搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

冲击波作用下微米尺度金属颗粒群的动力学行为

赵信文 李欣竹 张航 王学军 宋萍 张汉钊 康强 黄金 吴强

引用本文:
Citation:

冲击波作用下微米尺度金属颗粒群的动力学行为

赵信文, 李欣竹, 张航, 王学军, 宋萍, 张汉钊, 康强, 黄金, 吴强

Dynamical behaviors of Sn micro-sphere particles under shock wave action

Zhao Xin-Wen, Li Xin-Zhu, Zhang Hang, Wang Xue-Jun, Song Ping, Zhang Han-Zhao, Kang Qiang, Huang Jin, Wu Qiang
PDF
导出引用
  • 基于平面化爆驱动飞片高压加载技术和激光测速技术,研究了冲击波加载不同粒径锡颗粒群的微喷射行为以及在空气中的减速规律.实验结果表明,锡颗粒的最快喷射速度随粒径增大而显著增大.通过对微喷射形成过程的三维光滑粒子流体动力学方法数值模拟发现,大粒径锡颗粒之间存在较大的空隙结构,冲击波与空隙结构的相互作用诱导产生高速汇聚射流,空隙结构越大对应的喷射速度也越高.此外,通过研究不同粒径颗粒在复杂流场中的减速规律,进一步深化了对微喷射破碎后的颗粒尺度状态以及混合输运特性的认识.研究结果对于预测和分析冲击波加载微米颗粒群的微喷混合特性具有一定价值.
    In these decades, the turbulence mixing of micro-ejecta particles and gas has attracted considerable attention because it has great influence on inertial confinement fusion and some technologies of optical detection. It is significantly important for studying the evolution of micro-ejecta by investigating the influence of particle size and the transporting progress. In this paper, we experimentally investigate the micro-ejecta dynamical behaviors when a strong shockwave acts on Sn micro-sphere particles with different sizes of 0.1 μm, 1 μm, 5 μm and 10 μm. A strict experiment is carried out, in which a thin Ta flyer is accelerated by TNT explosion to load the Sn particles, and the velocity variation of ejecta particles transported in air is measured by the displacement interferometer system for any reflector. The results show that the tip-velocity of the micro-ejecta is very sensitive to the initial size of particle, where the larger size results in increased velocity. By analyzing the results of each case in detail, we discover that the formation of micro-ejecta is caused by the interaction between shockwave and the gap structure among several particles, where the larger gap structure induces faster ejecta tip-velocity. To verify this explanation, the effects of particle size on the ejecta tip-velocity is examined by simulating the cases of 5 μm and 10 μm in particle size through three-dimensional smooth particle hydrodynamics method. The simulated tip-velocity results are in good agreement with the corresponding experimental results. However, the scenario is different when the particle size is smaller than 1 μm, where the experimentally measured tip-velocity of 0.1 μm size particle is nearly the same as that of 1 μm size particle. We attribute this to the fact that the gap structure is too small to affect the micro-ejecta progress and the micro-ejecta is mainly caused by the large scale defects accumulated by a huge number of particles. Furthermore, by comparing with the experimentally measured velocity decay, we also estimate the size distribution of ejecta particles by simulating the decelerating processes of different-sized particles with different initial velocities in gas. This paper is helpful in comprehending in depth the micro-ejecta process caused by the shockwave acting on micro particles, and also in designing such experiments accurately.
      通信作者: 李欣竹, yy_stroller@163.com
    • 基金项目: 科学挑战专题(批准号:JCKY2016212A501)资助的课题.
      Corresponding author: Li Xin-Zhu, yy_stroller@163.com
    • Funds: Project supported by the Science Challenge Project, China (Grant No. JCKY2016212A501).
    [1]

    Walsh J M, Shreffler R G, Willing F J 1953 J. Appl. Phys. 24 349

    [2]

    Asay J R, Mix L P, Perry F C 1976 Appl. Phys. Lett. 29 284

    [3]

    Wang P, Qin C S, Zhang S D, Liu C 2004 Chin. J. High Press. Phys. 18 149 (in Chinese) [王裴,秦承森,张树道,刘超 2004 高压物理学报 18 149]

    [4]

    Buttler W T, Zellner M B, Olson R T, Rigg P A, Hixson R S, Hammerberg J E, Obst A W, Payton J R 2007 J. Appl. Phys. 101 063547

    [5]

    Monfared S K, Oró D M, Grover M, Hammerberg J E, Lalone B M, Pack C L, Schauer M M, Stevens G D, Stone J B, Turley W D, Buttler W T 2014 J. Appl. Phys. 116 063504

    [6]

    Durand O, Soulard L 2013 J. Appl. Phys. 114 194902

    [7]

    Zhang W Y, Ye W H, Wu J F, Miao W Y, Fan Z F, Wang L F, Gu J F, Dai Z S, Cao Z R, Xu X W, Yuan Y T, Kang D G, Li Y S, Yu X J, Liu C L, Xue C, Zheng W D, Wang M, Pei W B, Zhu S P, Jiang S E, Liu S Y, Ding Y K, He X S 2014 Sci. China: Phys. Mech. Astron. 44 1 (in Chinese) [张维岩, 叶文华, 吴俊峰, 缪文勇, 范征锋, 王立锋, 谷建法, 戴振生, 曹柱荣, 徐小文, 袁永腾, 康洞国, 李永升, 郁晓瑾, 刘长礼, 薛创, 郑无敌, 王敏, 裴文兵, 朱少平, 江少恩, 刘慎业, 丁永坤, 贺贤土 2014 中国科学:物理学 44 1]

    [8]

    Zhang C Y, Hu H B, Li Q Z, Yuan S 2009 Chin. J. High Press. Phys. 23 283 (in Chinese) [张崇玉, 胡海波, 李庆忠, 袁帅 2009 高压物理学报 23 283]

    [9]

    Weng J D, Tan H, Wang X, Ma Y, Hu S L, Wang X S 2006 Appl. Phys. Lett. 89 111101

    [10]

    La Lone B M, Marshall B R, Miller E K, Stevens G D, Turley W D, Veeser L R 2015 Rev. Sci. Instrum. 86 023112

    [11]

    Seifter A, Stewart S T, Furlanetto M R, Kennedy G B, Payton J R, Obst A W 2006 AIP Conf. Proc. 845 239

    [12]

    Seifter A, Grover M, Holtkamp D B, Payton J R, Rodriguez P, Turley D, Obst A W 2004 26th International Congress on High-Speed Photography and Photonics Alexandria, Virginia, September 19-24, 2004 p93

    [13]

    Ma Y, Wang X S, Li X Z, Zhang H Z, Hu S L, Li J B, Chen H, Wen J D 2006 Chin. J. High Press. Phys. 20 207 (in Chinese) [马云, 汪小松, 李欣竹, 张汉钊, 胡绍楼, 李加波, 陈宏, 翁继东 2006 高压物理学报 20 207]

    [14]

    Asay J R 1978 J. Appl. Phys. 49 6173

    [15]

    Oró D M, Hammerberg J E, Buttler W T, Mariam F G, Morris C, Rousculp C, Stone J B 2012 AIP Conf. Proc. 1426 1351

    [16]

    Rousculp C L, Oro D M, Morris C, Saunders A, Reass W, Griego J R, Turchi P J, Reinovsky R E https://www.osti.gov/scitech/biblio/1178310/ [2015-4-20]

    [17]

    Liu G R, Liu M B 2003 Smoothed Particle Hydrodynamics: A Meshfree Particle Methods (Singapore: World Scientific) pp309-339

    [18]

    Wang P, Qin C S, Zhang S D, Liu C 2004 Chin. J. High Press. Phys. 18 149 (in Chinese) [王裴, 秦承森, 张树道, 刘超 2004 高压物理学报 18 149]

    [19]

    Monfared S K, Buttler W T, Frayer D K, Grover M, LaLone B M, Stevens G D, Stone J B, Turley W D, Schauer M M 2015 J. Appl. Phys. 117 223105

    [20]

    Tan H 2007 Introduction to Experimental Shocked-Wave Physics (Beijing: National Defense Industry Press) pp36-43 (in Chinese) [谭华 2007 实验冲击波物理导引(北京:国防工业出版社)第36—43页]

    [21]

    Zhang S Q, Liu C L, Li Q Z, Liu Q 2008 Acta Mech. Sin. 40 535 (in Chinese) [张世文, 刘仓理, 李庆忠, 刘乔 2008 力学学报 40 535]

    [22]

    Sorenson D S, Pazuchanics P D, Johnson R P, Tunnell T W, Smalley D D, Malone R M, Kaufman M I, Marks D G, Capelle G A, Grover M, Stevens G D, LaLone B M, Marshall B F, Turley W D 2017 AIP Conf. Proc. 1793 100026

    [23]

    Buttler W T, Oró D M, Olson R T, Cherne F J, Hammerberg J E, Hixson R S, Monfared S K, Pack C L, Rigg P A, Stone J B, Terrones G 2014 J. Appl. Phys. 116 103519

    [24]

    Fung J, Harrison A K, Chitanvbs S, Margulies J 2013 Comput. Fluids 83 177

    [25]

    Wang P, Sun H Q, Shao J L, Qin C S, Li X Z 2012 Acta Phys. Sin. 61 234703 (in Chinese) [王裴, 孙海全, 邵建立, 秦承森, 李欣竹 2012 物理学报 61 234703]

    [26]

    Igra O, Takayama K 1993 Proc. R. Soc. London 442 231

  • [1]

    Walsh J M, Shreffler R G, Willing F J 1953 J. Appl. Phys. 24 349

    [2]

    Asay J R, Mix L P, Perry F C 1976 Appl. Phys. Lett. 29 284

    [3]

    Wang P, Qin C S, Zhang S D, Liu C 2004 Chin. J. High Press. Phys. 18 149 (in Chinese) [王裴,秦承森,张树道,刘超 2004 高压物理学报 18 149]

    [4]

    Buttler W T, Zellner M B, Olson R T, Rigg P A, Hixson R S, Hammerberg J E, Obst A W, Payton J R 2007 J. Appl. Phys. 101 063547

    [5]

    Monfared S K, Oró D M, Grover M, Hammerberg J E, Lalone B M, Pack C L, Schauer M M, Stevens G D, Stone J B, Turley W D, Buttler W T 2014 J. Appl. Phys. 116 063504

    [6]

    Durand O, Soulard L 2013 J. Appl. Phys. 114 194902

    [7]

    Zhang W Y, Ye W H, Wu J F, Miao W Y, Fan Z F, Wang L F, Gu J F, Dai Z S, Cao Z R, Xu X W, Yuan Y T, Kang D G, Li Y S, Yu X J, Liu C L, Xue C, Zheng W D, Wang M, Pei W B, Zhu S P, Jiang S E, Liu S Y, Ding Y K, He X S 2014 Sci. China: Phys. Mech. Astron. 44 1 (in Chinese) [张维岩, 叶文华, 吴俊峰, 缪文勇, 范征锋, 王立锋, 谷建法, 戴振生, 曹柱荣, 徐小文, 袁永腾, 康洞国, 李永升, 郁晓瑾, 刘长礼, 薛创, 郑无敌, 王敏, 裴文兵, 朱少平, 江少恩, 刘慎业, 丁永坤, 贺贤土 2014 中国科学:物理学 44 1]

    [8]

    Zhang C Y, Hu H B, Li Q Z, Yuan S 2009 Chin. J. High Press. Phys. 23 283 (in Chinese) [张崇玉, 胡海波, 李庆忠, 袁帅 2009 高压物理学报 23 283]

    [9]

    Weng J D, Tan H, Wang X, Ma Y, Hu S L, Wang X S 2006 Appl. Phys. Lett. 89 111101

    [10]

    La Lone B M, Marshall B R, Miller E K, Stevens G D, Turley W D, Veeser L R 2015 Rev. Sci. Instrum. 86 023112

    [11]

    Seifter A, Stewart S T, Furlanetto M R, Kennedy G B, Payton J R, Obst A W 2006 AIP Conf. Proc. 845 239

    [12]

    Seifter A, Grover M, Holtkamp D B, Payton J R, Rodriguez P, Turley D, Obst A W 2004 26th International Congress on High-Speed Photography and Photonics Alexandria, Virginia, September 19-24, 2004 p93

    [13]

    Ma Y, Wang X S, Li X Z, Zhang H Z, Hu S L, Li J B, Chen H, Wen J D 2006 Chin. J. High Press. Phys. 20 207 (in Chinese) [马云, 汪小松, 李欣竹, 张汉钊, 胡绍楼, 李加波, 陈宏, 翁继东 2006 高压物理学报 20 207]

    [14]

    Asay J R 1978 J. Appl. Phys. 49 6173

    [15]

    Oró D M, Hammerberg J E, Buttler W T, Mariam F G, Morris C, Rousculp C, Stone J B 2012 AIP Conf. Proc. 1426 1351

    [16]

    Rousculp C L, Oro D M, Morris C, Saunders A, Reass W, Griego J R, Turchi P J, Reinovsky R E https://www.osti.gov/scitech/biblio/1178310/ [2015-4-20]

    [17]

    Liu G R, Liu M B 2003 Smoothed Particle Hydrodynamics: A Meshfree Particle Methods (Singapore: World Scientific) pp309-339

    [18]

    Wang P, Qin C S, Zhang S D, Liu C 2004 Chin. J. High Press. Phys. 18 149 (in Chinese) [王裴, 秦承森, 张树道, 刘超 2004 高压物理学报 18 149]

    [19]

    Monfared S K, Buttler W T, Frayer D K, Grover M, LaLone B M, Stevens G D, Stone J B, Turley W D, Schauer M M 2015 J. Appl. Phys. 117 223105

    [20]

    Tan H 2007 Introduction to Experimental Shocked-Wave Physics (Beijing: National Defense Industry Press) pp36-43 (in Chinese) [谭华 2007 实验冲击波物理导引(北京:国防工业出版社)第36—43页]

    [21]

    Zhang S Q, Liu C L, Li Q Z, Liu Q 2008 Acta Mech. Sin. 40 535 (in Chinese) [张世文, 刘仓理, 李庆忠, 刘乔 2008 力学学报 40 535]

    [22]

    Sorenson D S, Pazuchanics P D, Johnson R P, Tunnell T W, Smalley D D, Malone R M, Kaufman M I, Marks D G, Capelle G A, Grover M, Stevens G D, LaLone B M, Marshall B F, Turley W D 2017 AIP Conf. Proc. 1793 100026

    [23]

    Buttler W T, Oró D M, Olson R T, Cherne F J, Hammerberg J E, Hixson R S, Monfared S K, Pack C L, Rigg P A, Stone J B, Terrones G 2014 J. Appl. Phys. 116 103519

    [24]

    Fung J, Harrison A K, Chitanvbs S, Margulies J 2013 Comput. Fluids 83 177

    [25]

    Wang P, Sun H Q, Shao J L, Qin C S, Li X Z 2012 Acta Phys. Sin. 61 234703 (in Chinese) [王裴, 孙海全, 邵建立, 秦承森, 李欣竹 2012 物理学报 61 234703]

    [26]

    Igra O, Takayama K 1993 Proc. R. Soc. London 442 231

  • [1] 高伟, 邵琳, 韩珊珊, 邢宇, 张晶晶, 陈斌辉, 韩庆艳, 严学文, 张成云, 董军. 基于单颗粒NaYF4微米棒的上转换白光发射特性. 物理学报, 2023, 72(2): 024207. doi: 10.7498/aps.72.20221606
    [2] 高伟, 孙泽煜, 郭立淳, 韩珊珊, 陈斌辉, 韩庆艳, 严学文, 王勇凯, 刘继红, 董军. Ho3+离子掺杂单颗粒氟化物微米核壳结构的上转换发光特性. 物理学报, 2022, 71(3): 034207. doi: 10.7498/aps.71.20211719
    [3] 高伟, 孙泽煜, 郭立淳, 韩珊珊, 陈斌辉, 韩庆艳, 严学文, 王勇凯, 刘继红, 董军. Ho3+离子掺杂单颗粒氟化物微米核壳结构的上转换发光特性研究. 物理学报, 2021, (): . doi: 10.7498/aps.70.20211719
    [4] 陈永涛, 洪仁楷, 陈浩玉, 任国武. 熔化状态下金属样品表面的微喷射问题. 物理学报, 2016, 65(2): 026201. doi: 10.7498/aps.65.026201
    [5] 冯培培, 吴寒, 张楠. 超短脉冲激光烧蚀石墨产生的喷射物的时间分辨发射光谱研究. 物理学报, 2015, 64(21): 214201. doi: 10.7498/aps.64.214201
    [6] 王天天, 葛昌纯, 贾崇林, 汪杰, 谷天赋, 吴海新. 喷射成形粉末高温合金FGH4095M的制备及组织特征. 物理学报, 2015, 64(10): 106103. doi: 10.7498/aps.64.106103
    [7] 赵信文, 李欣竹, 王学军, 宋萍, 张汉钊, 吴强. 金属表面几何缺陷微细结构对微喷射特性的影响. 物理学报, 2015, 64(12): 124701. doi: 10.7498/aps.64.124701
    [8] 孟凡净, 刘焜. 密集剪切颗粒流中速度波动和自扩散特性的离散元模拟. 物理学报, 2014, 63(13): 134502. doi: 10.7498/aps.63.134502
    [9] 叶扬, 王树林. 铜微颗粒碰撞阻尼特性. 物理学报, 2014, 63(22): 224304. doi: 10.7498/aps.63.224304
    [10] 杨景辉, 张楠, 朱晓农. 利用相干光照明的纹影成像装置研究飞秒激光脉冲烧蚀铝靶喷射物相位的超快时间演化. 物理学报, 2013, 62(13): 134203. doi: 10.7498/aps.62.134203
    [11] 张宇, 葛昌纯, 沈卫平, 邱成杰. 喷射成型FGH4095静态再结晶组织特征. 物理学报, 2012, 61(20): 208101. doi: 10.7498/aps.61.208101
    [12] 张宇, 葛昌纯, 郭彪, 沈卫平. 喷射成形FGH4095的热变形特征. 物理学报, 2012, 61(21): 218102. doi: 10.7498/aps.61.218102
    [13] 张宇, 葛昌纯, 沈卫平, 邱成杰. 氮气喷射成形FGH4095的组织特征. 物理学报, 2012, 61(19): 196101. doi: 10.7498/aps.61.196101
    [14] 陈永涛, 任国武, 汤铁钢, 李庆忠, 王德田, 胡海波. 熔化前后Pb样品表面微喷射现象研究. 物理学报, 2012, 61(20): 206202. doi: 10.7498/aps.61.206202
    [15] 王裴, 孙海权, 邵建立, 秦承森, 李欣竹. 微喷颗粒与气体混合过程的数值模拟研究. 物理学报, 2012, 61(23): 234703. doi: 10.7498/aps.61.234703
    [16] 王心亮, 陈洁, 王叶兵, 高峰, 张首刚, 刘海峰, 常宏. 利用塞曼扫频法实现对减速锶原子束速度分布的直接测量. 物理学报, 2011, 60(10): 103201. doi: 10.7498/aps.60.103201
    [17] 崔志文, 刘金霞, 王春霞, 王克协. 基于Biot-喷射流统一模型Maxwell流体饱和孔隙介质中的弹性波. 物理学报, 2010, 59(12): 8655-8661. doi: 10.7498/aps.59.8655
    [18] 胡浩丰, 王晓雷, 李智磊, 张楠, 翟宏琛. 飞秒激光烧蚀铝靶产生喷射物的超快脉冲数字全息诊断. 物理学报, 2009, 58(11): 7662-7667. doi: 10.7498/aps.58.7662
    [19] 陈军, 经福谦, 张景琳, 陈栋泉. 冲击作用下金属表面微喷射的分子动力学模拟. 物理学报, 2002, 51(10): 2386-2392. doi: 10.7498/aps.51.2386
    [20] 郑师海, 李德华, 陈岩松, 戴伦. 微米亚微米有限凹槽衍射特性的实验研究. 物理学报, 1996, 45(8): 1292-1296. doi: 10.7498/aps.45.1292
计量
  • 文章访问数:  4724
  • PDF下载量:  227
  • 被引次数: 0
出版历程
  • 收稿日期:  2016-11-11
  • 修回日期:  2017-02-28
  • 刊出日期:  2017-05-05

/

返回文章
返回