搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

镁颗粒-空气混合物一维稳态爆震波特性数值模拟

刘龙 夏智勋 黄利亚 马立坤 那旭东

引用本文:
Citation:

镁颗粒-空气混合物一维稳态爆震波特性数值模拟

刘龙, 夏智勋, 黄利亚, 马立坤, 那旭东

Numerical investigation of one-dimensional steady detonation wave characteristics for magnesium particle-air mixture

Liu Long, Xia Zhi-Xun, Huang Li-Ya, Ma Li-Kun, Na Xu-Dong
PDF
HTML
导出引用
  • 镁颗粒因其能量密度高、点火特性和燃烧效率好的优势, 作为燃料或添加剂应用于爆震燃烧动力系统具有广阔的应用前景. 本文建立了镁颗粒-空气混合物的一维稳态爆震波模型, 数值模拟爆震波稳态传播过程及其内部流场分布. 结果表明, 镁颗粒-空气混合物爆震波仅能以特征值速度稳定自维持传播, 特征值爆震速度的高低并不仅仅取决于反应放热多少, 两相间的相互作用也会影响热能向气相动能的转化效率. 当爆震波末端氧化镁处于熔化过程时, 满足一定的来流速度和镁颗粒密度条件, 爆震波仍能够稳定自维持传播. 气相吸收反应放热膨胀加速至声速的过程主要发生在镁颗粒纯蒸发反应阶段, 但在氧化镁熔化阶段由于熔化过程吸热量大, 使气相吸热膨胀过程近乎停止. 颗粒粒径变化主要影响爆震波尺寸, 而对特征值爆震速度以及波后声速面参数影响甚微. 在常温常压的初始条件下, 爆震波稳定自维持传播过程中波内不涉及氧化镁的汽化离解过程.
    Magnesium particles have broad application prospects as fuel or additive for detonation combustion power systems due to their high energy density, ignition characteristics and combustion efficiency. In this paper, a one-dimensional steady-state model is established for the magnesium particle-air mixture. The distribution of the flow field and the influences of factors such as phase transition process, inlet velocity, particle radius and initial particle density on the structure of detonation wave are analyzed numerically under different working conditions. The studies have shown that the process accelerating to the sound speed due to the expansion of the gas phase mainly occurs in the pure evaporation reaction stage of the magnesium particles. The duration of magnesium and magnesium oxide melting accounts for a small proportion of the entire combustion process. Under the initial conditions of normal temperature and pressure, the theoretical maximum temperature in the detonation wave during self-sustaining propagation is lower than the dissociation temperature of the magnesium oxide. The heat absorbed in the magnesium melting process is released into the gas phase for expansion work as the reaction progresses, leading to a small effect of magnesium melting on the structure of the detonation wave. The amount of exothermic heat absorbed in the magnesium oxide melting process is so large that the process of expansion of the gaseous working fluid is almost stopped. Moreover, the absorbed heat cannot be used for gas phase expansion work. Therefore, the melting process of magnesium oxide has a great influence on the structure of the detonation wave. The detonation wave of the magnesium particle-air mixture can be stabilized and self-sustained only at the eigenvalue velocity. Below this value, a singular point appears in the flow field. Above this value, the wave cannot be accelerated to the speed of sound, and the downstream flow field disturbance can pass through the reaction combustion zone and weaken the intensity of the detonation wave. When the end of the detonation wave is in the melting process, the detonation wave can still stabilize the self-sustaining propagation when a certain inflow velocity and a magnesium particle density are satisfied. Otherwise, the detonation wave can propagate only at an average speed with oscillation. The initial particle concentration corresponding to the peak of the eigenvalue velocity is smaller than the stoichiometric one corresponding to the peaks of the density, pressure and temperature, indicating that the eigenvalue velocity is not dependent solely on the heat release of the reaction because the interaction between the two phases also affects the conversion efficiency of thermal energy into gas phase kinetic energy. Under the premise of uniform distribution of internal temperature of magnesium particles, the particle size mainly affects the size of the detonation wave, but has little effect on the characteristic value of the eigenvalue velocity and the Chapman-Jouguet parameters. The model in this paper comprehensively reflects the influence of the phase transition process in the combustion process on the structure of the detonation wave and the self-sustaining propagation mechanism. It has a certain guiding significance for designing the detonation power device using powder fuel.
      通信作者: 黄利亚, huangliya05@nudt.edu.cn
    • 基金项目: 国家自然科学基金(批准号: 51706241, 11572349)资助的课题
      Corresponding author: Huang Li-Ya, huangliya05@nudt.edu.cn
    • Funds: Project supported by the National Natural Science Foundation of China (Grant Nos. 51706241, 11572349)
    [1]

    Wolanski P 2013 Proc. Combust. Inst. 34 125Google Scholar

    [2]

    Veyssiere B, Ingignoli W 2003 Shock Waves 12 291Google Scholar

    [3]

    Veyssiere B, Bozier O, Khasainov B 2002 Shock Waves 12 227Google Scholar

    [4]

    Palaszewski B, Jurns J, Breisacher K, Kearns K 2004 40th AIAA/ASME/SAE/ASEE Joint Propulsion Conference and Exhibit Fort Lauderdale, Florida, USA, July 11−14, 2004 p4191

    [5]

    Bykovskii F A, Zhdan S A, Vedernikov E F, Zholobov Yu A 2010 Dokl. Phys. 55 142Google Scholar

    [6]

    Bykovskii F A, Zhdan S A, Vedernikov E F, Zholobov Yu A 2011 Combust. Expl. Shock Waves 47 473Google Scholar

    [7]

    Bykovskii F A, Zhdan S A, Vedernikov E F, Zholobov Yu A 2012 Combust. Expl. Shock Waves 48 203Google Scholar

    [8]

    Bykovskii F A, Zhdan S A, Vedernikov E F, Zholobov Yu A 2013 Combust. Expl. Shock Waves 49 705Google Scholar

    [9]

    Bykovskii F A, Zhdan S A, Vedernikov E F 2014 Combust. Expl. Shock Waves 50 214Google Scholar

    [10]

    Lee J H S 1998 The Detonation Phenomenon (New York: Cambridge University Press) p7

    [11]

    Fedorov A V, Khmel’ T A, Fomin V M 1999 Shock Waves 9 313Google Scholar

    [12]

    洪滔 2003 博士学位论文 (北京: 中国工程物理研究院)

    Hong T 2003 Ph. D. Dissertation (Beijing: China Academy of Engineering Physics) (in Chinese)

    [13]

    Zhang F 2009 Shock Wave Science and Technology Reference Library (Vol. 4) ( Berlin, Heidelberg: Springer) pp99, 153, 159

    [14]

    Uphoff U, Hänel D, Roth P 1996 Shock Waves 6 17Google Scholar

    [15]

    Fedorov A V, Khmel T A 1999 Combust. Expl. Shock Waves 35 288Google Scholar

    [16]

    Benkiewicz K, Hayashi K 2003 Shock Waves 12 385Google Scholar

    [17]

    洪滔, 秦承森 2004 爆炸与冲击 24 193Google Scholar

    Hong T, Qing C S 2004 Expl. Shock Wave 24 193Google Scholar

    [18]

    Fedorov A V, Khmel’ T A 2005 Combust. Expl. Shock Waves 41 78Google Scholar

    [19]

    Fedorov A V, Khmel’ T A 2005 Combust. Expl. Shock Waves 41 435Google Scholar

    [20]

    Fedorov A V, Khmel’ T A 2008 Combust. Expl. Shock Waves 44 343Google Scholar

    [21]

    胡洪波, 翁春生 2011 火箭推进 37 47Google Scholar

    Hu H B, Wen C S 2011 J. Rocket Propul. 37 47Google Scholar

    [22]

    韦伟, 翁春生 2012 弹道学报 24 99Google Scholar

    Wei W, Wen C S 2012 J. Ball 24 99Google Scholar

    [23]

    韦伟, 翁春生 2012 南京师范大学学报(工程技术版) 12 53Google Scholar

    Wei W, Wen C S 2012 J. Nanjing Normal University (Eng. Technol. Ed.) 12 53Google Scholar

    [24]

    韦伟, 翁春生 2015 爆炸与冲击 35 29Google Scholar

    Wei W, Wen C S 2015 Expl. Shock Wave 35 29Google Scholar

    [25]

    韦伟, 翁春生 2017 固体火箭技术 40 41

    Wei W, Wen C S 2017 J. Solid Rock. Technol. 40 41

    [26]

    昝文涛, 洪滔, 董贺飞 2017 含能材料 25 508Google Scholar

    Zan W T, Hong T, Dong H F 2017 Chin. J. Energ. Mater. 25 508Google Scholar

    [27]

    Teng H, Jiang Z 2013 Combust. Flame 160 463Google Scholar

    [28]

    杨晋朝, 夏智勋, 胡建新 2012 物理学报 61 164702Google Scholar

    Yang J C, Xia Z X, Hu J X 2012 Acta Phys. Sin. 61 164702Google Scholar

    [29]

    杨晋朝, 夏智勋, 胡建新 2013 物理学报 62 074701Google Scholar

    Yang J C, Xia Z X, Hu J X 2013 Acta Phys. Sin. 62 074701Google Scholar

    [30]

    方丁酉 1988 两相流动力学(长沙: 国防科技大学出版社) 第17页

    Fang D J 1988 Two-phase Flow Dynamics (Changsha: National Defense Science and Technology University Press) p17 (in Chinese)

    [31]

    Steinberg T A, Wilson D, Benz F 1992 Combust. Flame 91 200Google Scholar

    [32]

    Kashireninov O E, Kuznetsov V A, Manelis G B 1977 Aiaa J. 15 1035

    [33]

    Gosteev Y A, Fedorov A V 2005 Combust. Expl. Shock Waves 41 190Google Scholar

    [34]

    洪滔, 秦承森 1999 爆炸与冲击 19 335Google Scholar

    Hong T, Qing C S 1999 Expl. Shock Wave 19 335Google Scholar

    [35]

    Zhang F, Murray S B, Gerrard K B 2004 Proceedings of the 24th International Symposium on Shock Waves Beijing, China, July 11−16, 2004 p795

    [36]

    杨世铭, 陶文铨 2006 传热学 (第4版) (北京:高等教育出版社) 第121页

    Yang S M, Tao W Q 2006 Heat Transfer (4th Ed.) (Beijing: Higher Education Press) p121 (in Chinese)

  • 图 1  一维稳态爆震波结构示意图

    Fig. 1.  Schematic of the steady one-dimensionional detonation wave.

    图 2  不同网格条件下气相密度分布(内插图为局部放大图)

    Fig. 2.  Spatial distribution of the gas-phase density with different grid sizes. Inset shows the view of partial enlargement.

    图 3  不同来流速度条件下爆震波末端$1 - Ma_1^2$$\phi $的空间分布

    Fig. 3.  Spatial distribution of $1 - Ma_1^2$ and $\phi $ at the end of detonation wave with different inlet velocity.

    图 4  爆震波流场参数分布 (a) 密度和质量分数; (b) 速度和压力; (c) 温度

    Fig. 4.  Parameters distribution in detonation wave: (a) Density and mass fraction; (b) velocity and pressure; (c) temperature.

    图 5  气态工质爆震燃烧过程压力-比体积曲线 (a) Mg熔化; (b) MgO熔化

    Fig. 5.  Pressure-specific volume curve of detonation combustion in gaseous phase: (a) Mg fusion; (b) MgO fusion.

    图 6  流场参数随颗粒相初始密度的变化 (a) 特征值速度和激波诱导下限速度; (b) 密度; (c) 速度和压力; (d) 温度

    Fig. 6.  Variation of parameters with different initial concentration of particle phase: (a) Eigenvalue detonation velocity and minimum velocity of particle ignition induced by shock wave; (b) density; (c) velocity and pressure; (d) temperature.

    图 7  流场参数随颗粒初始半径的变化 (a)速度; (b)密度和压力; (c)温度; (d)爆震波长度

    Fig. 7.  Variation of parameters with different initial particle radii: (a) Velocity; (b) density and pressure; (c) temperature; (d) length of detonation wave.

    表 1  镁和铝的结果对比

    Table 1.  Comparison of results of magnesium and aluminum detonation.

    燃料种类质量热值/MJ·kg–1理论空燃比爆震波速度/m·s–1CJ面密度/kg·m–3CJ面速度/m·s–1CJ面压力/MPa
    25.062.871782.283.27942.72.87
    31.073.8316502.436732.04
    下载: 导出CSV

    表 2  诱导区及相变区长度

    Table 2.  Length of induction region and phase-transition region.

    总长度诱导区燃烧区
    (Mg蒸发)
    Mg
    熔化
    MgO
    熔化
    MgO
    离解
    空间长度/m0.33240.03540.2970.01160.0048 ×
    占比10.1060.8940.0350.014 ×
    下载: 导出CSV

    表 3  相变过程对爆震波结构影响对比

    Table 3.  Effect of phase transition on structure of detonation wave.

    $\Delta h_{\rm{Mg},f}$/MJ·kg–1$\Delta h_{\rm{MgO},f}$/MJ·kg–1$\eta_{0.99\rm{CJ}}$燃烧区占比
    0.3541.9460.9950.894
    01.9460.9520.885
    0.35400.5730.872
    000.5490.865
    下载: 导出CSV
  • [1]

    Wolanski P 2013 Proc. Combust. Inst. 34 125Google Scholar

    [2]

    Veyssiere B, Ingignoli W 2003 Shock Waves 12 291Google Scholar

    [3]

    Veyssiere B, Bozier O, Khasainov B 2002 Shock Waves 12 227Google Scholar

    [4]

    Palaszewski B, Jurns J, Breisacher K, Kearns K 2004 40th AIAA/ASME/SAE/ASEE Joint Propulsion Conference and Exhibit Fort Lauderdale, Florida, USA, July 11−14, 2004 p4191

    [5]

    Bykovskii F A, Zhdan S A, Vedernikov E F, Zholobov Yu A 2010 Dokl. Phys. 55 142Google Scholar

    [6]

    Bykovskii F A, Zhdan S A, Vedernikov E F, Zholobov Yu A 2011 Combust. Expl. Shock Waves 47 473Google Scholar

    [7]

    Bykovskii F A, Zhdan S A, Vedernikov E F, Zholobov Yu A 2012 Combust. Expl. Shock Waves 48 203Google Scholar

    [8]

    Bykovskii F A, Zhdan S A, Vedernikov E F, Zholobov Yu A 2013 Combust. Expl. Shock Waves 49 705Google Scholar

    [9]

    Bykovskii F A, Zhdan S A, Vedernikov E F 2014 Combust. Expl. Shock Waves 50 214Google Scholar

    [10]

    Lee J H S 1998 The Detonation Phenomenon (New York: Cambridge University Press) p7

    [11]

    Fedorov A V, Khmel’ T A, Fomin V M 1999 Shock Waves 9 313Google Scholar

    [12]

    洪滔 2003 博士学位论文 (北京: 中国工程物理研究院)

    Hong T 2003 Ph. D. Dissertation (Beijing: China Academy of Engineering Physics) (in Chinese)

    [13]

    Zhang F 2009 Shock Wave Science and Technology Reference Library (Vol. 4) ( Berlin, Heidelberg: Springer) pp99, 153, 159

    [14]

    Uphoff U, Hänel D, Roth P 1996 Shock Waves 6 17Google Scholar

    [15]

    Fedorov A V, Khmel T A 1999 Combust. Expl. Shock Waves 35 288Google Scholar

    [16]

    Benkiewicz K, Hayashi K 2003 Shock Waves 12 385Google Scholar

    [17]

    洪滔, 秦承森 2004 爆炸与冲击 24 193Google Scholar

    Hong T, Qing C S 2004 Expl. Shock Wave 24 193Google Scholar

    [18]

    Fedorov A V, Khmel’ T A 2005 Combust. Expl. Shock Waves 41 78Google Scholar

    [19]

    Fedorov A V, Khmel’ T A 2005 Combust. Expl. Shock Waves 41 435Google Scholar

    [20]

    Fedorov A V, Khmel’ T A 2008 Combust. Expl. Shock Waves 44 343Google Scholar

    [21]

    胡洪波, 翁春生 2011 火箭推进 37 47Google Scholar

    Hu H B, Wen C S 2011 J. Rocket Propul. 37 47Google Scholar

    [22]

    韦伟, 翁春生 2012 弹道学报 24 99Google Scholar

    Wei W, Wen C S 2012 J. Ball 24 99Google Scholar

    [23]

    韦伟, 翁春生 2012 南京师范大学学报(工程技术版) 12 53Google Scholar

    Wei W, Wen C S 2012 J. Nanjing Normal University (Eng. Technol. Ed.) 12 53Google Scholar

    [24]

    韦伟, 翁春生 2015 爆炸与冲击 35 29Google Scholar

    Wei W, Wen C S 2015 Expl. Shock Wave 35 29Google Scholar

    [25]

    韦伟, 翁春生 2017 固体火箭技术 40 41

    Wei W, Wen C S 2017 J. Solid Rock. Technol. 40 41

    [26]

    昝文涛, 洪滔, 董贺飞 2017 含能材料 25 508Google Scholar

    Zan W T, Hong T, Dong H F 2017 Chin. J. Energ. Mater. 25 508Google Scholar

    [27]

    Teng H, Jiang Z 2013 Combust. Flame 160 463Google Scholar

    [28]

    杨晋朝, 夏智勋, 胡建新 2012 物理学报 61 164702Google Scholar

    Yang J C, Xia Z X, Hu J X 2012 Acta Phys. Sin. 61 164702Google Scholar

    [29]

    杨晋朝, 夏智勋, 胡建新 2013 物理学报 62 074701Google Scholar

    Yang J C, Xia Z X, Hu J X 2013 Acta Phys. Sin. 62 074701Google Scholar

    [30]

    方丁酉 1988 两相流动力学(长沙: 国防科技大学出版社) 第17页

    Fang D J 1988 Two-phase Flow Dynamics (Changsha: National Defense Science and Technology University Press) p17 (in Chinese)

    [31]

    Steinberg T A, Wilson D, Benz F 1992 Combust. Flame 91 200Google Scholar

    [32]

    Kashireninov O E, Kuznetsov V A, Manelis G B 1977 Aiaa J. 15 1035

    [33]

    Gosteev Y A, Fedorov A V 2005 Combust. Expl. Shock Waves 41 190Google Scholar

    [34]

    洪滔, 秦承森 1999 爆炸与冲击 19 335Google Scholar

    Hong T, Qing C S 1999 Expl. Shock Wave 19 335Google Scholar

    [35]

    Zhang F, Murray S B, Gerrard K B 2004 Proceedings of the 24th International Symposium on Shock Waves Beijing, China, July 11−16, 2004 p795

    [36]

    杨世铭, 陶文铨 2006 传热学 (第4版) (北京:高等教育出版社) 第121页

    Yang S M, Tao W Q 2006 Heat Transfer (4th Ed.) (Beijing: Higher Education Press) p121 (in Chinese)

  • [1] 刘龙, 夏智勋, 黄利亚, 马立坤, 陈斌斌. 镁颗粒-空气混合物一维非稳态爆震波特性数值模拟研究. 物理学报, 2020, 69(19): 194701. doi: 10.7498/aps.69.20200549
    [2] 李诗尧, 于明. 固体炸药爆轰的一种考虑热学非平衡的反应流动模型. 物理学报, 2018, 67(21): 214704. doi: 10.7498/aps.67.20172501
    [3] 蒋亦民, 刘佑. 颗粒-颗粒接触力的热力学模型. 物理学报, 2018, 67(4): 044502. doi: 10.7498/aps.67.20171441
    [4] 梁霄, 王瑞利. 爆轰流体力学模型敏感度分析与模型确认. 物理学报, 2017, 66(11): 116401. doi: 10.7498/aps.66.116401
    [5] 李响, 吴德伟, 王希, 苗强, 陈坤, 杨春燕. 一种基于von Neumann熵的双路径纠缠量子微波信号生成质量评估方法. 物理学报, 2016, 65(11): 114204. doi: 10.7498/aps.65.114204
    [6] 陈福振, 强洪夫, 苗刚, 高巍然. 燃料抛撒成雾及其燃烧爆炸的光滑离散颗粒流体动力学方法数值模拟研究. 物理学报, 2015, 64(11): 110202. doi: 10.7498/aps.64.110202
    [7] 周洪强, 于明, 孙海权, 董贺飞, 张凤国. 炸药爆轰的连续介质本构模型和数值计算方法. 物理学报, 2014, 63(22): 224702. doi: 10.7498/aps.63.224702
    [8] 杨辰, 房超, 张建, 曹建主. 球床高温气冷堆燃料颗粒中放射性核素的累积释放份额研究. 物理学报, 2014, 63(3): 032802. doi: 10.7498/aps.63.032802
    [9] 韩冬, 陈良富, 李莘莘, 陶金花, 苏林, 邹铭敏, 范萌. 基于振动拉曼散射的差分水Ring效应系数卷积计算模型. 物理学报, 2013, 62(10): 109301. doi: 10.7498/aps.62.109301
    [10] 杨晋朝, 夏智勋, 胡建新. 镁颗粒群着火和燃烧过程数值模拟. 物理学报, 2013, 62(7): 074701. doi: 10.7498/aps.62.074701
    [11] 景龙飞, 黄天晅, 江少恩, 陈伯伦, 蒲昱东, 胡峰, 程书博. 神光-Ⅱ和神光-Ⅲ原型内爆对称性实验的模型分析. 物理学报, 2012, 61(10): 105205. doi: 10.7498/aps.61.105205
    [12] 王浩, 刘国权, 栾军华. 凸形晶粒的各向异性三维von Neumann方程研究. 物理学报, 2012, 61(4): 048102. doi: 10.7498/aps.61.048102
    [13] 房超, 刘马林. 包覆燃料颗粒碳化硅层的Raman光谱研究. 物理学报, 2012, 61(9): 097802. doi: 10.7498/aps.61.097802
    [14] 杨晋朝, 夏智勋, 胡建新. 镁颗粒群非稳态着火过程数值模拟. 物理学报, 2012, 61(16): 164702. doi: 10.7498/aps.61.164702
    [15] 余本海, 刘墨林, 陈东. 第一性原理研究Mg2 Si同质异相体的结构、电子结构和弹性性质. 物理学报, 2011, 60(8): 087105. doi: 10.7498/aps.60.087105
    [16] 陆坤权, 厚美瑛, 王强, 姜泽辉, 刘寄星. 震前兆信息传播、分布及其探测原理. 物理学报, 2011, 60(11): 119101. doi: 10.7498/aps.60.119101
    [17] 杨义涛, 张崇宏, 周丽宏, 李炳生, 张丽卿. 惰性气体离子注入铝镁尖晶石合成金属纳米颗粒的探索. 物理学报, 2009, 58(1): 399-403. doi: 10.7498/aps.58.399
    [18] 郭树旭, 王 伟, 石家纬. 并五苯同质异相体中分子间势能与能带计算. 物理学报, 2007, 56(7): 4085-4088. doi: 10.7498/aps.56.4085
    [19] 杨洪琼, 杨建伦, 温树槐, 王根兴, 郭玉芝, 唐正元, 牟维兵, 马驰. 激光直接驱动内爆DT燃料面密度诊断. 物理学报, 2001, 50(12): 2408-2412. doi: 10.7498/aps.50.2408
    [20] 陈仁. 关于磁流体力学激波中的开闸激震与关闸激震是否存在的问题. 物理学报, 1966, 22(9): 1098-1102. doi: 10.7498/aps.22.1098
计量
  • 文章访问数:  5379
  • PDF下载量:  53
  • 被引次数: 0
出版历程
  • 收稿日期:  2019-06-23
  • 修回日期:  2019-09-05
  • 上网日期:  2019-11-27
  • 刊出日期:  2019-12-01

/

返回文章
返回