Simulation and sesign of single event effect radiation hardening for SiGe heterojunction bipolar transistor

Li Pei; Guo Hong-Xia; Guo Qi; Wen Lin; Cui Jiang-Wei; Wang Xin; Zhang Jin-Xin

doi:10.7498/aps.64.118502

Abstract

With the rapid development of satellite, manned space flight and deep space exploration technology, semiconductor devices are used in extreme environments, especially in radiation and low temperature environment. SiGe HBT is a potential candidate for space applications because of its inherent robustness to total ionizing dose (TID) radiation. However, due primarily to charge collection through the collector-substrate (CS) junction and the relatively low substrate doping., SiGe HBTs are vulnerable to single event effects (SEEs) because of new features of process and structure. Thus, the SEE becomes a key factor in restricting space applications of SiGe HBTs. This paper presents an SEE hardening approach that uses a dummy collector to reduce charge collection in the SiGe HBT. The dummy collector is obtained by using the silicon space between adjacent HBTs. It is obtained without any process modification or area penalty. At first, we build simulation models for both normal and hardened SiGe HBTs, and then carry out SEE simulations respectively. The charge collection mechanism is obtained by analyzing the transient current and charge collection changes at different ion incident positions. Unlike the normal HBT, we can see that charge is continuously collected by the dummy CS junction. This causes more charges diffuse outward and the charges available for collector terminal to be reduced. For all ion incident positions, in the case of hardening, the drift components of charge collection are approximately the same, while the diffusion charge collection components are nearly completely compressed. During SEE, the CS junction either directly collects the deposited charges through drift within the potential funnel or indirectly collects charges after they have arrived at the junction after diffusion. The diffusion length of the carriers is on the order of tens of microns or more. Hence a dummy CS junction should be able to reduce the quantity of diffusive charges collected by the HBT collector. The actual charges collected by the collector are effectively reduced. The emitter and base charge collection also decrease by the dummy collector to different extents. Dummy-collector effectively mitigates the SEE of SiGe HBT. The SEE sensitive area of SiGe HBT is also effectively reduced by half. This work is carried out for the SiGe HBT circuit level radiation hardening design of single event effects

Keywords:

SiGe heterojunction bipolar transistor /
single event effect /
hardening design /
dummy collector

Authors and contacts

1.
Key Laboratory of Functional Materials and Devices for Special Environments of CAS; Xinjiang Key Laboratory of Electronic Information Materials and Devices; Xinjiang Technical Institute of Physics & Chemistry of CAS, 40-1 South Beijing Road, Urumqi 830011, China;
2.
University of Chinese Academy of Sciences, Beijing 100049, China;
3.
Northwest Institution of Nuclear Technology, Xi’an 710024, China;
4.
Xi’an Jiao Tong University, Xi’an 710049, China
Funds: Project supported by the National Natural Science Foundation of China (Grant No. 61274106).

References

[1]	Cressler J D 2013 IEEE Trans. Nucl. Sci. 60 1992
[2]	Cressler J D 2005 Proceedings of the Bipolar/BiCMOS Circuits and Technology Meeting Santa Barbara, October 9-11, 2005 p248
[3]	Cressler J D, Niu G F 2003 Silicon-germanium heterojunction bipolar transistors (Norwood:Artech House) pp95-182
[4]	Babcock J A, Cressler J D, Vempati L S, Clark S D, Jaeger R C, Harame D L 1995 IEEE Trans. Nucl. Sci. 42 1558
[5]	Lu Y, Cressler J D, Krithivasan R, Li Y, Reed R A, Marshall P W, Polar C, Freeman G, Ahlgren D 2003 IEEE Trans. Nucl. Sci. 50 1811
[6]	Sutton A K, Haugerud B M, Prakash A P G, Jun B, Cressler J D, Marshall C J, Marshall P W, Ladbury R, Joseph A J 2005 IEEE Trans. Nucl. Sci. 52 2358
[7]	Sutton A K, Prakash A P G, Jun B, Enhai Zhao, Bellini M, Pellish J, Diestelhorst R M, Carts M A, Phan A, Ladbury R, Cressler J D, Marshall P W, Marshall C J, Reed R A, Schrimpf R D, Fleetwood D M 2006 IEEE Trans. Nucl. Sci. 53 3166
[8]	Krithivasan R, Niu G F, Cressler J D, Currie S M, Fritz K E, Reed R A, Marshall P W, Riggs P A, Randall B A, Gilbert B 2003 IEEE Trans. Nucl. Sci. 50 2126
[9]	Krithivasan R, Marshall P W, Nayeem M, Sutton A K, Wei-Min Kuo, Haugerud B M, Najafizadeh L, Cressler J D, Carts M A, Marshall C J, Hansen D L, Jobe K C M, McKay A L, Niu G F, Reed R A, Randall B A, Burfield C A, Lindberg M D, Gilbert B K, Daniel E S IEEE Trans. Nucl. Sci. 53 3400
[10]	Reed R A, Marshall P W, Pickel J C, Carts M A, Fodness B, Niu G F, Fritz K, Vizkelethy G, Dodd P E, Irwin T L, Cressler J D, Krithivasan R, Riggs P A, Prairie J, Randall B A, Gilbert B K, Label K A 2003 IEEE Trans. Nucl. Sci. 50 2184
[11]	Sutton A K, Bellini M, Cressler J D, Pellish J A, Reed R A, Marshall P W, Niu G F, Vizkelethy G, Turowski M, Raman A 2007 IEEE Trans. Nucl. Sci. 54 2044
[12]	Marshall P W, Carts M A, Campbell A, McMorrow D, Buchner S, Stewart Ryan, Randall B, Gilbert Barry, Reed R A IEEE Trans. Nucl. Sci. 47 2669
[13]	Niu G F, Yang H, Varadharajaperumal M, Shi Y, Cressler J D, Krithivasan R, Marshall P W, Reed R A 2005 IEEE Trans. Nucl. Sci. 52 2153
[14]	Varadharajaperumal M, Niu G F, Wei X Y, Zhang T, Cressler J D, Reed R A, Marshall P W 2007 IEEE Trans. Nucl. Sci. 54 2330
[15]	Varadharajaperumal M 2010 Ph.D. Dissertation (Alabama:Auburn University)
[16]	Sutton A K, Bellini M, Cressler J D, Pellish J A, Reed R A, Marshall P W, Niu G f, Vizkelethy G, Turowski M, Raman A 2007 IEEE Trans. Nucl. Sci. 54 2044
[17]	Phillips S D, Moen K A, Najafizadeh L, Diestelhorst R M, Sutton A K, Cressler J D, Vizkelethy G, Dodd P E, Marshall P W 2010 IEEE Trans. Nucl. Sci. 57 3400
[18]	Zhang T 2009 MS Dissertation (Alabama:Auburn University)
[19]	Phillips S D 2012 Ph.D. Dissertation (Georgia:Georgia Institute of Technology)
[20]	Zhang J X, Guo H X, Guo Q, Wen L, Cui J W, Xi S B, Wang X, Deng W 2013 Acta Phys. Sin. 62 048501 (in Chinese) [张晋新, 郭红霞, 郭旗, 文林, 崔江维, 席善斌, 王信, 邓伟 2013 物理学报 62 048501]
[21]	Lai F, Hu G Y 2013 Microelectronics 43 0094 (in Chinese) [赖凡, 胡刚毅 2013 微电子学 43 0094]
[22]	Liu Z, Chen S M, Liang B, Liu B W, Zhao Z Y 2010 Acta Phys. Sin. 59 064906 (in Chinese) [刘征, 陈书明, 梁斌, 刘必慰, 赵振宇 2010 物理学报 59 064906]
[23]	Sun Y B, Fu J, Xu J, Wang Y D, Zhou W, Zhang W, Cui J, Li G Q, Liu Z H 2013 Acta Phys. Sin. 62 196104 (in Chinese) [孙亚宾, 付军, 许军, 王玉东, 周卫, 张伟, 崔杰, 李高庆, 刘志弘 2013 物理学报 62 196104]

Cited By

[1]	Cressler J D 2013 IEEE Trans. Nucl. Sci. 60 1992
[2]	Cressler J D 2005 Proceedings of the Bipolar/BiCMOS Circuits and Technology Meeting Santa Barbara, October 9-11, 2005 p248
[3]	Cressler J D, Niu G F 2003 Silicon-germanium heterojunction bipolar transistors (Norwood:Artech House) pp95-182
[4]	Babcock J A, Cressler J D, Vempati L S, Clark S D, Jaeger R C, Harame D L 1995 IEEE Trans. Nucl. Sci. 42 1558
[5]	Lu Y, Cressler J D, Krithivasan R, Li Y, Reed R A, Marshall P W, Polar C, Freeman G, Ahlgren D 2003 IEEE Trans. Nucl. Sci. 50 1811
[6]	Sutton A K, Haugerud B M, Prakash A P G, Jun B, Cressler J D, Marshall C J, Marshall P W, Ladbury R, Joseph A J 2005 IEEE Trans. Nucl. Sci. 52 2358
[7]	Sutton A K, Prakash A P G, Jun B, Enhai Zhao, Bellini M, Pellish J, Diestelhorst R M, Carts M A, Phan A, Ladbury R, Cressler J D, Marshall P W, Marshall C J, Reed R A, Schrimpf R D, Fleetwood D M 2006 IEEE Trans. Nucl. Sci. 53 3166
[8]	Krithivasan R, Niu G F, Cressler J D, Currie S M, Fritz K E, Reed R A, Marshall P W, Riggs P A, Randall B A, Gilbert B 2003 IEEE Trans. Nucl. Sci. 50 2126
[9]	Krithivasan R, Marshall P W, Nayeem M, Sutton A K, Wei-Min Kuo, Haugerud B M, Najafizadeh L, Cressler J D, Carts M A, Marshall C J, Hansen D L, Jobe K C M, McKay A L, Niu G F, Reed R A, Randall B A, Burfield C A, Lindberg M D, Gilbert B K, Daniel E S IEEE Trans. Nucl. Sci. 53 3400
[10]	Reed R A, Marshall P W, Pickel J C, Carts M A, Fodness B, Niu G F, Fritz K, Vizkelethy G, Dodd P E, Irwin T L, Cressler J D, Krithivasan R, Riggs P A, Prairie J, Randall B A, Gilbert B K, Label K A 2003 IEEE Trans. Nucl. Sci. 50 2184
[11]	Sutton A K, Bellini M, Cressler J D, Pellish J A, Reed R A, Marshall P W, Niu G F, Vizkelethy G, Turowski M, Raman A 2007 IEEE Trans. Nucl. Sci. 54 2044
[12]	Marshall P W, Carts M A, Campbell A, McMorrow D, Buchner S, Stewart Ryan, Randall B, Gilbert Barry, Reed R A IEEE Trans. Nucl. Sci. 47 2669
[13]	Niu G F, Yang H, Varadharajaperumal M, Shi Y, Cressler J D, Krithivasan R, Marshall P W, Reed R A 2005 IEEE Trans. Nucl. Sci. 52 2153
[14]	Varadharajaperumal M, Niu G F, Wei X Y, Zhang T, Cressler J D, Reed R A, Marshall P W 2007 IEEE Trans. Nucl. Sci. 54 2330
[15]	Varadharajaperumal M 2010 Ph.D. Dissertation (Alabama:Auburn University)
[16]	Sutton A K, Bellini M, Cressler J D, Pellish J A, Reed R A, Marshall P W, Niu G f, Vizkelethy G, Turowski M, Raman A 2007 IEEE Trans. Nucl. Sci. 54 2044
[17]	Phillips S D, Moen K A, Najafizadeh L, Diestelhorst R M, Sutton A K, Cressler J D, Vizkelethy G, Dodd P E, Marshall P W 2010 IEEE Trans. Nucl. Sci. 57 3400
[18]	Zhang T 2009 MS Dissertation (Alabama:Auburn University)
[19]	Phillips S D 2012 Ph.D. Dissertation (Georgia:Georgia Institute of Technology)
[20]	Zhang J X, Guo H X, Guo Q, Wen L, Cui J W, Xi S B, Wang X, Deng W 2013 Acta Phys. Sin. 62 048501 (in Chinese) [张晋新, 郭红霞, 郭旗, 文林, 崔江维, 席善斌, 王信, 邓伟 2013 物理学报 62 048501]
[21]	Lai F, Hu G Y 2013 Microelectronics 43 0094 (in Chinese) [赖凡, 胡刚毅 2013 微电子学 43 0094]
[22]	Liu Z, Chen S M, Liang B, Liu B W, Zhao Z Y 2010 Acta Phys. Sin. 59 064906 (in Chinese) [刘征, 陈书明, 梁斌, 刘必慰, 赵振宇 2010 物理学报 59 064906]
[23]	Sun Y B, Fu J, Xu J, Wang Y D, Zhou W, Zhang W, Cui J, Li G Q, Liu Z H 2013 Acta Phys. Sin. 62 196104 (in Chinese) [孙亚宾, 付军, 许军, 王玉东, 周卫, 张伟, 崔杰, 李高庆, 刘志弘 2013 物理学报 62 196104]

[1]	Li Pei, Dong Zhi-Yong, Guo Hong-Xia, Zhang Feng-Qi, Guo Ya-Xin, Peng Zhi-Gang, He Chao-Hui. Investigation of laser-induced single event effect on SiGe BiCMOS low noise amplifiers. Acta Physica Sinica, 2024, 73(4): 044301. doi: 10.7498/aps.73.20231451
[2]	Ju An-An, Guo Hong-Xia, Zhang Feng-Qi, Liu Ye, Zhong Xiang-Li, Ouyang Xiao-Ping, Ding Li-Li, Lu Chao, Zhang Hong, Feng Ya-Hui. Simulation research on single event effect of N-well resistor. Acta Physica Sinica, 2023, 72(2): 026102. doi: 10.7498/aps.72.20220125
[3]	Zhou Shu-Xing, Fang Ren-Feng, Wei Yan-Feng, Chen Chuan-Liang, Cao Wen-Yu, Zhang Xin, Ai Li-Kun, Li Yu-Dong, Guo Qi. Structure parameters design of InP based high electron mobility transistor epitaxial materials to improve radiation-resistance ability. Acta Physica Sinica, 2022, 71(3): 037202. doi: 10.7498/aps.71.20211265
[4]	Fu Jing, Cai Yu-Long, Li Yu-Dong, Feng Jie, Wen Lin, Zhou Dong, Guo Qi. Single event transient effect of frontside and backside illumination image sensors under proton irradiation. Acta Physica Sinica, 2022, 71(5): 054206. doi: 10.7498/aps.71.20211838
[5]	Shen Rui-Xiang, Zhang Hong, Song Hong-Jia, Hou Peng-Fei, Li Bo, Liao Min, Guo Hong-Xia, Wang Jin-Bin, Zhong Xiang-Li. Numerical simulation of single-event effects in fully-depleted silicon-on-insulator HfO₂-based ferroelectric field-effect transistor memory cell. Acta Physica Sinica, 2022, 71(6): 068501. doi: 10.7498/aps.71.20211655
[6]	Zhang Jin-Xin, Wang Xin, Guo Hong-Xia, Feng Juan, Lü Ling, Li Pei, Yan Yun-Yi, Wu Xian-Xiang, Wang Hui. Three-dimensional simulation of total ionizing dose effect on SiGe heterojunction bipolor transistor. Acta Physica Sinica, 2022, 71(5): 058502. doi: 10.7498/aps.71.20211795
[7]	. 3D Simulation Study on the Mechanism of Influence Factor of Total Dose Ionizing Effect on SiGe HBT. Acta Physica Sinica, 2021, (): . doi: 10.7498/aps.70.20211795
[8]	Han Jin-Hua, Qin Ying-Can, Guo Gang, Zhang Yan-Wen. A method of designing binary energy degrader. Acta Physica Sinica, 2020, 69(3): 033401. doi: 10.7498/aps.69.20191514
[9]	Wang Xun, Zhang Feng-Qi, Chen Wei, Guo Xiao-Qiang, Ding Li-Li, Luo Yin-Hong. Application and evaluation of Chinese spallation neutron source in single-event effects testing. Acta Physica Sinica, 2019, 68(5): 052901. doi: 10.7498/aps.68.20181843
[10]	Han Jin-Hua, Guo Gang, Liu Jian-Cheng, Sui Li, Kong Fu-Quan, Xiao Shu-Yan, Qin Ying-Can, Zhang Yan-Wen. Design of 100-MeV proton beam spreading scheme with double-ring double scattering method. Acta Physica Sinica, 2019, 68(5): 054104. doi: 10.7498/aps.68.20181787
[11]	Zhao Wen, Guo Xiao-Qiang, Chen Wei, Qiu Meng-Tong, Luo Yin-Hong, Wang Zhong-Ming, Guo Hong-Xia. Effects of nuclear reactions between protons and metal interconnect overlayers on single event effects of micro/nano scaled static random access memory. Acta Physica Sinica, 2015, 64(17): 178501. doi: 10.7498/aps.64.178501
[12]	Liu Jing, Guo Fei, Gao Yong. Mechanism and characteristic analysis and optimization of SiGeC heterojunction bipolar transistor with super junction. Acta Physica Sinica, 2014, 63(4): 048501. doi: 10.7498/aps.63.048501
[13]	Xiao Yao, Guo Hong-Xia, Zhang Feng-Qi, Zhao Wen, Wang Yan-Ping, Ding Li-Li, Fan Xue, Luo Yin-Hong, Zhang Ke-Ying. Synergistic effects of total ionizing dose on the single event effect sensitivity of static random access memory. Acta Physica Sinica, 2014, 63(1): 018501. doi: 10.7498/aps.63.018501
[14]	Zhang Jin-Xin, He Chao-Hui, Guo Hong-Xia, Tang Du, Xiong Cen, Li Pei, Wang Xin. Three-dimensional simulation study of bias effect on single event effects of SiGe heterojunction bipolar transistor. Acta Physica Sinica, 2014, 63(24): 248503. doi: 10.7498/aps.63.248503
[15]	Sun Ya-Bin, Fu Jun, Xu Jun, Wang Yu-Dong, Zhou Wei, Zhang Wei, Cui Jie, Li Gao-Qing, Liu Zhi-Hong. Study on ionization damage of silicon-germanium heterojunction bipolar transistors at various dose rates. Acta Physica Sinica, 2013, 62(19): 196104. doi: 10.7498/aps.62.196104
[16]	Zhang Jin-Xin, Guo Hong-Xia, Guo Qi, Wen Lin, Cui Jiang-Wei, Xi Shan-Bin, Wang Xin, Deng Wei. 3D simulation of heavy ion induced charge collection of single event effects in SiGe heterojunction bipolar transistor. Acta Physica Sinica, 2013, 62(4): 048501. doi: 10.7498/aps.62.048501
[17]	Liu Bi-Wei, Chen Jian-Jun, Chen Shu-Ming, Chi Ya-Qin. NPN bipolar effect and its influence on charge sharing in a tripe well CMOS technology with n+ deep well. Acta Physica Sinica, 2012, 61(9): 096102. doi: 10.7498/aps.61.096102
[18]	Liu Fan-Yu, Liu Heng-Zhu, Liu Bi-Wei, Liang Bin, Chen Jian-Jun. Effect of doping concentration in p+ deep well on charge sharing in 90nm CMOS technology. Acta Physica Sinica, 2011, 60(4): 046106. doi: 10.7498/aps.60.046106
[19]	Cai Ming-Hui, Han Jian-Wei, Li Xiao-Yin, Li Hong-Wei, Zhang Zhen-Li. A simulation study of the atmospheric neutron environment in near space. Acta Physica Sinica, 2009, 58(9): 6659-6664. doi: 10.7498/aps.58.6659
[20]	He Chao-Hui, Geng Bin, Yang Hai-Liang, Chen Xiao-Hua, Wang Yan-Ping, Li Guo-Zheng. Experimental study on irradiation effects in floating gate ROMs. Acta Physica Sinica, 2003, 52(1): 180-187. doi: 10.7498/aps.52.180

Catalog

Vol. 64, Issue 11 - 2015-06-05

Metrics

Abstract views: 5069
PDF Downloads: 202
Cited By: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

Search

Article

留言板