搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

ZnO压敏陶瓷缺陷结构表征及冲击老化机理研究

赵学童 李建英 李欢 李盛涛

引用本文:
Citation:

ZnO压敏陶瓷缺陷结构表征及冲击老化机理研究

赵学童, 李建英, 李欢, 李盛涛

Characterization of defects and research on impulse aging in ZnO varistor ceramics

Zhao Xue-Tong, Li Jian-Ying, Li Xuan, Li Sheng-Tao
PDF
导出引用
  • 对多元ZnO压敏陶瓷电阻片进行了多达14000次的大电流冲击老化试验, 通过显微结构、电气性能及介电特性的测量对其缺陷结构进行了表征, 并研究了缺陷结构与大电流冲击老化之间的关系. 试验表明多次大电流冲击老化导致试样的电气性能明显下降, 发现ZnO压敏陶瓷的几何效应不仅受控于晶粒还与晶界密切相关. 另外, 通过介电谱分析观察到ZnO压敏陶瓷存在四种缺陷弛豫过程, 低温-60 ℃下的两个缺陷弛豫峰激活能约为0.24 eV和0.35 eV, 认为它们分别对应着本征的锌填隙缺陷L(Zni··)和氧空位缺陷L(VO·)并且不受冲击老化的影响. 高温80℃以上两个松弛峰的活化能约为0.71 eV和0.84 eV, 认为它们分别对应着非本征的晶间相电子陷阱L(ingr)和晶界处界面态陷阱L(gb). 发现大电流冲击后, 仅界面态陷阱激活能从0.84 eV降低到0.76 eV, 认为界面态陷阱主要控制着ZnO压敏陶瓷的电气性能和稳定性.
    The electrical and dielectric properties and the microstructures of a polynary ZnO-based varistor ceramics with 14000 times impulse current aging test are measured. The relationship between defect structure and impulse current aging is mainly investigated. It is found that the electrical properties decrease rapidly with impulse aging and the dimensional effect of ZnO varistor ceramics is dominated not only by grain but also by grain boundary. Additionally, four defect relaxations are found at different temperatures by using dielectric spectra. Two defect relaxations appearing below -60 ℃ with activation energies about 0.24 eV and 0.35 eV are identified to be intrinsic defects originating from interstitial Zn L(Zni··) and vacancy oxygen L(VO·), which are not affected by impulse current aging. Other two relaxations appearing above 80 °C are suggested to be extrinsic defects originating from trap levels L(ingr) at intergranular phase and trap levels L(gb) at grain-boundary interfaces, respectively. Only L(gb) decreases from 0.84 eV to 0.76 eV due to impulse current aging while other trap levels keep unchanged. It is further proposed that L(gb) is responsible mainly for the electrical property and stability of ZnO ceramics.
    • 基金项目: 国家自然科学基金(批准号: 50977071, 51177121)资助的课题.
    • Funds: Project supported by the National Natural Science Foundation of China (Grant Nos. 50977071 and 51177121).
    [1]

    Gupta T K, Straub W D 1989 J. Appl. Phys. 66 6132

    [2]

    Xu D, Shi L Y, Wu Z H, Zhong Q D, Wu X X 2009 J. Eur. Ceram. Soc. 29 1789

    [3]

    Fayat J, Castro M S 2003 J. Eur. Ceram. Soc. 23 1585

    [4]

    Cordaro J F, Shim Y, May J E 1986 J. Appl. Phys. 60 4186

    [5]

    Chiou B S, Chung M C 1991 J. Electron. Mat. 20 885

    [6]

    Greuter F, Blatter G 1990 Semicond. Sci. Technol. 5 111

    [7]

    Levinson L M, Philipp H R 1976 J. Appl. Phys. 47 1117

    [8]

    Cheng P F, Li S T, Li J Y 2009 Acta Phys. Sin. 58 5721 (in Chinese) [成鹏飞, 李盛涛, 李建英 2009 物理学报 58 5721]

    [9]

    Cheng P, Li S, Zhang L, Li J 2008 Appl. Phys. Lett. 93 012902

    [10]

    Rohatgi A, Pang S K, Gupta T K, Straub W D 1988 J. Appl. Phys. 63 5375

    [11]

    Lee W I, Young R L 1996 Appl. Phys. Lett. 69 526

    [12]

    Li F F, Wang S L, Xu Y C 1993 Proceedings of the CSEE 3 25 (in Chinese) [李慧峰, 王士良, 许毓春 1993 中国电机工程学报(增刊) 3 25]

    [13]

    Li S T, Li J Y, Alim M A 2003 J. Electroceram 11 119

    [14]

    Yin G L, Li J Y, Yao G, Cheng P F, Li S T 2010 Acta Phys. Sin. 59 6345 (in Chinese) [尹桂来, 李建英, 尧广, 成鹏飞, 李盛涛 2010 物理学报 59 6345]

    [15]

    Chen J D, Liu Z Y, 1982 Dielectric Physics (Beijing: Mechanical Industry Press) p151 (in Chinese) [陈季丹, 刘子玉 1982 电介质物理学 (北京: 机械工业出版社) 第151页]

    [16]

    Tripathi R, Kumar A, Bharti C, Sinha T P 2010 Curr. Appl. Phys. 10 676

    [17]

    Roling B, Happe A, Funke K, Ingram M D 1997 Phys. Rev. Lett. 78 2160

    [18]

    Hong Y W, Kim J H 2004 Ceram. Int. 30 1307

    [19]

    Andres-Verges M, West A R 1997 J. Electroceram. 1 125

    [20]

    Tao M, Ai B, Dorlanne O, Loubiere A 1986 J. Appl. Phys. 61 1562

    [21]

    Leach C, Vernon-Parry K D, Ali N K 2010 J. Elctroceram. 25 188

    [22]

    Yin G L, Li J Y, Li S T 2009 Acta Phys. Sin. 58 4219 (in Chinese) [尹桂来, 李建英, 李盛涛 2009 物理学报 58 4219]

  • [1]

    Gupta T K, Straub W D 1989 J. Appl. Phys. 66 6132

    [2]

    Xu D, Shi L Y, Wu Z H, Zhong Q D, Wu X X 2009 J. Eur. Ceram. Soc. 29 1789

    [3]

    Fayat J, Castro M S 2003 J. Eur. Ceram. Soc. 23 1585

    [4]

    Cordaro J F, Shim Y, May J E 1986 J. Appl. Phys. 60 4186

    [5]

    Chiou B S, Chung M C 1991 J. Electron. Mat. 20 885

    [6]

    Greuter F, Blatter G 1990 Semicond. Sci. Technol. 5 111

    [7]

    Levinson L M, Philipp H R 1976 J. Appl. Phys. 47 1117

    [8]

    Cheng P F, Li S T, Li J Y 2009 Acta Phys. Sin. 58 5721 (in Chinese) [成鹏飞, 李盛涛, 李建英 2009 物理学报 58 5721]

    [9]

    Cheng P, Li S, Zhang L, Li J 2008 Appl. Phys. Lett. 93 012902

    [10]

    Rohatgi A, Pang S K, Gupta T K, Straub W D 1988 J. Appl. Phys. 63 5375

    [11]

    Lee W I, Young R L 1996 Appl. Phys. Lett. 69 526

    [12]

    Li F F, Wang S L, Xu Y C 1993 Proceedings of the CSEE 3 25 (in Chinese) [李慧峰, 王士良, 许毓春 1993 中国电机工程学报(增刊) 3 25]

    [13]

    Li S T, Li J Y, Alim M A 2003 J. Electroceram 11 119

    [14]

    Yin G L, Li J Y, Yao G, Cheng P F, Li S T 2010 Acta Phys. Sin. 59 6345 (in Chinese) [尹桂来, 李建英, 尧广, 成鹏飞, 李盛涛 2010 物理学报 59 6345]

    [15]

    Chen J D, Liu Z Y, 1982 Dielectric Physics (Beijing: Mechanical Industry Press) p151 (in Chinese) [陈季丹, 刘子玉 1982 电介质物理学 (北京: 机械工业出版社) 第151页]

    [16]

    Tripathi R, Kumar A, Bharti C, Sinha T P 2010 Curr. Appl. Phys. 10 676

    [17]

    Roling B, Happe A, Funke K, Ingram M D 1997 Phys. Rev. Lett. 78 2160

    [18]

    Hong Y W, Kim J H 2004 Ceram. Int. 30 1307

    [19]

    Andres-Verges M, West A R 1997 J. Electroceram. 1 125

    [20]

    Tao M, Ai B, Dorlanne O, Loubiere A 1986 J. Appl. Phys. 61 1562

    [21]

    Leach C, Vernon-Parry K D, Ali N K 2010 J. Elctroceram. 25 188

    [22]

    Yin G L, Li J Y, Li S T 2009 Acta Phys. Sin. 58 4219 (in Chinese) [尹桂来, 李建英, 李盛涛 2009 物理学报 58 4219]

  • [1] 马天慧, 雷作涛, 张晓萌, 付秋月, 布和巴特尔, 朱崇强, 杨春晖. 密度泛函理论研究ZnGeP2晶体中缺陷的稳定性及迁移机制. 物理学报, 2022, 71(22): 227101. doi: 10.7498/aps.71.20220610
    [2] 赵小强, 赵学童, 许超, 李巍巍, 任路路, 廖瑞金, 李建英. ZnO-Bi2O3系压敏陶瓷缺陷弛豫特性的研究进展. 物理学报, 2017, 66(2): 027701. doi: 10.7498/aps.66.027701
    [3] 邢兰俊, 常永勤, 邵长景, 王琳, 龙毅. Sn掺杂ZnO薄膜的室温气敏性能及其气敏机理. 物理学报, 2016, 65(9): 097302. doi: 10.7498/aps.65.097302
    [4] 李龙, 王鸣, 倪海彬, 沈添怿. 采用溶胶凝胶协同自组装与光刻相结合的方法在反蛋白石结构薄膜中引入二维缺陷. 物理学报, 2014, 63(5): 054206. doi: 10.7498/aps.63.054206
    [5] 刘小龙, 黄建国, 雷开卓. 水下等离子体声源的冲击波负压特性. 物理学报, 2013, 62(20): 204301. doi: 10.7498/aps.62.204301
    [6] 赵学童, 李建英, 贾然, 李盛涛. 直流老化及热处理对ZnO压敏陶瓷缺陷结构的影响. 物理学报, 2013, 62(7): 077701. doi: 10.7498/aps.62.077701
    [7] 王辉, 蔺家骏, 何锦强, 廖永力, 李盛涛. 沉淀剂对ZnO压敏陶瓷缺陷结构和电气性能的影响. 物理学报, 2013, 62(22): 226103. doi: 10.7498/aps.62.226103
    [8] 张丽娟, 王力海, 刘建党, 李强, 成斌, 张杰, 安然, 赵明磊, 叶邦角. 非铁电压电复合陶瓷SrTiO3-Bi12TiO20 (ST-BT) 的正电子湮没谱学研究. 物理学报, 2012, 61(23): 237805. doi: 10.7498/aps.61.237805
    [9] 成鹏飞, 李盛涛, 李建英. ZnO压敏陶瓷的介电谱. 物理学报, 2012, 61(18): 187302. doi: 10.7498/aps.61.187302
    [10] 王雪梅, 刘红. 锯齿型石墨烯纳米带的能带研究. 物理学报, 2011, 60(4): 047102. doi: 10.7498/aps.60.047102
    [11] 曹蕾, 刘鹏, 周剑平, 王亚娟, 苏丽娜, 刘成. CaCu3Ti4O12-MgTiO3陶瓷的介电性能与I-V非线性特征. 物理学报, 2011, 60(3): 037701. doi: 10.7498/aps.60.037701
    [12] 成鹏飞, 李盛涛, 李建英. ZnO-Bi2O3系压敏陶瓷的晶界电子结构. 物理学报, 2010, 59(1): 560-565. doi: 10.7498/aps.59.560
    [13] 尹桂来, 李建英, 尧广, 成鹏飞, 李盛涛. ZnO压敏陶瓷冲击老化的电子陷阱过程研究. 物理学报, 2010, 59(9): 6345-6350. doi: 10.7498/aps.59.6345
    [14] 李盛涛, 成鹏飞, 杨雁, 张乐. ZnO压敏陶瓷电导研究的新方法. 物理学报, 2009, 58(4): 2543-2548. doi: 10.7498/aps.58.2543
    [15] 成鹏飞, 李盛涛, 李建英. ZnO压敏陶瓷介电损耗的温度谱研究. 物理学报, 2009, 58(8): 5721-5725. doi: 10.7498/aps.58.5721
    [16] 李盛涛, 成鹏飞, 赵雷, 李建英. ZnO压敏陶瓷中缺陷的介电谱研究. 物理学报, 2009, 58(1): 523-528. doi: 10.7498/aps.58.523
    [17] 成鹏飞, 李盛涛, 焦兴六. ZnO-Bi2O3系压敏陶瓷的导电过程与等效势垒高度. 物理学报, 2006, 55(8): 4253-4258. doi: 10.7498/aps.55.4253
    [18] 张纯祥, 林理彬, 唐 强, 罗达玲. α-Al2O3: Mn单晶的三维热释发光谱研究. 物理学报, 2004, 53(11): 3940-3944. doi: 10.7498/aps.53.3940
    [19] 陈晓波, 李美仙, N.Sawanobori, 曾 哲, 聂玉昕. 掺Er3+氟氧化物玻璃陶瓷的直接上转换敏化发光. 物理学报, 2000, 49(12): 2482-2487. doi: 10.7498/aps.49.2482
    [20] 傅刚, 陈志雄, 石滨. ZnO压敏陶瓷中的本征缺陷. 物理学报, 1996, 45(5): 850-853. doi: 10.7498/aps.45.850
计量
  • 文章访问数:  6137
  • PDF下载量:  646
  • 被引次数: 0
出版历程
  • 收稿日期:  2011-11-30
  • 修回日期:  2011-12-31
  • 刊出日期:  2012-08-05

/

返回文章
返回