Experimental investigation on the influence of Mg content on Portevin-Le Chatelier effect in Al-based alloys by using digital image correlation

Yang Su-Li; Fu Shi-Hua; Cai Yu-Long; Zhang Di; Zhang Qing-Chuan

doi:10.7498/aps.66.086201

Abstract

The Protein-Le Chatelier (PLC) effects are investigated by using digital image correlation at a constant applied strain rate of 5.0010-3 s-1 and room temperature in Al-Mg alloys with Mg content values (wt.%) of 2.30, 4.57, 6.10 and 6.91 respectively in this study. Both the yield strength and the ultimate strength increase with increasing Mg content, which is generally called solution strengthening. Type of PLC band changes from A to B with increasing Mg content. In low Mg content (2.30%) alloy, the serration amplitude almost remains 1 MPa, while in each of high Mg content (4.57%, 6.10%, 6.91%) alloys it linearly increases with the strain increasing. The serration amplitude is found to increase with increasing Mg content and gradually reaches a saturated state. With the increase of Mg content, the period of PLC band for continuous propagation gradually reduces and the time when the PLC band location sudden jumps increases in the process of propagation. When the strain is small, the out-of-band deformation of alloy is inhomogeneous obviously. And the deformation inhomogeneity slightly decreases with increasing Mg content. DIC results indicate that the PLC bandwidth does not change with Mg content, while the maximum strain increment in the PLC band increases with increasing both Mg content and strain. Additionally, special periodic damped serrations are observed in the stress-time curve of the low Mg content (2.30%), the corresponding PLC band shows that the periodic changed serrations in the stress-time curve correspond to the transformation of the PLC band orientation. Besides, the PLC band propagates upward continuously both before and after the shift.

Keywords:

Authors and contacts

1.
CAS Key Laboratory of Mechanical Behavior and Design of Materials, University of Science and Technology of China, Hefei 230027, China;
2.
State Key Laboratory for Advanced Metals and Materials, University of Science and Technology Beijing, Beijing 100083, China

Corresponding author: Fu Shi-Hua, fushihua@ustc.edu.cn;zhangqc@ustc.edu.cn ; Zhang Qing-Chuan, fushihua@ustc.edu.cn;zhangqc@ustc.edu.cn

Funds: Project supported by the National Natural Science Foundation of China (Grant Nos. 11332010, 11627803, 11472266, 11428206, 51571013) and the Strategic Priority Research Program of the Chinese Academy of Sciences (Grant No. DB22040502).

References

[1]	Klose F B, Hagemann F, Hhner P, Neuhuser H 2004 Mater. Sci. Eng. A 387389 93
[2]	Jiang H F, Zhang Q C, Chen X D, Chen Z J, Jiang Z Y, Wu X P, Fan J H 2007 Acta Mater. 55 2219
[3]	Zhang Q C, Jiang Z Y, Jiang H F, Chen Z J, Wu X P 2005 Int. J. Plasticity 21 2150
[4]	Min J Y, Lin J P, Sun B 2014 Mech Mater. 68 164
[5]	Min J Y, Hector Jr L G, Zhang L, Sun L, Carsley J E, Lin J P 2016 Mater. Design 95 370
[6]	Cai Y L, Tian C G, Zhang G L, Han G M, Yang S L, Fu S H, Cui C Y, Zhang Q C 2017 J. Alloys Compd. 690 707
[7]	Wang X G, Han G M, Cui C Y, Guan S, Jin T, Sun X F, Hu Z Q 2016 Metall Mater. Trans. A 47 5994
[8]	Tong W, Tao H, Zhang N, Hector Jr L G 2005 Scr. Mater. 53 87
[9]	Jiang Z Y, Zhang Q C, Jiang H F, Chen Z J, Wu X P 2005 Mater. Sci. Eng. A 403 154
[10]	Ranc N, Wagner D 2008 Mater. Sci. Eng. A 474 188
[11]	Pink E, Grinberg A 1981 Mater. Sci. Eng. 51 1
[12]	Xiang G F, Zhang Q C, Liu H W, Wu X P, Ju X Y 2007 Scr. Mater. 56 721
[13]	Picu R C, Zhang D 2004 Acta Mater. 52 161
[14]	Tabata T, Fujtta H, Nakajima Y 1980 Acta Metall. 28 795
[15]	Penning P 1972 Acta Metall. 20 1169
[16]	Cottrell A H 1953 The London, Edinburgh, and Dublin Philos. Mag. J. Sci. 44 829
[17]	Xiong S M, Zhang Q C, Cao P T, Xiao R 2009 Acta Metall. Sin. 45 892 (in Chinese) [熊少敏, 张青川, 曹鹏涛, 肖锐 2009 金属学报 45 892]
[18]	Hu Q, Zhang Q C, Fu S H, Cao P T, Gong M 2011 Theor. Appl. Mech. Lett. 1 011007
[19]	Kang J, Wilkinson D S, Jain M, Embury J D, Beaudoin A J, Kim S, Mishira R, Sachdev A K 2006 Acta Mater. 54 209
[20]	Cao P T Zhang Q C, Xiao R, Xiong S M 2009 Acta Phys. Sin. 58 5591 (in Chinese) [曹鹏涛, 张青川, 肖锐, 熊少敏 2009 物理学报 58 5591]
[21]	Bernard C, Cor J, Laurent H, Chauvelon P, Manach P Y 2013 Exp. Mech. 53 1025
[22]	Fu S H, Cai Y L, Yang S L, Zhang Q C, Wu X P 2016 Chin. Phys. Lett. 33 026201
[23]	Fu S H, Cheng T, Zhang Q C, Hu Q, Cao P T 2012 Acta Mater. 60 6650
[24]	Zhemchuzhnikova D A, Lebyodkin M A, Lebedkina T A, Kaibyshev R O 2015 Mater. Sci. Eng. A 639 37
[25]	Cai Y L, Fu S H, Wang Y H, Tian C G, Gao Y, Cheng T, Zhang Q C 2014 Acta Metall. Sin. 50 1491
[26]	Ma P C, Zhang D, Zhuang L Z, Zhang J S 2015 Int. J. Min. Met. Mater. 22 175
[27]	Ait-Amokhtar H, Fressengeas C, Bouabdallah K 2015 Mater. Sci. Eng. A 631 209
[28]	Ait-Amokhtar H, Fressengeas C, Boudrahem S 2008 Mater. Sci. Eng. A 488 540
[29]	Kang J D, Mishra R K, Wilkinson D S, Hopperstad O S 2012 Philos. Mag. Lett. 92 647
[30]	Cai Y L, Yang S L, Wang Y H, Fu S H, Zhang Q C 2016 Mater. Sci. Eng. A 664 155
[31]	McCormick P G, Ling C P 1995 Acta Metall. Mater. 43 1969
[32]	Pan B 2011 Exp. Mech. 51 1223
[33]	Kubin L P, Estrin Y 1990 Acta Metall. Mater. 38 697

Cited By

[1]	Klose F B, Hagemann F, Hhner P, Neuhuser H 2004 Mater. Sci. Eng. A 387389 93
[2]	Jiang H F, Zhang Q C, Chen X D, Chen Z J, Jiang Z Y, Wu X P, Fan J H 2007 Acta Mater. 55 2219
[3]	Zhang Q C, Jiang Z Y, Jiang H F, Chen Z J, Wu X P 2005 Int. J. Plasticity 21 2150
[4]	Min J Y, Lin J P, Sun B 2014 Mech Mater. 68 164
[5]	Min J Y, Hector Jr L G, Zhang L, Sun L, Carsley J E, Lin J P 2016 Mater. Design 95 370
[6]	Cai Y L, Tian C G, Zhang G L, Han G M, Yang S L, Fu S H, Cui C Y, Zhang Q C 2017 J. Alloys Compd. 690 707
[7]	Wang X G, Han G M, Cui C Y, Guan S, Jin T, Sun X F, Hu Z Q 2016 Metall Mater. Trans. A 47 5994
[8]	Tong W, Tao H, Zhang N, Hector Jr L G 2005 Scr. Mater. 53 87
[9]	Jiang Z Y, Zhang Q C, Jiang H F, Chen Z J, Wu X P 2005 Mater. Sci. Eng. A 403 154
[10]	Ranc N, Wagner D 2008 Mater. Sci. Eng. A 474 188
[11]	Pink E, Grinberg A 1981 Mater. Sci. Eng. 51 1
[12]	Xiang G F, Zhang Q C, Liu H W, Wu X P, Ju X Y 2007 Scr. Mater. 56 721
[13]	Picu R C, Zhang D 2004 Acta Mater. 52 161
[14]	Tabata T, Fujtta H, Nakajima Y 1980 Acta Metall. 28 795
[15]	Penning P 1972 Acta Metall. 20 1169
[16]	Cottrell A H 1953 The London, Edinburgh, and Dublin Philos. Mag. J. Sci. 44 829
[17]	Xiong S M, Zhang Q C, Cao P T, Xiao R 2009 Acta Metall. Sin. 45 892 (in Chinese) [熊少敏, 张青川, 曹鹏涛, 肖锐 2009 金属学报 45 892]
[18]	Hu Q, Zhang Q C, Fu S H, Cao P T, Gong M 2011 Theor. Appl. Mech. Lett. 1 011007
[19]	Kang J, Wilkinson D S, Jain M, Embury J D, Beaudoin A J, Kim S, Mishira R, Sachdev A K 2006 Acta Mater. 54 209
[20]	Cao P T Zhang Q C, Xiao R, Xiong S M 2009 Acta Phys. Sin. 58 5591 (in Chinese) [曹鹏涛, 张青川, 肖锐, 熊少敏 2009 物理学报 58 5591]
[21]	Bernard C, Cor J, Laurent H, Chauvelon P, Manach P Y 2013 Exp. Mech. 53 1025
[22]	Fu S H, Cai Y L, Yang S L, Zhang Q C, Wu X P 2016 Chin. Phys. Lett. 33 026201
[23]	Fu S H, Cheng T, Zhang Q C, Hu Q, Cao P T 2012 Acta Mater. 60 6650
[24]	Zhemchuzhnikova D A, Lebyodkin M A, Lebedkina T A, Kaibyshev R O 2015 Mater. Sci. Eng. A 639 37
[25]	Cai Y L, Fu S H, Wang Y H, Tian C G, Gao Y, Cheng T, Zhang Q C 2014 Acta Metall. Sin. 50 1491
[26]	Ma P C, Zhang D, Zhuang L Z, Zhang J S 2015 Int. J. Min. Met. Mater. 22 175
[27]	Ait-Amokhtar H, Fressengeas C, Bouabdallah K 2015 Mater. Sci. Eng. A 631 209
[28]	Ait-Amokhtar H, Fressengeas C, Boudrahem S 2008 Mater. Sci. Eng. A 488 540
[29]	Kang J D, Mishra R K, Wilkinson D S, Hopperstad O S 2012 Philos. Mag. Lett. 92 647
[30]	Cai Y L, Yang S L, Wang Y H, Fu S H, Zhang Q C 2016 Mater. Sci. Eng. A 664 155
[31]	McCormick P G, Ling C P 1995 Acta Metall. Mater. 43 1969
[32]	Pan B 2011 Exp. Mech. 51 1223
[33]	Kubin L P, Estrin Y 1990 Acta Metall. Mater. 38 697

[1]	Wan Xing-Yuan, Zhang Ji-Ming. A novel image authentication and recovery algorithm based on dither and chaos. Acta Physica Sinica, 2014, 63(21): 210701. doi: 10.7498/aps.63.210701
[2]	Wang Xing-Yuan, Zhang Ji-Ming. A novel image authentication and recovery algorithm based on chaos and Hamming code. Acta Physica Sinica, 2014, 63(2): 020701. doi: 10.7498/aps.63.020701
[3]	He Yan-Sheng, Fu Shi-Hua, Zhang Qing-Chuan. Simulations of the interactions between dislocations and solute atoms in different loading conditions. Acta Physica Sinica, 2014, 63(22): 228102. doi: 10.7498/aps.63.228102
[4]	Gao Yue, Fu Shi-Hua, Cai Yu-Long, Cheng Teng, Zhang Qing-Chuan. Digital shearography investigation on the out-plane deformation of the Portevin-Le Chatelier bands. Acta Physica Sinica, 2014, 63(6): 066201. doi: 10.7498/aps.63.066201
[5]	Hu Qi, Zhang Qing-Chuan, Fu Shi-Hua, Cao Peng-Tao, Gong Ming. Effect of precipitation on Portevin-Le Chateliereffect in Al-Mg alloys. Acta Physica Sinica, 2011, 60(9): 096201. doi: 10.7498/aps.60.096201
[6]	Cao Peng-Tao, Zhang Qing-Chuan, Fu Shi-Hua, Hu Qi, Gao Yun. Thermal analysis of serrated yielding in an Al-Mg alloy. Acta Physica Sinica, 2010, 59(1): 458-465. doi: 10.7498/aps.59.458
[7]	Cao Peng-Tao, Zhang Qing-Chuan, Xiao Rui, Xiong Shao-Min. The Portevin-Le Chatelier effect in Al-Mg alloy investigated by infrared pyrometry. Acta Physica Sinica, 2009, 58(8): 5591-5597. doi: 10.7498/aps.58.5591
[8]	Li Jiang-Cheng, Mei Dong-Cheng. The time-delay effect of a metapopulation. Acta Physica Sinica, 2008, 57(11): 6792-6798. doi: 10.7498/aps.57.6792
[9]	Jiang Hui-Feng, Zhang Qing-Chuan, Chen Xue-Dong, Fan Zhi-Chao, Chen Zhong-Jia, Wu Xiao-Ping. Numerical simulation of the dynamic interactions between dislocation and solute atoms. Acta Physica Sinica, 2007, 56(6): 3388-3392. doi: 10.7498/aps.56.3388
[10]	Wang Kun, Yao Shu-De, Hou Li-Na, Ding Zhi-Bo, Yuan Hong-Tao, Du Xiao-Long, Xue Qi-Kun. Depth-dependent elastic strain in ZnO/Zn0.9Mg0.1O/ZnO heterostructure studied by Rutherford backscattering/channeling. Acta Physica Sinica, 2006, 55(6): 2892-2896. doi: 10.7498/aps.55.2892
[11]	Wang Min, Hu Xiao-Fang, Wu Xiao-Ping. Digital image correlation method for the analysis of 3-D internal displacement field in object. Acta Physica Sinica, 2006, 55(10): 5135-5139. doi: 10.7498/aps.55.5135
[12]	Peng Kai-Ping, Chen Wen-Zhe, Qian Kuang-Wu. Study of an anomalous serrated yielding phenomenon in 3004 aluminum alloy. Acta Physica Sinica, 2006, 55(7): 3569-3575. doi: 10.7498/aps.55.3569
[13]	Jiang Hui-Feng, Zhang Qing-Chuan, Xu Yi-Hao, Wu Xiao-Ping. The effect of solution treatment on the spatial behavior of the Portevin-Le Chatelier effect in Al-Cu alloys. Acta Physica Sinica, 2006, 55(1): 409-412. doi: 10.7498/aps.55.409
[14]	Jiang Hui-Feng, Zhang Qing-Chuan, Chen Zhong-Jia, Wu Xiao-Ping. Numerical simulation of the Portevin-Le Chatelier effect in annealed aluminum alloys. Acta Physica Sinica, 2006, 55(6): 2856-2859. doi: 10.7498/aps.55.2856
[15]	Zhang Xi-Jian, Ma Hong-Lei, Wang Qing-Pu, Ma Jin, Zong Fu-Jian, Xiao Hong-Di, Ji Feng. Structural and optical properties of MgxZn1-xO thin films deposited by radio frequency magnetron sputtering. Acta Physica Sinica, 2005, 54(9): 4309-4312. doi: 10.7498/aps.54.4309
[16]	Shen Jing-Ling, Zhang Cun-Lin, Hu Ying, S. P. Jamison. Chirped pulse cross-correlation for THz wave measurement. Acta Physica Sinica, 2004, 53(7): 2212-2215. doi: 10.7498/aps.53.2212
[17]	Zhao Hui, Du Zhi-Wei, Zhou Tie-Tao, Liu Pei-Ying, Dong Bao-Zhong, Chen Chang-Qi. Small angle x-ray scattering study on microstructure evolution of the aging process of Al-Zn-Mg-Cu-Li alloy. Acta Physica Sinica, 2004, 53(4): 1251-1254. doi: 10.7498/aps.53.1251
[18]	Du Zhi-Wei, Zhou Tie-Tao, Zhao Hui, Feng Lin-Ping, Dong Bao-Zhong, Chen Chang-Qi. Small angle x-ray scattering study of precipitation in Al-Zn-Mg-Cu alloys. Acta Physica Sinica, 2004, 53(10): 3601-3608. doi: 10.7498/aps.53.3601
[19]	TAN QI. INVESTIGATION ON THE INTERACTION OF DISLOCATION WITH POINT DEFECTS BY STRAIN AGEING INTERNAL FRICTION OF ALUMINIUM ALLOYS. Acta Physica Sinica, 1994, 43(10): 1658-1664. doi: 10.7498/aps.43.1658
[20]	. . Acta Physica Sinica, 1965, 21(6): 1316-1320. doi: 10.7498/aps.21.1316

Catalog

Vol. 66, Issue 8 - 2017-04-20

Metrics

Abstract views: 4975
PDF Downloads: 163
Cited By: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

Search

Article

留言板