搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

分离压和表面黏度的协同作用对液膜排液过程的影响

叶学民 杨少东 李春曦

引用本文:
Citation:

分离压和表面黏度的协同作用对液膜排液过程的影响

叶学民, 杨少东, 李春曦

Synergistic effects of disjoining pressure and surface viscosity on film drainage process

Ye Xue-Min, Yang Shao-Dong, Li Chun-Xi
PDF
导出引用
  • 针对含不溶性活性剂的垂直液膜排液过程,在考虑分离压作用的前提下,引入随活性剂浓度变化的表面黏度模型,应用润滑理论建立了液膜厚度、活性剂浓度和液膜表面速度的演化方程组,通过数值计算分析了常表面黏度和变表面黏度情形下的液膜演化特征.结果表明:表面黏度是影响液膜排液过程的重要因素,当不考虑表面黏度时,液膜表面呈流动模式,反之呈刚性模式,且随表面黏度增加,液膜排液速率明显减缓.分离压对黑膜的形成至关重要,分离压单独作用时,其形成的黑膜长度较短,而只考虑表面黏度时,则不能形成稳定的黑膜.而在二者协同作用下,液膜中部形成了向下扩展、厚度很薄但非常稳定的黑膜,且黑膜厚度、出现时间均随表面黏度的增大而增加.当考虑活性剂浓度对表面黏度的影响时,表面速度受此影响显著;在形成黑膜长度及出现时间方面与相应常表面黏度的情形基本类似,但其黑膜厚度小于相应常表面黏度,故在液膜排液过程中更容易发生失稳.
    A mathematical model is established to investigate the gravity-driven draining process of a vertical thin liquid film containing insoluble surfactants when considering the synergistic effect of surface viscosity and disjoining pressure. Lubrication theory is used to derive a coupled equation set describing the evolution of the film thickness, surfactant concentration and surface velocity. The equation set is solved numerically by the FreeFem program based on the finite element method. The film is assumed to be supported by the wire frame at both the top and bottom, thus the mass of liquid and the mass of total surfactants are conserved in the simulation. The characteristics of film evolution under the constant and variable surface viscosity are examined. Simulation results show that the surface viscosity is a crucial factor affecting the film drainage process. When neglecting the effect of surface viscosity, the film surface exhibits the mobile mode, while the film surface presents the rigid mode in the case of the surface viscosity considered. Increasing the surface viscosity, the rate of film drainage is slowed down significantly, leading to a reduction of the film thinning and enhancement of film stability, which is consistent with the results obtained by Naire et al. The disjoining pressure is a key factor in the formation of black film. When the disjoining pressure is only involved in the model, the length of the black film region is relatively short, nevertheless, if the effect of surface viscosity is only considered, a stable black film does not form. Under the synergistic effect of the disjoining pressure and surface viscosity, a very long and thin but stable black film is found in the middle segment of the film. Additionally, the thickness of black film increases and the appearance time postpones with the increase of surface viscosity. Considering the influence of concentration-dependent surface viscosity, the drainage rate is greatly affected. In the early stage, due to the smaller overall surface viscosity, the surface velocity is relatively large. With increasing surface viscosity at the bottom of film, the strength of the film surface tends to be enhanced, and then the anti-perturbation ability of the film is promoted and the film thinning is retarded. There is no significant difference in the length nor the appearance time of black film except that the thickness of black film with concentration-dependent surface viscosity is lower than that with the constant viscosity, thus the flow stability is weaker than that with the constant viscosity. In addition, the presence of the disjoining pressure slows down the thinning of blackest portion of the film and the surfactant concentration at this position. In the numerical results of the variable surface viscosity given by Braun et al. it is observed that the concentration of surfactant could almost be swept to clean in the top part of film. That is possibly because the effect of the disjoining pressure is neglected by Braun et al. It should be pointed out that the surface elasticity plays an important role in the stability of film. Therefore, it is necessary to consider the effect of surface elasticity in the future investigation.
      通信作者: 李春曦, leechunxi@163.com
    • 基金项目: 国家自然科学基金(批准号:11202079)和中央高校基本科研业务费专项资金(批准号:13MS97)资助的课题.
      Corresponding author: Li Chun-Xi, leechunxi@163.com
    • Funds: Project supported by the National Natural Science Foundation of China (Grant No. 11202079) and the Fundamental Research for the Central Universities, China (Grant No. 13MS97).
    [1]

    Huang J, Sun Q C 2007 Acta Phys. Sin. 56 6124 (in Chinese)[黄晋, 孙其诚 2007 物理学报 56 6124]

    [2]

    Bournival G, Du Z, Ata S, Jameson G J 2014 Chem. Eng. Sci. 116 536

    [3]

    Firouzi M, Nguyen A V 2014 Adv. Powder Technol. 25 1212

    [4]

    Jun S, Pelot D D, Yarin A L 2012 Langmuir 28 5323

    [5]

    Anazadehsayed A, Naser J 2017 Chem. Eng. Sci. 166 11

    [6]

    Mysels K J, Shinoda K, Frankel S 1959 Soap Films:Studies of Their Thinning and a Bibilography (New York:Pergammon) p116

    [7]

    Wang J, Nguyen A V, Farrokhpay S 2016 Adv. Colloid Interfac. 228 55

    [8]

    Benjamin Dollet, Isabelle Cantat 2014 J. Fluid Mech. 739 124

    [9]

    Zang D Y, Rio E, Langevin D, Wei B, Binks B P 2010 Eur. Phys. J. E 31 125

    [10]

    Schwartz L W, Roy R V 1999 J. Colloid Interface Sci. 218 309

    [11]

    Carey E, Stubenrauch C 2010 J. Colloid Interface Sci. 343 314

    [12]

    Tabakova S S, Danov K D 2009 J. Colloid Interface Sci. 336 273

    [13]

    Matar O K 2002 Phys. Fluids 14 4216

    [14]

    Boussinesq J 1913 Ann. Chim. Phys. 29 349

    [15]

    Li T M, Jia S Y 1995 CIESC J. 5 532 (in Chinese)[李佟茗, 贾绍义 1995 化工学报 5 532]

    [16]

    Naire S, Braun R J, Snow S A 2000 J. Colloid Interface Sci. 230 91

    [17]

    Naire S, Braun R J, Snow S A 2004 J. Comput. Appl. Math. 166 385

    [18]

    Naire S, Braun R J, Snow S A 2001 Phys. Fluids 13 2492

    [19]

    Heidari A H, Braun R J, Hirsa A H, Snow S A, Naire S 2002 J. Colloid Interface Sci. 253 295

    [20]

    Snow S A, Pernisz U C, Nugent B M 1996 Dow Corning Corporation Research Report 1996-I0000-41395

    [21]

    Lopez J M, Hirsa A H 2000 J. Colloid Interface Sci. 229 575

    [22]

    Vitasari D, Grassia P, Martin P 2015 Appl. Math. Model. 40 1941

    [23]

    Elfring G J, Leal L G, Squires T M 2016 J. Fluid Mech. 792 712

    [24]

    Yekeen N, Idris A K, Manan M A, Samin A M, Risal A R, Tan X K 2017 Chin. J. Chem. Eng. 25 347

    [25]

    Han G B, Wu J T, Xu X M 2000 Acta Phys. Chim. Sin. 16 507 (in Chinese)[韩国彬, 吴金添, 徐晓明 2000 物理化学学报 16 507]

    [26]

    Gauchet S, Durand M, Langevin D 2014 J. Colloid Interface Sci. 449 373

    [27]

    Saulnier L, Champougny L, Bastien G, Restagno F, Langevin D, Rio E 2014 Soft Matter 10 2899

    [28]

    Sett S, Sinha-Ray S, Yarin A L 2013 Langmuir 29 4934

    [29]

    Zang D Y, Rio E, Delon G, Langevin D, Wei B, Binks B P 2011 Mol. Phys. 109 1057

    [30]

    Pu W, Wei P, Sun L, Jin F Y, Wang S 2016 J. Ind. Eng. Chem. 47 360

    [31]

    Zhang C R 2007 Ph. D. Dissertation (Beijing:Technical Institute of Physical and Chemistry of Chinese Academy of Sciences) (in Chinese)[张春荣 2007 博士学位论文 (北京:中国科学院理化技术研究所)]

    [32]

    Tian Y, Holt R G, Apfel R E 1997 J. Colloid Interface Sci. 87 1

    [33]

    Avramidis K S, Jiang T S 1991 J. Colloid Interface Sci. 147 262

    [34]

    Murai Y, Shiratori T, Kumagai I, Rhs P A, Fischer P 2015 Flow Meas. Instrum. 41 121

    [35]

    Ivanov I B, Danov K D, Ananthapadmanabhan K P, Lips A 2005 Adv. Colloid Interfac. 114-115 61

    [36]

    Manor O, Lavrenteva O, Nir A 2008 J. Colloid Interface Sci. 321 142

    [37]

    Zhao Y P 2012 Physical Mechanics of Surface and Interface (Beijing:Science Press) pp185, 186 (in Chinese)[赵亚溥 2012 表面与界面物理力学 (北京:科学出版社) 第185, 186页]

    [38]

    Li C X, Pei J J, Ye X M 2013 Acta Phys. Sin. 62 214704 (in Chinese)[李春曦, 裴建军, 叶学民 2013 物理学报 62 214704]

    [39]

    de Wit A, Gallez D, Christov C I 1994 Phys. Fluids 6 3256

    [40]

    Sakata E K, Berg J C 1972 J. Colloid Interface Sci. 40 99

    [41]

    Saulnier L, Boos J, Stubenrauch C, Rio E 2014 Soft Matter 10 7117

    [42]

    Lu K Q, Liu J X 2007 Introduction of Soft Matter Physics (Beijing:Peking University Press) pp278, 279 (in Chinese)[陆坤权, 刘寄星 2007 软物质物理学导论 (北京大学出版社) 第278, 279页]

    [43]

    Braun R J, Snow S A, Naire S 2002 J. Eng. Math. 43 281

    [44]

    Karakashev S I, Nguyen A V 2007 Colloid Surface A 293 229

    [45]

    Ivanov I B, Dimitrov D S 1974 Colloid Polym. Sci. 252 98

  • [1]

    Huang J, Sun Q C 2007 Acta Phys. Sin. 56 6124 (in Chinese)[黄晋, 孙其诚 2007 物理学报 56 6124]

    [2]

    Bournival G, Du Z, Ata S, Jameson G J 2014 Chem. Eng. Sci. 116 536

    [3]

    Firouzi M, Nguyen A V 2014 Adv. Powder Technol. 25 1212

    [4]

    Jun S, Pelot D D, Yarin A L 2012 Langmuir 28 5323

    [5]

    Anazadehsayed A, Naser J 2017 Chem. Eng. Sci. 166 11

    [6]

    Mysels K J, Shinoda K, Frankel S 1959 Soap Films:Studies of Their Thinning and a Bibilography (New York:Pergammon) p116

    [7]

    Wang J, Nguyen A V, Farrokhpay S 2016 Adv. Colloid Interfac. 228 55

    [8]

    Benjamin Dollet, Isabelle Cantat 2014 J. Fluid Mech. 739 124

    [9]

    Zang D Y, Rio E, Langevin D, Wei B, Binks B P 2010 Eur. Phys. J. E 31 125

    [10]

    Schwartz L W, Roy R V 1999 J. Colloid Interface Sci. 218 309

    [11]

    Carey E, Stubenrauch C 2010 J. Colloid Interface Sci. 343 314

    [12]

    Tabakova S S, Danov K D 2009 J. Colloid Interface Sci. 336 273

    [13]

    Matar O K 2002 Phys. Fluids 14 4216

    [14]

    Boussinesq J 1913 Ann. Chim. Phys. 29 349

    [15]

    Li T M, Jia S Y 1995 CIESC J. 5 532 (in Chinese)[李佟茗, 贾绍义 1995 化工学报 5 532]

    [16]

    Naire S, Braun R J, Snow S A 2000 J. Colloid Interface Sci. 230 91

    [17]

    Naire S, Braun R J, Snow S A 2004 J. Comput. Appl. Math. 166 385

    [18]

    Naire S, Braun R J, Snow S A 2001 Phys. Fluids 13 2492

    [19]

    Heidari A H, Braun R J, Hirsa A H, Snow S A, Naire S 2002 J. Colloid Interface Sci. 253 295

    [20]

    Snow S A, Pernisz U C, Nugent B M 1996 Dow Corning Corporation Research Report 1996-I0000-41395

    [21]

    Lopez J M, Hirsa A H 2000 J. Colloid Interface Sci. 229 575

    [22]

    Vitasari D, Grassia P, Martin P 2015 Appl. Math. Model. 40 1941

    [23]

    Elfring G J, Leal L G, Squires T M 2016 J. Fluid Mech. 792 712

    [24]

    Yekeen N, Idris A K, Manan M A, Samin A M, Risal A R, Tan X K 2017 Chin. J. Chem. Eng. 25 347

    [25]

    Han G B, Wu J T, Xu X M 2000 Acta Phys. Chim. Sin. 16 507 (in Chinese)[韩国彬, 吴金添, 徐晓明 2000 物理化学学报 16 507]

    [26]

    Gauchet S, Durand M, Langevin D 2014 J. Colloid Interface Sci. 449 373

    [27]

    Saulnier L, Champougny L, Bastien G, Restagno F, Langevin D, Rio E 2014 Soft Matter 10 2899

    [28]

    Sett S, Sinha-Ray S, Yarin A L 2013 Langmuir 29 4934

    [29]

    Zang D Y, Rio E, Delon G, Langevin D, Wei B, Binks B P 2011 Mol. Phys. 109 1057

    [30]

    Pu W, Wei P, Sun L, Jin F Y, Wang S 2016 J. Ind. Eng. Chem. 47 360

    [31]

    Zhang C R 2007 Ph. D. Dissertation (Beijing:Technical Institute of Physical and Chemistry of Chinese Academy of Sciences) (in Chinese)[张春荣 2007 博士学位论文 (北京:中国科学院理化技术研究所)]

    [32]

    Tian Y, Holt R G, Apfel R E 1997 J. Colloid Interface Sci. 87 1

    [33]

    Avramidis K S, Jiang T S 1991 J. Colloid Interface Sci. 147 262

    [34]

    Murai Y, Shiratori T, Kumagai I, Rhs P A, Fischer P 2015 Flow Meas. Instrum. 41 121

    [35]

    Ivanov I B, Danov K D, Ananthapadmanabhan K P, Lips A 2005 Adv. Colloid Interfac. 114-115 61

    [36]

    Manor O, Lavrenteva O, Nir A 2008 J. Colloid Interface Sci. 321 142

    [37]

    Zhao Y P 2012 Physical Mechanics of Surface and Interface (Beijing:Science Press) pp185, 186 (in Chinese)[赵亚溥 2012 表面与界面物理力学 (北京:科学出版社) 第185, 186页]

    [38]

    Li C X, Pei J J, Ye X M 2013 Acta Phys. Sin. 62 214704 (in Chinese)[李春曦, 裴建军, 叶学民 2013 物理学报 62 214704]

    [39]

    de Wit A, Gallez D, Christov C I 1994 Phys. Fluids 6 3256

    [40]

    Sakata E K, Berg J C 1972 J. Colloid Interface Sci. 40 99

    [41]

    Saulnier L, Boos J, Stubenrauch C, Rio E 2014 Soft Matter 10 7117

    [42]

    Lu K Q, Liu J X 2007 Introduction of Soft Matter Physics (Beijing:Peking University Press) pp278, 279 (in Chinese)[陆坤权, 刘寄星 2007 软物质物理学导论 (北京大学出版社) 第278, 279页]

    [43]

    Braun R J, Snow S A, Naire S 2002 J. Eng. Math. 43 281

    [44]

    Karakashev S I, Nguyen A V 2007 Colloid Surface A 293 229

    [45]

    Ivanov I B, Dimitrov D S 1974 Colloid Polym. Sci. 252 98

  • [1] 成潇潇, 刘建国, 徐亮, 徐寒杨, 金岭, 束胜全, 薛明. 基于页岩气返排液中污染气体浓度及扩散模型研究. 物理学报, 2021, 70(13): 130202. doi: 10.7498/aps.70.20210017
    [2] 张鹏程, 方文玉, 鲍磊, 康文斌. 蛋白质“液-液相分离”的理论和计算方法进展. 物理学报, 2020, 69(13): 138701. doi: 10.7498/aps.69.20200438
    [3] 杨亚晶, 梅晨曦, 章旭东, 魏衍举, 刘圣华. 液滴撞击液膜的穿越模式及运动特性. 物理学报, 2019, 68(15): 156101. doi: 10.7498/aps.68.20190604
    [4] 李春曦, 施智贤, 庄立宇, 叶学民. 活性剂对表面声波作用下薄液膜铺展的影响. 物理学报, 2019, 68(21): 214703. doi: 10.7498/aps.68.20190791
    [5] 叶学民, 李明兰, 张湘珊, 李春曦. 表面弹性对含可溶性活性剂垂直液膜排液的影响. 物理学报, 2018, 67(21): 214703. doi: 10.7498/aps.67.20181020
    [6] 叶学民, 李明兰, 张湘珊, 李春曦. 表面弹性和分离压耦合作用下的垂直液膜排液过程. 物理学报, 2018, 67(16): 164701. doi: 10.7498/aps.67.20180349
    [7] 檀满林, 周丹丹, 符冬菊, 张维丽, 马清, 李冬霜, 陈建军, 张化宇, 王根平. 基于BiFeO3/ITO复合膜表面钝化的黑硅太阳电池性能研究. 物理学报, 2017, 66(16): 167701. doi: 10.7498/aps.66.167701
    [8] 叶学民, 杨少东, 李春曦. 随活性剂浓度变化的分离压对垂直液膜排液过程的影响. 物理学报, 2017, 66(18): 184702. doi: 10.7498/aps.66.184702
    [9] 黄虎, 洪宁, 梁宏, 施保昌, 柴振华. 液滴撞击液膜过程的格子Boltzmann方法模拟. 物理学报, 2016, 65(8): 084702. doi: 10.7498/aps.65.084702
    [10] 吴正人, 刘梅, 刘秋升, 宋朝匣, 王思思. 倾斜波动壁面上液膜表面波演化特性的影响. 物理学报, 2015, 64(24): 244701. doi: 10.7498/aps.64.244701
    [11] 王松岭, 刘梅, 王思思, 吴正人. 随时间变化的非平整壁面对液膜表面波演化特性的影响. 物理学报, 2015, 64(1): 014701. doi: 10.7498/aps.64.014701
    [12] 梁刚涛, 沈胜强, 郭亚丽, 陈觉先, 于欢, 李熠桥. 实验观测液滴撞击倾斜表面液膜的特殊现象. 物理学报, 2013, 62(8): 084707. doi: 10.7498/aps.62.084707
    [13] 李春曦, 姜凯, 叶学民. 含活性剂液膜去润湿演化的稳定性特征. 物理学报, 2013, 62(23): 234702. doi: 10.7498/aps.62.234702
    [14] 周丰茂, 孙东科, 朱鸣芳. 偏晶合金液-液相分离的格子玻尔兹曼方法模拟. 物理学报, 2010, 59(5): 3394-3401. doi: 10.7498/aps.59.3394
    [15] 郭加宏, 戴世强, 代钦. 液滴冲击液膜过程实验研究. 物理学报, 2010, 59(4): 2601-2609. doi: 10.7498/aps.59.2601
    [16] 李亚楠, 梁中翥, 梁静秋, 郑娜, 方伟, 王维彪, 禹秉熙. 辐射探测芯片吸收膜理论设计及镍磷黑膜制备. 物理学报, 2010, 59(7): 4530-4534. doi: 10.7498/aps.59.4530
    [17] 刘光友, 谭兴文, 姚金才, 王 振, 熊祖洪. 电化学制备薄黑硅抗反射膜. 物理学报, 2008, 57(1): 514-518. doi: 10.7498/aps.57.514
    [18] 普小云, 柳清菊, 张中明, 林理忠. 表面单分子膜的垂悬液滴方法研究. 物理学报, 1998, 47(1): 60-67. doi: 10.7498/aps.47.60
    [19] 杨世. 表面压诱导的外消旋双亲分子单层手征相分离的数学模型及其二维古典解. 物理学报, 1998, 47(10): 1673-1679. doi: 10.7498/aps.47.1673
    [20] 李标, 褚君浩, 陈新强, 刘坤, 曹菊英, 汤定元. 汞压对液相外延(Hg,Cd)Te的液相线及组份的影响. 物理学报, 1995, 44(6): 853-861. doi: 10.7498/aps.44.853
计量
  • 文章访问数:  4894
  • PDF下载量:  170
  • 被引次数: 0
出版历程
  • 收稿日期:  2017-05-26
  • 修回日期:  2017-07-16
  • 刊出日期:  2017-10-05

/

返回文章
返回