搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

表面弹性和分离压耦合作用下的垂直液膜排液过程

叶学民 李明兰 张湘珊 李春曦

引用本文:
Citation:

表面弹性和分离压耦合作用下的垂直液膜排液过程

叶学民, 李明兰, 张湘珊, 李春曦

Coupling effects of surface elasticity and disjoining pressure on film drainage process

Ye Xue-Min, Li Ming-Lan, Zhang Xiang-Shan, Li Chun-Xi
PDF
导出引用
  • 针对含不溶性活性剂的垂直液膜排液过程,在考虑表面弹性和分离压耦合作用的基础上,采用润滑理论建立了液膜厚度、表面速度和活性剂浓度的演化方程组,通过数值计算分析了表面弹性和分离压单独作用和耦合作用下的液膜演化特征.结果表明:表面弹性与分离压均对垂直液膜排液过程有显著影响.表面弹性单独作用时,液膜初始厚度随弹性增大,黑膜仅在液膜顶部形成,长度较短且不能稳定存在;分离压单独作用时,活性剂随流体不断汇集在底端,液膜表面无法形成表面张力梯度,不发生逆流现象;当二者耦合作用时,可得到较稳定的液膜,排液前期增加表面弹性可提高液膜的厚度、降低表面速度和促使液体逆流,从而减缓排液过程;后期出现黑膜后,分离压中的静电斥力起主要作用,延缓液膜“老化”.
    The aim of the present paper is to investigate the gravity-driven draining process containing insoluble surfactants, with the coupling effects of surface elasticity and disjoining pressure taken into consideration. A set of evolution equations including liquid film thickness, surface velocity and surfactant concentration, is established based on the lubrication theory. Assuming that the top of the liquid film is attached to the wireframe and the bottom is connected to the reservoir, the drainage stability is simulated with the FreeFem software. The characteristics of film evolution under the coupled effects of surface elasticity and disjoining pressure are examined, respectively. The simulated results show that the surface elasticity and the disjoining pressure have significant influences on the vertical thin film draining process. Under the effect of the surface elasticity alone, the initial film thickness increases with the elasticity increasing and the black film only forms on the top of the liquid film, but cannot stably exist and breaks quickly. The addition of the surface elasticity can increase the liquid film thickness and the drainage time, reduce the surface velocity, and rigidify the interface. When the disjoining pressure is applied merely, the surfactant flows into the reservoir continuously; hardly can the liquid film form a surface tension gradient and thus cannot form a countercurrent phenomenon. Under the coupling effect of the surface elasticity and disjoining pressure, a more stable liquid film forms. In the early stage of drainage, surface elasticity increases the film thickness, reduces the surface speed and generates the liquid countercurrent to slow the drainage process. When the black film appears, the electrostatic repulsion of the disjoining pressure is notable and makes the black film stable. The results obtained in the paper are in agreement with some of the experimental results in the literature. However, the elasticity-related surface tension and surfactant concentration model used is a simplified model. The nonlinear relationship between surface tension and surfactant concentration should be further considered in future theoretical models.
      通信作者: 李春曦, leechunxi@163.com
    • 基金项目: 国家自然科学基金(批准号:11202079)和中央高校基本科研业务费(批准号:13MS97)资助的课题.
      Corresponding author: Li Chun-Xi, leechunxi@163.com
    • Funds: Project supported by the National Natural Science Foundation of China (Grant No. 11202079) and the Fundamental Research for the Central Universities of China (Grant No. 13MS97).
    [1]

    Wang J, Nguyen A V, Farrokhpay S 2015 Adv. Colloid Interface 228 55

    [2]

    Bournival G, Du Z, Ata S, Jameson G J 2014 Chem. Eng. Sci. 116 536

    [3]

    Firouzi M, Nguyen A V 2014 Adv. Powder Technol. 25 1212

    [4]

    Wang L, Yoon R H 2008 Int. J. Miner. Process. 85 101

    [5]

    Wang J, Nguyen A V, Farrokhpay S 2016 Colloid Surface A 488 70

    [6]

    Sett S, Sinharay S, Yarin A L 2013 Langmuir 29 4934

    [7]

    Wang L, Yoon R H 2006 Colloid Surface A 282 84

    [8]

    Mysels K J, Cox M C, Skewis J D 1961 J. Phys. Chem. 65 1107

    [9]

    Champougny L, Scheid B, Restagno F, Vermant J, Rio E 2015 Soft Matter 11 2758

    [10]

    Saulnier L, Champougny L, Bastien G, Restagno F, Langevin D, Rio E 2014 Soft Matter 10 2899

    [11]

    Liggieri L, Attolini V, Ferrari M, Ravera F 2002 J. Colloid Interface Sci. 255 225

    [12]

    Persson C M, Claesson P M, Lunkenheimer K 2002 J. Colloid Interface Sci. 251 182

    [13]

    Karakashev S I, Ivanova D S, Angarska Z K, Manev E D, Tsekov R, Radoev B, Slavchov R, Nguyen A V 2010 Colloid Surface A 365 122

    [14]

    Seiwert J, Dollet B, Cantat I 2014 J. Fluid Mech. 739 124

    [15]

    Exerowa D, Zacharieva M, Cohen R, Platikanov D 1979 Colloid Polym. Sci. 257 1089

    [16]

    Churaev N V 2003 Colloid J. 103 197

    [17]

    Manev E D, Pugh R J 1991 Langmuir 7 2253

    [18]

    Bhakta A, Ruckenstein E 1997 J. Colloid Interface Sci. 191 184

    [19]

    Carey E, Stubenrauch C 2010 J. Colloid Interface Sci. 343 314

    [20]

    Buchavzov N, Stubenrauch C 2007 Langmuir 23 5315

    [21]

    Stubenrauch C, Schlarmann J, Strey R 2002 Phys. Chem. Chem. Phys. 4 4504

    [22]

    Karakashev S I, Ivanova D S 2010 J. Colloid Interface Sci. 343 584

    [23]

    Teletzke G F, Davis H T, Scriven L E 1988 Rev. Phys. Appl. 23 989

    [24]

    Mitlin V S, Petviashvili N V 1994 Phys. Lett. A 192 323

    [25]

    Frastia L, Archer A J, Thiele U 2012 Soft Matter 8 11363

    [26]

    Ye X M, Yang S D, Li C X 2017 Acta Phys. Sin. 66 184702 (in Chinese) [叶学民, 杨少东, 李春曦 2017 物理学报 66 184702]

    [27]

    Ye X M, Yang S D, Li C X 2017 Acta Phys. Sin. 66 194701 (in Chinese) [叶学民, 杨少东, 李春曦 2017 物理学报 66 194701]

    [28]

    Tabakova S S, Danov K D 2009 J. Colloid Interface Sci. 336 273

    [29]

    Georgieva D, Cagna A, Langevin D 2009 Soft Matter 5 2063

    [30]

    Bergeron V 1997 Langmuir 13 3474

    [31]

    Panaiotov I, Dimitrov D S, Ter-Minassian-Saraga L 1979 J. Colloid Interface Sci. 72 49

    [32]

    Park C W 1991 J. Colloid Interface Sci. 146 382

    [33]

    Zhao Y P 2012 Physical Mechanics of Surface and Interface (Beijing: Science Press) p185, 186 (in Chinese) [赵亚溥 2012 表面与界面物理力学 (北京: 科学出版社) 第185, 186页]

    [34]

    Naire S, Braun R J, Snow S A 2000 J. Colloid Interface Sci. 230 91

    [35]

    Heidari A H, Braun R J, Hirsa A H, Snow S A, Naire S 2002 J. Colloid Interface Sci. 253 295

    [36]

    Ruschak K J 2010 Aiche J. 24 705

    [37]

    Vitasari D, Grassia P, Martin P 2016 Appl. Math. Model. 40 1941

    [38]

    Berg S, Adelizzi E A, Troian S M 2005 Langmuir 21 3867

    [39]

    Schwartz L W, Roy R V 1999 J. Colloid. Interface Sci. 218 309

    [40]

    Saulnier L, Boos J, Stubenrauch C, Rio E 2014 Soft Matter 10 7117

  • [1]

    Wang J, Nguyen A V, Farrokhpay S 2015 Adv. Colloid Interface 228 55

    [2]

    Bournival G, Du Z, Ata S, Jameson G J 2014 Chem. Eng. Sci. 116 536

    [3]

    Firouzi M, Nguyen A V 2014 Adv. Powder Technol. 25 1212

    [4]

    Wang L, Yoon R H 2008 Int. J. Miner. Process. 85 101

    [5]

    Wang J, Nguyen A V, Farrokhpay S 2016 Colloid Surface A 488 70

    [6]

    Sett S, Sinharay S, Yarin A L 2013 Langmuir 29 4934

    [7]

    Wang L, Yoon R H 2006 Colloid Surface A 282 84

    [8]

    Mysels K J, Cox M C, Skewis J D 1961 J. Phys. Chem. 65 1107

    [9]

    Champougny L, Scheid B, Restagno F, Vermant J, Rio E 2015 Soft Matter 11 2758

    [10]

    Saulnier L, Champougny L, Bastien G, Restagno F, Langevin D, Rio E 2014 Soft Matter 10 2899

    [11]

    Liggieri L, Attolini V, Ferrari M, Ravera F 2002 J. Colloid Interface Sci. 255 225

    [12]

    Persson C M, Claesson P M, Lunkenheimer K 2002 J. Colloid Interface Sci. 251 182

    [13]

    Karakashev S I, Ivanova D S, Angarska Z K, Manev E D, Tsekov R, Radoev B, Slavchov R, Nguyen A V 2010 Colloid Surface A 365 122

    [14]

    Seiwert J, Dollet B, Cantat I 2014 J. Fluid Mech. 739 124

    [15]

    Exerowa D, Zacharieva M, Cohen R, Platikanov D 1979 Colloid Polym. Sci. 257 1089

    [16]

    Churaev N V 2003 Colloid J. 103 197

    [17]

    Manev E D, Pugh R J 1991 Langmuir 7 2253

    [18]

    Bhakta A, Ruckenstein E 1997 J. Colloid Interface Sci. 191 184

    [19]

    Carey E, Stubenrauch C 2010 J. Colloid Interface Sci. 343 314

    [20]

    Buchavzov N, Stubenrauch C 2007 Langmuir 23 5315

    [21]

    Stubenrauch C, Schlarmann J, Strey R 2002 Phys. Chem. Chem. Phys. 4 4504

    [22]

    Karakashev S I, Ivanova D S 2010 J. Colloid Interface Sci. 343 584

    [23]

    Teletzke G F, Davis H T, Scriven L E 1988 Rev. Phys. Appl. 23 989

    [24]

    Mitlin V S, Petviashvili N V 1994 Phys. Lett. A 192 323

    [25]

    Frastia L, Archer A J, Thiele U 2012 Soft Matter 8 11363

    [26]

    Ye X M, Yang S D, Li C X 2017 Acta Phys. Sin. 66 184702 (in Chinese) [叶学民, 杨少东, 李春曦 2017 物理学报 66 184702]

    [27]

    Ye X M, Yang S D, Li C X 2017 Acta Phys. Sin. 66 194701 (in Chinese) [叶学民, 杨少东, 李春曦 2017 物理学报 66 194701]

    [28]

    Tabakova S S, Danov K D 2009 J. Colloid Interface Sci. 336 273

    [29]

    Georgieva D, Cagna A, Langevin D 2009 Soft Matter 5 2063

    [30]

    Bergeron V 1997 Langmuir 13 3474

    [31]

    Panaiotov I, Dimitrov D S, Ter-Minassian-Saraga L 1979 J. Colloid Interface Sci. 72 49

    [32]

    Park C W 1991 J. Colloid Interface Sci. 146 382

    [33]

    Zhao Y P 2012 Physical Mechanics of Surface and Interface (Beijing: Science Press) p185, 186 (in Chinese) [赵亚溥 2012 表面与界面物理力学 (北京: 科学出版社) 第185, 186页]

    [34]

    Naire S, Braun R J, Snow S A 2000 J. Colloid Interface Sci. 230 91

    [35]

    Heidari A H, Braun R J, Hirsa A H, Snow S A, Naire S 2002 J. Colloid Interface Sci. 253 295

    [36]

    Ruschak K J 2010 Aiche J. 24 705

    [37]

    Vitasari D, Grassia P, Martin P 2016 Appl. Math. Model. 40 1941

    [38]

    Berg S, Adelizzi E A, Troian S M 2005 Langmuir 21 3867

    [39]

    Schwartz L W, Roy R V 1999 J. Colloid. Interface Sci. 218 309

    [40]

    Saulnier L, Boos J, Stubenrauch C, Rio E 2014 Soft Matter 10 7117

  • [1] 贺华丹, 钟琦超, 解文军. 声悬浮条件下双水相液滴的蒸发与相分离. 物理学报, 2024, 73(3): 034304. doi: 10.7498/aps.73.20230963
    [2] 王凯宇, 庞祥龙, 李晓光. 超疏水表面液滴的振动特性及其与液滴体积的关系. 物理学报, 2021, 70(7): 076801. doi: 10.7498/aps.70.20201771
    [3] 成潇潇, 刘建国, 徐亮, 徐寒杨, 金岭, 束胜全, 薛明. 基于页岩气返排液中污染气体浓度及扩散模型研究. 物理学报, 2021, 70(13): 130202. doi: 10.7498/aps.70.20210017
    [4] 张鹏程, 方文玉, 鲍磊, 康文斌. 蛋白质“液-液相分离”的理论和计算方法进展. 物理学报, 2020, 69(13): 138701. doi: 10.7498/aps.69.20200438
    [5] 杨亚晶, 梅晨曦, 章旭东, 魏衍举, 刘圣华. 液滴撞击液膜的穿越模式及运动特性. 物理学报, 2019, 68(15): 156101. doi: 10.7498/aps.68.20190604
    [6] 李春曦, 施智贤, 庄立宇, 叶学民. 活性剂对表面声波作用下薄液膜铺展的影响. 物理学报, 2019, 68(21): 214703. doi: 10.7498/aps.68.20190791
    [7] 叶学民, 李明兰, 张湘珊, 李春曦. 表面弹性对含可溶性活性剂垂直液膜排液的影响. 物理学报, 2018, 67(21): 214703. doi: 10.7498/aps.67.20181020
    [8] 叶学民, 杨少东, 李春曦. 随活性剂浓度变化的分离压对垂直液膜排液过程的影响. 物理学报, 2017, 66(18): 184702. doi: 10.7498/aps.66.184702
    [9] 叶学民, 杨少东, 李春曦. 分离压和表面黏度的协同作用对液膜排液过程的影响. 物理学报, 2017, 66(19): 194701. doi: 10.7498/aps.66.194701
    [10] 桑永杰, 蓝宇, 丁玥文. Helmholtz水声换能器弹性壁液腔谐振频率研究. 物理学报, 2016, 65(2): 024301. doi: 10.7498/aps.65.024301
    [11] 黄虎, 洪宁, 梁宏, 施保昌, 柴振华. 液滴撞击液膜过程的格子Boltzmann方法模拟. 物理学报, 2016, 65(8): 084702. doi: 10.7498/aps.65.084702
    [12] 吴正人, 刘梅, 刘秋升, 宋朝匣, 王思思. 倾斜波动壁面上液膜表面波演化特性的影响. 物理学报, 2015, 64(24): 244701. doi: 10.7498/aps.64.244701
    [13] 王松岭, 刘梅, 王思思, 吴正人. 随时间变化的非平整壁面对液膜表面波演化特性的影响. 物理学报, 2015, 64(1): 014701. doi: 10.7498/aps.64.014701
    [14] 梁刚涛, 沈胜强, 郭亚丽, 陈觉先, 于欢, 李熠桥. 实验观测液滴撞击倾斜表面液膜的特殊现象. 物理学报, 2013, 62(8): 084707. doi: 10.7498/aps.62.084707
    [15] 李春曦, 姜凯, 叶学民. 含活性剂液膜去润湿演化的稳定性特征. 物理学报, 2013, 62(23): 234702. doi: 10.7498/aps.62.234702
    [16] 郭加宏, 戴世强, 代钦. 液滴冲击液膜过程实验研究. 物理学报, 2010, 59(4): 2601-2609. doi: 10.7498/aps.59.2601
    [17] 周丰茂, 孙东科, 朱鸣芳. 偏晶合金液-液相分离的格子玻尔兹曼方法模拟. 物理学报, 2010, 59(5): 3394-3401. doi: 10.7498/aps.59.3394
    [18] 闵敬春. 滴状冷凝中液滴的内外压差及临界半径. 物理学报, 2002, 51(12): 2730-2732. doi: 10.7498/aps.51.2730
    [19] 普小云, 柳清菊, 张中明, 林理忠. 表面单分子膜的垂悬液滴方法研究. 物理学报, 1998, 47(1): 60-67. doi: 10.7498/aps.47.60
    [20] 李标, 褚君浩, 陈新强, 刘坤, 曹菊英, 汤定元. 汞压对液相外延(Hg,Cd)Te的液相线及组份的影响. 物理学报, 1995, 44(6): 853-861. doi: 10.7498/aps.44.853
计量
  • 文章访问数:  5513
  • PDF下载量:  97
  • 被引次数: 0
出版历程
  • 收稿日期:  2018-02-23
  • 修回日期:  2018-05-12
  • 刊出日期:  2019-08-20

/

返回文章
返回