搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

氢气引入对宽光谱Mg和Ga共掺杂ZnO透明导电薄膜的特性影响

田淙升 陈新亮 刘杰铭 张德坤 魏长春 赵颖 张晓丹

引用本文:
Citation:

氢气引入对宽光谱Mg和Ga共掺杂ZnO透明导电薄膜的特性影响

田淙升, 陈新亮, 刘杰铭, 张德坤, 魏长春, 赵颖, 张晓丹

Influence of H2 introduction on wide-spectrum Mg and Ga co-doped ZnO transparent conductive thin films

Tian Cong-Sheng, Chen Xin-Liang, Liu Jie-Ming, Zhang De-Kun, Wei Chang-Chun, Zhao Ying, Zhang Xiao-Dan
PDF
导出引用
  • 为适应宽光谱高效率硅基薄膜太阳电池的应用需求,本文尝试采用直流磁控溅射技术在553 K衬底温度下生长氢化Mg和Ga共掺杂ZnO(HMGZO)透明导电氧化物(TCO)薄膜. 通过对薄膜微观结构、表面形貌、电学以及光学性能的测试和分析,详细地研究了氢气(H2)流量(0–16.0 sccm)对HMGZO薄膜结晶特性及光电性能的影响. 实验结果表明:生长获得的HMGZO薄膜均为六角纤锌矿结构的多晶薄膜,择优取向为(002)晶面生长方向. 薄膜的生长速率随着氢气流量的增加呈现逐渐减小趋势,主要归因于溅射产额的减小. 适当的氢气引入会引起晶粒尺寸的增加. 随着氢气流量由0增加至4.0 sccm,ZnO 薄膜电阻率从177 Ω·cm急剧减小至7.2×10-3 Ω·cm,主要是由于H施主的引入显著地增加了载流子浓度;然而进一步增加氢气流量(4.0–16.0 sccm)造成电阻率的轻微增加,主要归因于载流子浓度的减小以及过多氢杂质引入造成杂质散射的增加. 所有生长获得的HMGZO薄膜平均光学透过率在波长λ~320–1100 nm范围内可达87%以上. 由于Mg的作用及Burstein-Moss效应的影响造成了带隙展宽,带隙变化范围~3.49–3.70 eV,其中最大光学带隙Eg可达~3.70 eV.
    To meet the demands of high efficient silicon thin film solar cells, transparent conductive hydrogenated Mg and Ga co-doped ZnO (HMGZO) thin films were deposited via pulsed direct current (DC) magnetron sputtering on glass substrates at a substrate temperature of 553 K. The micro-structural, morphological, electrical, and optical properties of HMGZO thin films were investigated at various H2 flow rates. Experimental results show that all the HMGZO thin films are polycrystalline with a hexagonal wurtzite structure exhibiting a preferred (002) crystal plane orientation. Appropriate H2 flow rate increases grain size and also enhances the RMS roughness. The deposition rate of HMGZO films decreases with the increase of H2 flow rate due to the decrease of sputtering yield. Resistivity of HMGZO thin films decreases rapidly from 117 to 7.2×10-3 Ω·cm with increasing H2 flow rate from 0 to 4.0 sccm. With further increasing H2 flow rate (4.0–16.0 sccm), the resistivity increases slightly due to the reduced carrier concentration and excessive H atoms as impurity. Optical transmittance of all the HMGZO thin films is higher than 87.7% in the wavelength range from 320 to 1100 nm. Burstein-Moss band-filling determined by carrier concentrations and the incorporation of Mg atoms together contribute to the band-gap (Eg) widening phenomenon. The band gap Eg varies from ~ 3.49–3.70 eV and the maximum Eg of 3.70 eV is obtained at a H2 flow rate of 16.0 sccm.
    • 基金项目: 国家重点基础研究发展计划(批准号:2011CBA00705,2011CBA00706,2011CBA00707)、天津市应用基础及前沿技术研究计划(批准号:13JCZDJC26900)、天津市重大科技支撑计划项目(批准号:11TXSYGX22100)、国家高技术研究发展计划(批准号:2013AA050302)和中央高校基本科研业务费专项资金(批准号:65010341)资助的课题.
    • Funds: Project supported by the State Key Development Program for Basic Research of China (Grant Nos. 2011CBA00705, 2011CBA00706, 2011CBA00707), the Tianjin Applied Basic Research Project and Cutting-edge Technology Research Plan, China (Grant No. 13JCZDJC26900), the Tianjin Major Science and Technology Support Project, China (Grant No. 11TXSYGX22100), the National High Technology Research and Development Program of China (Grant No. 2013AA050302), and the Fundamental Research Funds for the Central Universities of China (Grant No. 65010341).
    [1]

    Burroughes J H, Bradley D D C, Brown A R, Marks R N, Mackay K, Friend R H, Burns P L, Holmes A B 1990 Nature 347 539

    [2]

    Li H, Wang N, Liu X 2008 Opt. Express 16 194

    [3]

    Mller J, Rech B, Springer J, Vanecek M 2004 Sol. Energy 77 917

    [4]

    Yu X M, Zhao J, Hou G F, Zhang J J, Zhang X D, Zhao Y 2013 Acta Phys. Sin. 62 120101 (in Chinese) [于晓明, 赵静, 侯国付, 张建军, 张晓丹, 赵颖 2013 物理学报 62 120101]

    [5]

    Wang G H, Zhao L, Yan B J, Chen J W, Wang G, Diao H W, Wang W J 2013 Chin. Phys. B 22 68102

    [6]

    Fan H B, Zheng X L, Wu S C, Liu Z G, Yao H B 2012 Chin. Phys. B 21 38101

    [7]

    Zhang C, Cheng X L, Wang F, Yan C B, Huang Q, Zhao Y, Zhang X D, Geng X H 2012 Acta Phys. Sin. 61 238101 [张翅, 陈新亮, 王斐, 闫聪博, 黄茜, 赵颖, 张晓丹, 耿新华 2012 物理学报 61 238101]

    [8]

    Moss T S 1954 Proc. Phys. Soc. Sect. B 67 775

    [9]

    Burstein E 1954 Phys. Rev. 93 632

    [10]

    Wang F, Chen X L, Geng X H, Zhang D K, Wei C C, Huang Q, Zhang X D, Zhao Y 2012 Appl. Surf. Sci. 258 9005

    [11]

    Jang S H, Chichibu S F 2012 J. Appl. Phys. 112 073503

    [12]

    Shin S W, Kim I Y, Lee G H, Agawane G L, Mohokar A V, Heo G S, Kim J H, Lee J Y 2011 Cryst. Growth Des. 11 4819

    [13]

    Gu X, Zhu L, Ye Z, Ma Q, He H, Zhang Y, Zhao B 2008 Sol. Energy Mater. Sol. Cells 92 343

    [14]

    Matsubara K, Tampo H, Shibata H, Yamada A, Fons P, Iwata K, Niki S 2004 Appl. Phys. Lett. 85 1374

    [15]

    Cohen D J, Ruthe K C, Barnett S A 2004 J. Appl. Phys. 96 459

    [16]

    Duenow J N, Gessert T A, Wood D M, Young D L, Coutts T J 2008 J. Non-cryst. Solids. 354 2787

    [17]

    Park Y R, Kim J, Kim Y S 2009 Appl. Surf. Sci. 255 9010

    [18]

    Van De Walle C G 2000 Phys. Rev. Lett. 85 1012

    [19]

    Van De Walle C G, Neugebauer J 2003 Nature 423 626

    [20]

    Janotti A, Van De Walle C G 2007 Nature Mater. 6 44

    [21]

    Lavrov E V, Börrnert F, Weber J 2006 Physica B 376-377 694

    [22]

    Shi G A, Stavola M, Pearton S J, Thieme M, Lavrov E V, Weber J 2005 Phys. Rev. B 72 195211

    [23]

    Zhou Z, Kato K, Komaki T, Yoshino M, Yukawa H, Morinaga M 2004 Int. J. Hydrogen Energ 29 323

    [24]

    Tark S J, Ok Y W, Kang M G, Lim H J, Kim W M, Kim D 2009 J. Electroceram. 23 548

    [25]

    Song D, Aberle A G, Xia J 2002 Appl. Surf. Sci. 195 291

    [26]

    Prasada Rao T, Santhosh Kumar M C, Sooraj Hussain N 2012 J. Alloy. Compd. 541 495

    [27]

    Zhang X D, Guo M L, Liu C L, Zhang L A, Zhang W Y, Ding Y Q, Wu Q, Feng X 2008 Eur. Phys. J. B 62 417

  • [1]

    Burroughes J H, Bradley D D C, Brown A R, Marks R N, Mackay K, Friend R H, Burns P L, Holmes A B 1990 Nature 347 539

    [2]

    Li H, Wang N, Liu X 2008 Opt. Express 16 194

    [3]

    Mller J, Rech B, Springer J, Vanecek M 2004 Sol. Energy 77 917

    [4]

    Yu X M, Zhao J, Hou G F, Zhang J J, Zhang X D, Zhao Y 2013 Acta Phys. Sin. 62 120101 (in Chinese) [于晓明, 赵静, 侯国付, 张建军, 张晓丹, 赵颖 2013 物理学报 62 120101]

    [5]

    Wang G H, Zhao L, Yan B J, Chen J W, Wang G, Diao H W, Wang W J 2013 Chin. Phys. B 22 68102

    [6]

    Fan H B, Zheng X L, Wu S C, Liu Z G, Yao H B 2012 Chin. Phys. B 21 38101

    [7]

    Zhang C, Cheng X L, Wang F, Yan C B, Huang Q, Zhao Y, Zhang X D, Geng X H 2012 Acta Phys. Sin. 61 238101 [张翅, 陈新亮, 王斐, 闫聪博, 黄茜, 赵颖, 张晓丹, 耿新华 2012 物理学报 61 238101]

    [8]

    Moss T S 1954 Proc. Phys. Soc. Sect. B 67 775

    [9]

    Burstein E 1954 Phys. Rev. 93 632

    [10]

    Wang F, Chen X L, Geng X H, Zhang D K, Wei C C, Huang Q, Zhang X D, Zhao Y 2012 Appl. Surf. Sci. 258 9005

    [11]

    Jang S H, Chichibu S F 2012 J. Appl. Phys. 112 073503

    [12]

    Shin S W, Kim I Y, Lee G H, Agawane G L, Mohokar A V, Heo G S, Kim J H, Lee J Y 2011 Cryst. Growth Des. 11 4819

    [13]

    Gu X, Zhu L, Ye Z, Ma Q, He H, Zhang Y, Zhao B 2008 Sol. Energy Mater. Sol. Cells 92 343

    [14]

    Matsubara K, Tampo H, Shibata H, Yamada A, Fons P, Iwata K, Niki S 2004 Appl. Phys. Lett. 85 1374

    [15]

    Cohen D J, Ruthe K C, Barnett S A 2004 J. Appl. Phys. 96 459

    [16]

    Duenow J N, Gessert T A, Wood D M, Young D L, Coutts T J 2008 J. Non-cryst. Solids. 354 2787

    [17]

    Park Y R, Kim J, Kim Y S 2009 Appl. Surf. Sci. 255 9010

    [18]

    Van De Walle C G 2000 Phys. Rev. Lett. 85 1012

    [19]

    Van De Walle C G, Neugebauer J 2003 Nature 423 626

    [20]

    Janotti A, Van De Walle C G 2007 Nature Mater. 6 44

    [21]

    Lavrov E V, Börrnert F, Weber J 2006 Physica B 376-377 694

    [22]

    Shi G A, Stavola M, Pearton S J, Thieme M, Lavrov E V, Weber J 2005 Phys. Rev. B 72 195211

    [23]

    Zhou Z, Kato K, Komaki T, Yoshino M, Yukawa H, Morinaga M 2004 Int. J. Hydrogen Energ 29 323

    [24]

    Tark S J, Ok Y W, Kang M G, Lim H J, Kim W M, Kim D 2009 J. Electroceram. 23 548

    [25]

    Song D, Aberle A G, Xia J 2002 Appl. Surf. Sci. 195 291

    [26]

    Prasada Rao T, Santhosh Kumar M C, Sooraj Hussain N 2012 J. Alloy. Compd. 541 495

    [27]

    Zhang X D, Guo M L, Liu C L, Zhang L A, Zhang W Y, Ding Y Q, Wu Q, Feng X 2008 Eur. Phys. J. B 62 417

计量
  • 文章访问数:  4506
  • PDF下载量:  928
  • 被引次数: 0
出版历程
  • 收稿日期:  2013-07-13
  • 修回日期:  2013-10-22
  • 刊出日期:  2014-02-05

/

返回文章
返回