搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

直流老化及热处理对ZnO压敏陶瓷缺陷结构的影响

赵学童 李建英 贾然 李盛涛

引用本文:
Citation:

直流老化及热处理对ZnO压敏陶瓷缺陷结构的影响

赵学童, 李建英, 贾然, 李盛涛

The Effect of DC degradation and heat-treatment on defects in ZnO varistor

Zhao Xue-Tong, Li Jian-Ying, Jia Ran, Li Sheng-Tao
PDF
导出引用
  • 在电场为3.2 kV/cm, 电流密度为50 mA/cm2条件下对ZnO压敏陶瓷进行了115 h的直流老化, 研究了直流老化对ZnO压敏陶瓷电气性能及缺陷结构的影响. 发现直流老化115 h 后ZnO压敏陶瓷的电位梯度、非线性系数分别从2845 V/cm, 38.3下降到51.6 V/cm, 1.1, 介电损耗中的缺陷松弛峰被增大的直流电导掩盖, 电模量中只观察到一个缺陷松弛峰, 低频区交流电导率急剧增大并且相应的电导活化能从0.84 eV下降到只有0.083 eV. 通过对直流老化后的ZnO压敏陶瓷在800 ℃进行12 h 的热处理, 发现其电气性能和介电性能都得到了良好的恢复并有一定的增强, 电位梯度、非线性系数恢复到3085 V/cm, 50.8, 电导活化能上升到0.88 eV. 另外, 其本征氧空位缺陷松弛峰也得到了一定的抑制. 因此, 认为热处理过程中氧在晶界处的扩散作用对ZnO压敏陶瓷的直流老化恢复起到了关键作用.
    In this research, DC degradation for ZnO varistors at 3.2 kV/cm and 50 mA/cm2 for 115 hours was performed, and its effect on electrical properties and defects of ZnO varistors was investigated. It was found that the breakdown field and nonlinear coefficient drops sharply from 2845 V/cm to 51.6 V/cm and 38.3 to 1.1, respectively, when the DC degradaion time reaches 115 hours. For the degraded sample, the dielectric loss was dominated by the increase of conductivity so that some defect relaxation peaks cannot be observed is the DC degraded ZnO varistors. However, in electrical modulus plot, one relaxation peak can be observed. The conductivity in low frequency range increases greatly and the conductance activation energy drops from 0.84 to 0.083 eV. Additionally, the heat-treatment process of ZnO varistors at 800 ℃ for 24 hours was also performed. It is interesting to note that the electrical properties and the relaxation processes of ZnO varistor is restorable completely again after heat-treatment. The breakdown field and the nonlinear coefficient increase to 3085 V/cm and 50.8, respectively, and the activation energy of conductance increases to 0.88 eV. It is also found that the defect relaxation peak, which is shown in dielectric spectra corresponding to oxygen vacancy defect, is suppressed evidently by heat-retreating. Therefore, it is proposed that oxygen is likely to diffuse into the ZnO grain boundaries at the heat-treatment process, which can play an important role in restorability of the DC degraded ZnO varistor.
    • 基金项目: 国家自然科学基金 (批准号: 50977071, 51177121) 资助的课题.
    • Funds: Project supported by the National Natural Science Foundation of China (Grant Nos. 50977071, 51177121).
    [1]

    Gupta T K, Straub W D 1989 J. Appl. Phys. 66 6132

    [2]

    Xu D, Shi L Y, Wu Z H, Zhong Q D, Wu X X 2009 J. Eur. Ceram. Soc. 29 1789

    [3]

    Zhao K Y, Zeng H R, Li G R, Song H Z, Cheng L H, Hui S X, Yin Q R 2009 Chin. Phys. Lett. 26 100701

    [4]

    Li S T, Yang Y, Zhang L, Cheng P F, Li J Y 2009 Chin. Phys. Lett. 26 077201

    [5]

    Zhao X T, Li J Y, Li H, Li S T 2012 Acta Phys. Sin. 61 153103 (in Chinese) [赵学童, 李建英, 李欢, 李盛涛 2012 物理学报 61 153103]

    [6]

    Wang Y P, Cheng P F 2010 Insulators and Surge Arresters 4 34 (in Chinese) [王玉平, 成鹏飞 2010 电瓷避雷器 4 34]

    [7]

    Gupta T K 1990 J. Am. Ceram. Soc. 73 1817

    [8]

    Li S T, Cheng P F, Wang Y P 2008 Insulators and Surge Arresters 4 16 (in Chinese) [李盛涛, 成鹏飞, 王玉平, 朱斌 2008 电瓷避雷器 4 16]

    [9]

    Yin G L, Li J Y, Yao G, Cheng P F, Li S T 2010 Acta Phys. Sin. 59 6345 (in Chinese) [尹桂来, 李建英, 尧广, 成鹏飞, 李盛涛 2010 物理学报 59 6345]

    [10]

    Chen J D, Liu Z Y 1982 Dielectric Physics (Beijing: Mechanical Industry Press) p151 (in Chinese) [陈季丹, 刘子玉 1982 电介质物理学 (北京: 机械工业出版社) 第151页]

    [11]

    Jonscher A K 1996 Universal Relaxation Law (London: Chelsea Dielectrics Press)

    [12]

    Tripathi R, Kumar A, Bharti C, Sinha T P 2010 Curr. Appl. Phys. 10 676

    [13]

    Roling B, Happe A, Funke K, Ingram M D 1997 Phys. Rev. Lett. 78 2160

    [14]

    Yin G L, Li J Y, Li S T 2009 Acta Phys. Sin. 58 4219 (in Chinese) [尹桂来, 李建英, 李盛涛2009 物理学报 58 4219]

    [15]

    Cheng P F, Li S T, Li J Y 2009 Acta Phys. Sin. 58 5721 (in Chinese) [成鹏飞, 李盛涛, 李建英 2009 物理学报 58 5721]

    [16]

    Cheng P, Li S, Zhang L, Li J 2008 Appl. Phys. Lett. 93 012902

    [17]

    Zhao X T, Li J Y, Li S T 2012 J. Appl. Phys. 111 124106

    [18]

    Greuter F 1995 Solid State Ionics 75 67

    [19]

    Li J Y, Li S T, Liu F Y, Alim M A 2006 J Mater Sci: Mater Electron 17 211

    [20]

    Sinclair D C, West A R 1989 J. Appl. Phys. 66 3850

  • [1]

    Gupta T K, Straub W D 1989 J. Appl. Phys. 66 6132

    [2]

    Xu D, Shi L Y, Wu Z H, Zhong Q D, Wu X X 2009 J. Eur. Ceram. Soc. 29 1789

    [3]

    Zhao K Y, Zeng H R, Li G R, Song H Z, Cheng L H, Hui S X, Yin Q R 2009 Chin. Phys. Lett. 26 100701

    [4]

    Li S T, Yang Y, Zhang L, Cheng P F, Li J Y 2009 Chin. Phys. Lett. 26 077201

    [5]

    Zhao X T, Li J Y, Li H, Li S T 2012 Acta Phys. Sin. 61 153103 (in Chinese) [赵学童, 李建英, 李欢, 李盛涛 2012 物理学报 61 153103]

    [6]

    Wang Y P, Cheng P F 2010 Insulators and Surge Arresters 4 34 (in Chinese) [王玉平, 成鹏飞 2010 电瓷避雷器 4 34]

    [7]

    Gupta T K 1990 J. Am. Ceram. Soc. 73 1817

    [8]

    Li S T, Cheng P F, Wang Y P 2008 Insulators and Surge Arresters 4 16 (in Chinese) [李盛涛, 成鹏飞, 王玉平, 朱斌 2008 电瓷避雷器 4 16]

    [9]

    Yin G L, Li J Y, Yao G, Cheng P F, Li S T 2010 Acta Phys. Sin. 59 6345 (in Chinese) [尹桂来, 李建英, 尧广, 成鹏飞, 李盛涛 2010 物理学报 59 6345]

    [10]

    Chen J D, Liu Z Y 1982 Dielectric Physics (Beijing: Mechanical Industry Press) p151 (in Chinese) [陈季丹, 刘子玉 1982 电介质物理学 (北京: 机械工业出版社) 第151页]

    [11]

    Jonscher A K 1996 Universal Relaxation Law (London: Chelsea Dielectrics Press)

    [12]

    Tripathi R, Kumar A, Bharti C, Sinha T P 2010 Curr. Appl. Phys. 10 676

    [13]

    Roling B, Happe A, Funke K, Ingram M D 1997 Phys. Rev. Lett. 78 2160

    [14]

    Yin G L, Li J Y, Li S T 2009 Acta Phys. Sin. 58 4219 (in Chinese) [尹桂来, 李建英, 李盛涛2009 物理学报 58 4219]

    [15]

    Cheng P F, Li S T, Li J Y 2009 Acta Phys. Sin. 58 5721 (in Chinese) [成鹏飞, 李盛涛, 李建英 2009 物理学报 58 5721]

    [16]

    Cheng P, Li S, Zhang L, Li J 2008 Appl. Phys. Lett. 93 012902

    [17]

    Zhao X T, Li J Y, Li S T 2012 J. Appl. Phys. 111 124106

    [18]

    Greuter F 1995 Solid State Ionics 75 67

    [19]

    Li J Y, Li S T, Liu F Y, Alim M A 2006 J Mater Sci: Mater Electron 17 211

    [20]

    Sinclair D C, West A R 1989 J. Appl. Phys. 66 3850

  • [1] 杨如霞, 卢玉明, 曾丽竹, 张禄佳, 李冠男. 钆掺杂对0.7BiFe0.95Ga0.05O3-0.3BaTiO3陶瓷的结构、介电性能和多铁性能的影响. 物理学报, 2020, 69(10): 107701. doi: 10.7498/aps.69.20200175
    [2] 黄禹田, 王煜, 朱敏敏, 吕婷, 杨洪春, 李翔, 王秀章, 刘美风, 李少珍. (1-x)Sr3Sn2O7+xCa3Mn2O7陶瓷合成及其光电性能. 物理学报, 2018, 67(15): 154203. doi: 10.7498/aps.67.20180954
    [3] 赵小强, 赵学童, 许超, 李巍巍, 任路路, 廖瑞金, 李建英. ZnO-Bi2O3系压敏陶瓷缺陷弛豫特性的研究进展. 物理学报, 2017, 66(2): 027701. doi: 10.7498/aps.66.027701
    [4] 赵学童, 廖瑞金, 李建英, 王飞鹏. 直流老化对CaCu3Ti4O12陶瓷介电性能的影响. 物理学报, 2015, 64(12): 127701. doi: 10.7498/aps.64.127701
    [5] 贾晓琴, 何智兵, 牛忠彩, 何小珊, 韦建军, 李蕊, 杜凯. 热处理对制备辉光放电聚合物薄膜结构及光学性能的影响. 物理学报, 2013, 62(5): 056804. doi: 10.7498/aps.62.056804
    [6] 王辉, 蔺家骏, 何锦强, 廖永力, 李盛涛. 沉淀剂对ZnO压敏陶瓷缺陷结构和电气性能的影响. 物理学报, 2013, 62(22): 226103. doi: 10.7498/aps.62.226103
    [7] 赵学童, 李建英, 李欢, 李盛涛. ZnO压敏陶瓷缺陷结构表征及冲击老化机理研究. 物理学报, 2012, 61(15): 153103. doi: 10.7498/aps.61.153103
    [8] 成鹏飞, 李盛涛, 李建英. ZnO压敏陶瓷的介电谱. 物理学报, 2012, 61(18): 187302. doi: 10.7498/aps.61.187302
    [9] 於黄忠, 周晓明, 邓俊裕. 热处理对不同溶剂制备的共混体系太阳电池性能影响. 物理学报, 2011, 60(7): 077206. doi: 10.7498/aps.60.077206
    [10] 丁南, 唐新桂, 匡淑娟, 伍君博, 刘秋香, 何琴玉. 锰掺杂对Ba(Zr, Ti)O3陶瓷压电与介电性能的影响. 物理学报, 2010, 59(9): 6613-6619. doi: 10.7498/aps.59.6613
    [11] 尹桂来, 李建英, 尧广, 成鹏飞, 李盛涛. ZnO压敏陶瓷冲击老化的电子陷阱过程研究. 物理学报, 2010, 59(9): 6345-6350. doi: 10.7498/aps.59.6345
    [12] 李盛涛, 成鹏飞, 杨雁, 张乐. ZnO压敏陶瓷电导研究的新方法. 物理学报, 2009, 58(4): 2543-2548. doi: 10.7498/aps.58.2543
    [13] 成鹏飞, 李盛涛, 李建英. ZnO压敏陶瓷介电损耗的温度谱研究. 物理学报, 2009, 58(8): 5721-5725. doi: 10.7498/aps.58.5721
    [14] 李盛涛, 成鹏飞, 赵雷, 李建英. ZnO压敏陶瓷中缺陷的介电谱研究. 物理学报, 2009, 58(1): 523-528. doi: 10.7498/aps.58.523
    [15] 成鹏飞, 李盛涛, 焦兴六. ZnO-Bi2O3系压敏陶瓷的导电过程与等效势垒高度. 物理学报, 2006, 55(8): 4253-4258. doi: 10.7498/aps.55.4253
    [16] 赵苏串, 李国荣, 张丽娜, 王天宝, 丁爱丽. Na0.25K0.25Bi0.5TiO3无铅压电陶瓷的介电特性研究. 物理学报, 2006, 55(7): 3711-3715. doi: 10.7498/aps.55.3711
    [17] 曾 涛, 董显林, 毛朝梁, 梁瑞虹, 杨 洪. 孔隙率及晶粒尺寸对多孔PZT陶瓷介电和压电性能的影响及机理研究. 物理学报, 2006, 55(6): 3073-3079. doi: 10.7498/aps.55.3073
    [18] 张丽娜, 赵苏串, 郑嘹赢, 李国荣, 殷庆瑞. 复合层状Bi7Ti4NbO21铁电陶瓷的结构与介电和压电性能研究. 物理学报, 2005, 54(5): 2346-2351. doi: 10.7498/aps.54.2346
    [19] 刘鹏, 姚熹. La调节Pb(Zr,Sn,Ti)O_3反铁电陶瓷的相变与电学性质. 物理学报, 2002, 51(7): 1621-1627. doi: 10.7498/aps.51.1621
    [20] 刘鹏, 边小兵, 张良莹, 姚熹. (PbBa)(Zr,Sn,Ti)O_3反铁电/弛豫型铁电相界陶瓷的相变与介电、热释电性质. 物理学报, 2002, 51(7): 1628-1633. doi: 10.7498/aps.51.1628
计量
  • 文章访问数:  5662
  • PDF下载量:  732
  • 被引次数: 0
出版历程
  • 收稿日期:  2012-10-12
  • 修回日期:  2012-11-22
  • 刊出日期:  2013-04-05

/

返回文章
返回