插入二氧化铈薄膜提高MOD-YBa2Cu3O7-x厚膜超导性能的研究

丁发柱; 古宏伟; 王洪艳; 屈飞; 商红静; 张慧亮; 董泽斌; 张贺; 周微微

doi:10.7498/aps.65.097401

摘要

YBa2Cu3O7-x(YBCO)膜存在厚度效应: 随着厚度增加, YBCO薄膜的临界电流密度下降, 尤其是YBCO薄膜的厚度超过1 m时, 它的临界电流密度急剧下降. 本文在YBCO薄膜之间引入极薄的二氧化铈(CeO2)薄膜, 成功制备出结构为YBCO/YBCO/CeO2/YBCO的超导厚膜. 所制备的厚度为2 m的YBCO膜临界电流密度为1.36 MA/cm2 (77 K, 自场), 其性能比相同厚度的纯YBCO膜有了较大幅度的提升. 研究表明CeO2薄膜起到了传递织构、松弛应力的作用.

关键词:

Abstract

In YBa2Cu3O7-x (YBCO) film there exists thickness effect: the critical current density of YBCO film drops precipitously as the coating thickness increases, especially in the case that the thickness of YBCO film exceeds 1 m. In this paper, we introduce very thin layers of CeO2 into YBCO layers and successfully fabricate the structure of YBCO/YBCO/CeO2/YBCO superconducting thick film. Firstly, YBCO films with two layers are fabricated on a LaAlO3 substrate by a multiple coatings process using a trifluoroacetate metal organic deposition method. Secondly, CeO2 thin films are deposited on YBCO films by RF-sputtering. Finally, we prepare the third YBCO film on CeO2interlayer. No cracks are observed in scanning electron microscopy images of these films; further, the majority of the grains in the films are well-textured and c-axis oriented. The full-width-half-maximum of the out-of-plane texture is measured to be 1.395 for the multilayer YBCO film at a thickness of 2 m Using this multilayer technology, we achieve Jc values of up to 1.36 MA/cm2 (77 K, self-field) in films as thick as 2 m, for an extrapolated critical current of 272 A/cm. We attribute the enhanced performance of the thick YBCO film to the CeO2 interlayer which playsan important role in transmission texture and stress relaxation.

Keywords:

作者及机构信息

1.
中国科学院电工研究所, 北京 100190;

2.
中国科学院应用超导重点实验室, 北京 100190;

3.
青岛科技大学材料科学与工程学院, 青岛 266042

通信作者: 古宏伟, guhw@mail.iee.ac.cn

基金项目: 国家高技术研究发展计划(批准号: 2014AA032702)、国家自然科学基金(批准号: 51577180, 51272250)和北京市自然科学基金面上项目(批准号: 2152035)资助的课题.

Authors and contacts

1.
Institute of Electrical Engineering, Chinese Academy of Sciences, Beijing 100190, China;

2.
Key Laboratory of Applied Superconductivity, Chinese Academy of Sciences, Beijing 100190, China;

3.
College of Materials Science and Engineering, Qingdao University of Science and Technology, Qingdao 266042, China

Corresponding author: Gu Hong-Wei, guhw@mail.iee.ac.cn

Funds: Project supported by the National Higy Technology Research and Development Program of China (Grant No. 2014AA032702), the National Nature Science Foundation of China (Grant Nos. 51577180, 51272250) and the Beijing Natural Science Foundation, China (Grant No. 2152035).

参考文献

[1]	Fukushima T, Nakasaki R, Zhang Y, Brownsey P, Sundaram A, Kasahara M, Kuraseko H, Hazelton D, Sakamoto H 2015 Performance and Reliability of 2G-HTS Wires for High-Field Magnet Applications, 28th International Symposium on Superconductivity Tokyo, Japan, November 16-18, 2015
[2]	Moon S H, Su Nam 2013 Developed New Process Named RCE-DR: The Practical Highest Throughput Process. European Conference on Applied Superconductivity Genova, Italy, September 15-19, 2013
[3]	Iijima Y, Adachi Y, Igarashi M, Kakimoto K, Fujita S, Daibo M, Ohsugi M, Takemoto T, Nakamura N, Kurihara C, Machida K, Hanyu S Kikutake R, Nagata M, Tatano F, Itoh M 2014 Development for Mass Production of Homogeneous RE123 Coated Conductors by Hot-Wall PLD Process on IBAD Template Technique, Applied Superconductivity Conference Charlotte NC, USA, August 10-15, 2014
[4]	Malozemoff A P 2015 Progress in American Superconductor's HTS Wire and Optimization for Fault Current Limiting Systems, 28th International Symposium on Superconductivity Tokyo, Japan, November 16-18, 2015
[5]	Ibi A, Iwai H, Takahashi K, Muroga T, Miyata S, Watanabe T, Yamada Y, Shiohara Y 2005 Physica C: Superconductivity 426-431 910
[6]	Li X, Rupich M W, Kodenkandath T, Huang Y 2007 IEEE Trans. Appl. Supercond. 17 3553
[7]	Teranishi R, Matsuda J, Nakaoka K, Fuji H, Aoki Y, Kitoh Y, Nomoto S, Yamada Y, Yajima A, Izumi T, Shiohara Y 2005 Physica C: Superconductivity 426-431 959
[8]	Matsui H, Tsukada K, Tsuchiya T, Sohma M, Yamaguchi I, Manabe T, Kumagai T 2011 IEEE Trans. Appl. Supercond. 21 2933
[9]	Jia Q X, Foltyn S R, Arendt P N, Smith J F 2002 Appl. Phys. Lett. 80 1601
[10]	Suenaga M, Li Q, Ye Z, Iwakuma M, Toyota K, Funaki F, Foltyn S R, Wang H, Clem J R 2004 J. Appl. Phys. 95 208
[11]	Feldmann D M, Holesinger T G, Maiorov B, Zhou H, Foltyn S R, Coulter J Y, Apodoca I 2010 Supercond. Sci. Technol. 23 115016
[12]	Rupich M W, Li X P, Sathyamurthy S, Thieme C L H, DeMoranville K, Gannon J, Fleshler S 2013 IEEE Trans. Appl. Supercond. 23 6601205
[13]	Takahashi K, Kobayashi H, Yamada Y, Ibi A, Fukushima H, Konishi M, Miyata S, Shiohara Y, Kato T, Hirayama T 2006 Supercond. Sci. Technol. 19 924
[14]	Foltyn S R, Jia Q X, Arendt P N, Kinder L, Fan Y, Smith J F 1999 Appl. Phys. Lett. 75 3692
[15]	Pahlke P, Hering M, Sieger M, Lao M, Eisterer M, Usoskin A, Strmer J, Holzapfel B, Schultz L, Hhne R 2015 IEEE Trans. Appl. Supercond. 25 3
[16]	Ding F Z, Gu H W, Wang H Y, Zhang H L, Zhang T, Qu F, Dong Z B, Zhou W W 2015 Chin. Phys. B 24 057401
[17]	Foltyn S R, Wang H, Civale L, Jia Q X, Arendt P N, Maiorov B, Li Y, Maley M P, MacManus-Driscoll J L 2005 Appl. Phys. Lett. 87 162505
[18]	Feldmann D M, Holesinger T G, Maiorov B, Zhou H, Foltyn S R, Coulter J Y, Apodoca I 2010 Supercond. Sci. Technol. 23 115016
[19]	Sarkara A, Danga V S, Mikheenko P, Awang Kechik M M, Abell J S, Crisan A 2010 Thin Solid Film 519 876
[20]	Teranishi R, Matsuda J, Nakaoka K, Fuji H, Aoki Y, Kitoh Y, Izumi T, Yamada Y, Shiohara Y 2005 IEEE Trans. Appl. Supercond. 15 2663
[21]	Matsui H, Tsukada K, Tsuchiya T, Sohma M, Yamaguchi I, Manabe T, Kumagai T 2011 IEEE Trans. Appl. Supercond. 21 2933
[22]	Zhu Y B, Zhou Y L, Wang S F, Liu Z, Zhang Q, Chen Z H, L H B, Yang G Z 2004 Chin. Phys. B 13 238
[23]	Ding F Z, L X D, Gu H W, Li T, Cao J L 2009 Chin. Phys. B 18 1631
[24]	Ghalsasi S, Zhou Y X, Chen J, L B, Salama K 2008 Supercond. Sci. Technol. 21 045015
[25]	Shu G Q, Li M J, Boubeche M, Liu Z Y, Bai C Y, Cai C B 2014 IEEE Trans. Appl. Supercond. 24 5

施引文献

[1]	Fukushima T, Nakasaki R, Zhang Y, Brownsey P, Sundaram A, Kasahara M, Kuraseko H, Hazelton D, Sakamoto H 2015 Performance and Reliability of 2G-HTS Wires for High-Field Magnet Applications, 28th International Symposium on Superconductivity Tokyo, Japan, November 16-18, 2015
[2]	Moon S H, Su Nam 2013 Developed New Process Named RCE-DR: The Practical Highest Throughput Process. European Conference on Applied Superconductivity Genova, Italy, September 15-19, 2013
[3]	Iijima Y, Adachi Y, Igarashi M, Kakimoto K, Fujita S, Daibo M, Ohsugi M, Takemoto T, Nakamura N, Kurihara C, Machida K, Hanyu S Kikutake R, Nagata M, Tatano F, Itoh M 2014 Development for Mass Production of Homogeneous RE123 Coated Conductors by Hot-Wall PLD Process on IBAD Template Technique, Applied Superconductivity Conference Charlotte NC, USA, August 10-15, 2014
[4]	Malozemoff A P 2015 Progress in American Superconductor's HTS Wire and Optimization for Fault Current Limiting Systems, 28th International Symposium on Superconductivity Tokyo, Japan, November 16-18, 2015
[5]	Ibi A, Iwai H, Takahashi K, Muroga T, Miyata S, Watanabe T, Yamada Y, Shiohara Y 2005 Physica C: Superconductivity 426-431 910
[6]	Li X, Rupich M W, Kodenkandath T, Huang Y 2007 IEEE Trans. Appl. Supercond. 17 3553
[7]	Teranishi R, Matsuda J, Nakaoka K, Fuji H, Aoki Y, Kitoh Y, Nomoto S, Yamada Y, Yajima A, Izumi T, Shiohara Y 2005 Physica C: Superconductivity 426-431 959
[8]	Matsui H, Tsukada K, Tsuchiya T, Sohma M, Yamaguchi I, Manabe T, Kumagai T 2011 IEEE Trans. Appl. Supercond. 21 2933
[9]	Jia Q X, Foltyn S R, Arendt P N, Smith J F 2002 Appl. Phys. Lett. 80 1601
[10]	Suenaga M, Li Q, Ye Z, Iwakuma M, Toyota K, Funaki F, Foltyn S R, Wang H, Clem J R 2004 J. Appl. Phys. 95 208
[11]	Feldmann D M, Holesinger T G, Maiorov B, Zhou H, Foltyn S R, Coulter J Y, Apodoca I 2010 Supercond. Sci. Technol. 23 115016
[12]	Rupich M W, Li X P, Sathyamurthy S, Thieme C L H, DeMoranville K, Gannon J, Fleshler S 2013 IEEE Trans. Appl. Supercond. 23 6601205
[13]	Takahashi K, Kobayashi H, Yamada Y, Ibi A, Fukushima H, Konishi M, Miyata S, Shiohara Y, Kato T, Hirayama T 2006 Supercond. Sci. Technol. 19 924
[14]	Foltyn S R, Jia Q X, Arendt P N, Kinder L, Fan Y, Smith J F 1999 Appl. Phys. Lett. 75 3692
[15]	Pahlke P, Hering M, Sieger M, Lao M, Eisterer M, Usoskin A, Strmer J, Holzapfel B, Schultz L, Hhne R 2015 IEEE Trans. Appl. Supercond. 25 3
[16]	Ding F Z, Gu H W, Wang H Y, Zhang H L, Zhang T, Qu F, Dong Z B, Zhou W W 2015 Chin. Phys. B 24 057401
[17]	Foltyn S R, Wang H, Civale L, Jia Q X, Arendt P N, Maiorov B, Li Y, Maley M P, MacManus-Driscoll J L 2005 Appl. Phys. Lett. 87 162505
[18]	Feldmann D M, Holesinger T G, Maiorov B, Zhou H, Foltyn S R, Coulter J Y, Apodoca I 2010 Supercond. Sci. Technol. 23 115016
[19]	Sarkara A, Danga V S, Mikheenko P, Awang Kechik M M, Abell J S, Crisan A 2010 Thin Solid Film 519 876
[20]	Teranishi R, Matsuda J, Nakaoka K, Fuji H, Aoki Y, Kitoh Y, Izumi T, Yamada Y, Shiohara Y 2005 IEEE Trans. Appl. Supercond. 15 2663
[21]	Matsui H, Tsukada K, Tsuchiya T, Sohma M, Yamaguchi I, Manabe T, Kumagai T 2011 IEEE Trans. Appl. Supercond. 21 2933
[22]	Zhu Y B, Zhou Y L, Wang S F, Liu Z, Zhang Q, Chen Z H, L H B, Yang G Z 2004 Chin. Phys. B 13 238
[23]	Ding F Z, L X D, Gu H W, Li T, Cao J L 2009 Chin. Phys. B 18 1631
[24]	Ghalsasi S, Zhou Y X, Chen J, L B, Salama K 2008 Supercond. Sci. Technol. 21 045015
[25]	Shu G Q, Li M J, Boubeche M, Liu Z Y, Bai C Y, Cai C B 2014 IEEE Trans. Appl. Supercond. 24 5

[1]	彭兰沁, 李小雨, 幸运, 赵涵, 邓炎滔, 于迎辉. 铜氧化层上钒氧酞菁分子的吸附构型及组装结构. 物理学报, 2024, 73(12): 120704. doi: 10.7498/aps.73.20240043
[2]	王三胜, 李方, 吴晗, 张竺立, 蒋雯, 赵鹏. 低能离子对高温超导YBa2Cu3O7-薄膜的表面改性和机理. 物理学报, 2018, 67(3): 036103. doi: 10.7498/aps.67.20170822
[3]	顾艳妮, 吴小山. 氧空穴导致二氧化钒低温相带隙变窄. 物理学报, 2017, 66(16): 163102. doi: 10.7498/aps.66.163102
[4]	张明兰, 杨瑞霞, 李卓昕, 曹兴忠, 王宝义, 王晓晖. GaN厚膜中的质子辐照诱生缺陷研究. 物理学报, 2013, 62(11): 117103. doi: 10.7498/aps.62.117103
[5]	陆乃彦, 元冰, 杨恺. 带电多孔二氧化硅纳米颗粒在硫醇/磷脂混合双层膜上的非特异性吸附. 物理学报, 2013, 62(17): 178701. doi: 10.7498/aps.62.178701
[6]	董丽娟, 杜桂强, 杨成全, 石云龙. 厚金属Ag膜的磁光法拉第旋转效应的增强. 物理学报, 2012, 61(16): 164210. doi: 10.7498/aps.61.164210
[7]	黄维, 陈之战, 陈义, 施尔畏, 张静玉, 刘庆峰, 刘茜. 组合材料方法研究膜厚对Ni/SiC电极接触性质的影响. 物理学报, 2010, 59(5): 3466-3472. doi: 10.7498/aps.59.3466
[8]	张迎晨, 朱海燕, 黄婧南, 邹静, 吴红艳, 邱夷平. 氧等离子体处理对纳米二氧化硅溶胶涂覆高强、高模聚乙烯纤维拉伸性能的影响. 物理学报, 2009, 58(13): 292-S297. doi: 10.7498/aps.58.292
[9]	汪渊, 宋忠孝, 徐可为. 体心立方金属W薄膜晶体取向的膜厚尺寸效应及其表面映射. 物理学报, 2007, 56(12): 7248-7254. doi: 10.7498/aps.56.7248
[10]	夏正月, 韩培高, 韦德远, 陈德媛, 徐骏, 马忠元, 黄信凡, 陈坤基. 发光纳米硅/二氧化硅多层膜的特性与氢气氛退火的影响. 物理学报, 2007, 56(11): 6691-6694. doi: 10.7498/aps.56.6691
[11]	靳惠明, Felix Adriana, Aroyave Majorri. 离子注钇对镍900℃高温氧化行为及氧化膜性能的影响研究. 物理学报, 2006, 55(11): 6157-6162. doi: 10.7498/aps.55.6157
[12]	王淑芳, 朱亚斌, 张芹, 刘震, 周岳亮, 陈正豪, 吕惠宾, 杨国桢. 利用电泳法在金属基底上制备MgB2超导厚膜. 物理学报, 2003, 52(6): 1505-1508. doi: 10.7498/aps.52.1505
[13]	钱林茂, 雒建斌, 温诗铸, 萧旭东. 二氧化硅及其硅烷自组装膜微观摩擦力与粘着力的研究(Ⅱ)粘着力的实验与分析. 物理学报, 2000, 49(11): 2247-2253. doi: 10.7498/aps.49.2247
[14]	钱林茂, 雒建斌, 温诗铸, 萧旭东. 二氧化硅及其硅烷自组装膜微观摩擦力与粘着力的研究(Ⅰ)摩擦力的实验与分析. 物理学报, 2000, 49(11): 2240-2246. doi: 10.7498/aps.49.2240
[15]	娄志东, 徐征, 徐春祥, 于磊, 滕枫, 徐叙. 电致发光加速层二氧化硅的电子高场迁移率. 物理学报, 1998, 47(1): 139-145. doi: 10.7498/aps.47.139
[16]	王智河. Bi-2223银夹板厚膜的载流特性与应变的关系. 物理学报, 1996, 45(3): 518-521. doi: 10.7498/aps.45.518
[17]	贾金锋, 吴凯, 王德峥, 吕斯骅, 赵汝光, 吴思诚. 氧和一氧化碳在有序合金表面Pd{001}c(2×2)-Mn上的共吸附:生成二氧化碳的微观机制. 物理学报, 1995, 44(2): 251-258. doi: 10.7498/aps.44.251
[18]	杜家驹, 姜建义, 王翔, 尹华清. 单相钇钡铜氧高温超导体的超导转变与内耗原位研究. 物理学报, 1988, 37(9): 1556-1559. doi: 10.7498/aps.37.1556
[19]	王立萱. 石榴石外延膜色散关系的确定和膜厚的测量. 物理学报, 1983, 32(4): 520-524. doi: 10.7498/aps.32.520
[20]	陈辰嘉, 杨澄清, 黄亨吉. 磷通过热生长二氧化硅层在硅中的扩散. 物理学报, 1964, 20(7): 662-669. doi: 10.7498/aps.20.662

计量

文章访问数: 5484
PDF下载量: 215
被引次数: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

搜索

留言板