mech. Phy. Solids 53 1476
[28]	Strachan A, Çaín T, Goddard W 2001 Phys. Rev. B 63 060103
[29]	Belak J 1998 J. Comput.-Aided Mater. 5 193
[30]	Reina C, Marian J, Ortiz M 2011 Phys. Rev. B 84 104117
[31]	Pei X Y 2013 Ph. D. Dissertation (Mianyang: China Academy of Engineering Physics) (in Chinese) [裴晓阳 2013 博士学位论文 (绵阳: 中国工程物理研究院)]

Cited By

[1]	Lu K 2010 Science 328 319
[2]	Chen M W, McCauley J W, Dandekar D P, Bourne N K 2006 Nat. Mater. 5 614
[3]	Kawamura H, Hatano T, Kato N, Biswas S, Chakrabarti B K 2012 Rev. Mod. Phys. 84 839
[4]	Sagis L M C 2011 Rev. Mod. Phys. 83 1367
[5]	Zhang Z F, Wang Z G 2008 Prog. Mater. Sci. 53 1025
[6]	Han W Z, An Q, Luo S N, Germann T C, Tonks D L, Goddard W A 2012 Phys. Rev. B 85 024107
[7]	Jarmakani H, Maddox B, Wei C T, Kalantar D, Meyers M A 2010 Acta Mater. 58 4604
[8]	Kanel G I 2010 Int. J. Fracture 163 173
[9]	Lebensohn R A, Escobedo J P, Cerreta E K, Dennis-Koller D, Bronkhorst C A, Bingert J F 2013 Acta Mater. 61 6918
[10]	Mayer A E, Krasnikov V S 2011 Eng. Fract. Mech. 78 1306
[11]	Shao J L, Wang P, He A M, Zhang R, Qin C S 2013 J. Appl. Phys. 114 173501
[12]	Wang Y G, He H L, Wang L L 2013 Mech. Mater. 56 131
[13]	Cuitino A M, Ortiz M 1995 Acta Mater. 44 427
[14]	Fensin S J, Escobedo-Diaz J P, Brandl C, Cerreta E K, GrayIII G T, Germann T C, Valone S M 2014 Acta Mater. 64 113
[15]	Razorenov S V, Zaretsky E B, Savinykh A S 2014 Journal of Physics: Conference Series 500 112053
[16]	Whelchel R L, Sanders T H, Thadhani N N 2014 Scr. Mater. 92 59
[17]	Curran D R, Seaman L, Shockey D A 1987 Phys. Rep. 147 253
[18]	Qi M L, Luo C, He H L, Wang Y G, Fan D, Yan S L 2012 J. Appl. Phys. 111 043506
[19]	Kondrokhina I N, Podurets A M, Ignatova O N, Nadezhin S S, Skokov V I, Malyshev A N,Bat'kov Y V 2012 19th European Conference on Fracture p1
[20]	Bontaz-Carion J, Pellegrini Y 2006 Adv. Eng. Mater. 8 480
[21]	Qi M L, Zhong S, He H L, Fan D, Zhao L 2013 Chin. Phys. B 22 046203
[22]	Peng H, Li P, Pei X Y, He H L, Cheng H P, Qi M L 2013 Acta Phys. Sin. 62 226201 (in Chinese) [彭辉, 李平, 裴晓阳, 贺红亮, 程和平, 祁美兰 2013 物理学报 62 226201]
[23]	Qi M L, Bie B X, Zhao F P, Hu C M, Fan D, Ran X X, Xiao X H, Yang W G, Li P, Luo S N 2014 AIP Advances 4 077118
[24]	Peng H, Li P, Pei X Y, He H L, Qi M L 2013 Opt. Pre. Eng. 21 3008 (in Chinese) [彭辉, 李平, 裴晓阳, 贺红亮, 祁美兰 2013 光学精密工程 21 3008]
[25]	Williams C L 2012 Ph. D. Dissertation (Baltimore, Maryland: Johns Hopkins University)
[26]	Tuler F R, Butcher B M 1968 Int. J. Fracture 4 431
[27]	Molinari A, Wright T W 2005 J. Mech. Phy. Solids 53 1476
[28]	Strachan A, Çaín T, Goddard W 2001 Phys. Rev. B 63 060103
[29]	Belak J 1998 J. Comput.-Aided Mater. 5 193
[30]	Reina C, Marian J, Ortiz M 2011 Phys. Rev. B 84 104117
[31]	Pei X Y 2013 Ph. D. Dissertation (Mianyang: China Academy of Engineering Physics) (in Chinese) [裴晓阳 2013 博士学位论文 (绵阳: 中国工程物理研究院)]

[1]	Liu Jun, Wang Pei, Sun Zhi-Yuan, Zhang Feng-Guo, He An-Min. Approximate theoretical analysis of gas penetration in metal micro spallation. Acta Physica Sinica, 2021, 70(9): 098301. doi: 10.7498/aps.70.20201145
[2]	Lin Qian, Xie Pu-Chu, Hu Jian-Bo, Zhang Feng-Guo, Wang Pei, Wang Yong-Gang. Numerical simulation on dynamic damage evolution of high pure copper with different grain sizes. Acta Physica Sinica, 2021, 70(20): 204601. doi: 10.7498/aps.70.20210726
[3]	Li Bi-Yong, Peng Jian-Xiang, Gu Yan, He Hong-Liang. Experimental research on Rayleigh-Taylor instability of oxygen-free high conductivity copper under explosive loading. Acta Physica Sinica, 2020, 69(9): 094701. doi: 10.7498/aps.69.20191999
[4]	Zhu Qi, Wang Sheng-Tao, Zhao Fu-Qi, Pan Hao. Effect of stacking fault tetrahedron on spallation of irradiated Cu via molecular dynamics study. Acta Physica Sinica, 2020, 69(3): 036201. doi: 10.7498/aps.69.20191425
[5]	Zhang Feng-Guo, Liu Jun, He An-Min, Wang Pei, Wang Kun, Zhou Hong-Qiang, Zhao Fu-Qi. Method of determining parameters of void growth damage model and its application to simulation of spall test. Acta Physica Sinica, 2020, 69(20): 204601. doi: 10.7498/aps.69.20200527
[6]	Xie Pu-Chu, Wang Xiao-Song, Hu Chang-Ming, Hu Jian-Bo, Zhang Feng-Guo, Wang Yong-Gang. Incipient spallation of high purity copper under non-one-dimensional strain shock waves. Acta Physica Sinica, 2020, 69(3): 034601. doi: 10.7498/aps.69.20191104
[7]	Pei Xiao-Yang, Peng Hui, He Hong-Liang, Li Ping. Study on the effect of peak stress on dynamic damage evolution of high pure copper. Acta Physica Sinica, 2015, 64(5): 054601. doi: 10.7498/aps.64.054601
[8]	Ye Yang, Wang Shu-Lin. Characteristics of micro fine copper particles impact damping. Acta Physica Sinica, 2014, 63(22): 224304. doi: 10.7498/aps.63.224304
[9]	Zhang Feng-Guo, Zhou Hong-Qiang. Effects of grain size on the dynamic tensile damage of ductile polycrystalline metall. Acta Physica Sinica, 2013, 62(16): 164601. doi: 10.7498/aps.62.164601
[10]	Sun Zhan-Feng, He Hong-Liang, Li Ping, Li Qing-Zhong. The spall strength and shock compressive damage of AD95 ceramics. Acta Physica Sinica, 2012, 61(9): 096201. doi: 10.7498/aps.61.096201
[11]	Yu Quan-Zhi, Yin Wen, Liang Tian-Jiao. Calculation and analysis of DPA in the main components of CSNS target station. Acta Physica Sinica, 2011, 60(5): 052501. doi: 10.7498/aps.60.052501
[12]	Han Jing-Hua, Feng Guo-Ying, Yang Li-Ming, Zhang Qiu-Hui, Fu Yu-Qing, Niu Rui-Hua, Zhu Qi-Hua, Xie Xu-Dong, Zhou Shou-Huan. Influence of the high-repetition-pulsed laser beam size on the damage characteristics of absorbing glass. Acta Physica Sinica, 2011, 60(2): 028106. doi: 10.7498/aps.60.028106
[13]	Wang Yong-Gang, Hu Jian-Dong, Qi Mei-Lan, He Hong-Liang. Simulation of incipient spallation experiments of high purity aluminum based on a single void growth model. Acta Physica Sinica, 2011, 60(12): 126201. doi: 10.7498/aps.60.126201
[14]	Zhang Feng-Guo, Zhou Hong-Qiang, Zhang Guang-Cai, Hong Tao. Inertial and elastic-plastic effect on spallationdamage of ductile metals. Acta Physica Sinica, 2011, 60(7): 074601. doi: 10.7498/aps.60.074601
[15]	Wang Yong-Gang, He Hong-Liang, Boustie Michel, Sekine Toshimori. Experimental studies of spallation in nanocrystalline copper film by laser irradiation. Acta Physica Sinica, 2008, 57(1): 411-415. doi: 10.7498/aps.57.411
[16]	Liang Li-Ping, Zhang Lei, Sheng Yong-Gang, Xu Yao, Wu Dong, Sun Yu-Han, Jiang Xiao-Dong, Wei Xiao-Feng. Studies on the laser-induced damage resistance of sol-gel derived ZrO2-TiO2 composite high refractive index films. Acta Physica Sinica, 2007, 56(6): 3596-3601. doi: 10.7498/aps.56.3596
[17]	Xiong Jun－jiang, Gao Zhen－tong, Liu Xian－bin, Sun Xun－fang. On Stochastic Bifurcation Behavior of the Atom Movement at the Tip of a Crack in Fatigue Damage System. Acta Physica Sinica, 2000, 49(1): 49-53. doi: 10.7498/aps.49.49
[18]	Chen Zu-Yao, Tang Kai-Bin, Qian Yi-Tai, Sheng Zheng-Zhi, Wang Lu-Min. . Acta Physica Sinica, 1995, 44(5): 795-805. doi: 10.7498/aps.44.795
[19]	DING E-JIANG, HUANG ZU-QIA. ON THE SINGULAR PERTURBATION SOLUTION OF BOLTZMANN EQUATION (Ⅱ) "INITIAL LAYER" SOLUTION. Acta Physica Sinica, 1985, 34(1): 77-87. doi: 10.7498/aps.34.77
[20]	CHOU PANG-HSIN, YEN MING-KAO. THE EFFECT OF PHOSPHOROUS ON THE RECRYSTALLIZATION BEHAVIOR OF COLD-ROLLED COPPER STRIPS. Acta Physica Sinica, 1963, 19(10): 633-648. doi: 10.7498/aps.19.633

Catalog

Vol. 64, Issue 21 - 2015-11-05

Metrics

Abstract views: 5078
PDF Downloads: 213
Cited By: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

Search

Article

留言板