-
Polypropylene (PP) is widely used as capacitor films due to its better dielectric, mechanical, and thermal performance. In order to reduce the cost and size of capacitor, high energy density for PP dielectric is pursued. Since energy density is in quadratic proportion to direct current (dc) breakdown strength for linear dielectric, the enhancement of dc breakdown strength for PP dielectric is a primary choice to improve the energy density. Considering that the incorporation of nano-Al2O3 is an effective method to improve the dc breakdown strength for polymer, it is required to study the dc breakdown strength of PP/Al2O3 nanodielectric. In order to explore the breakdown mechanism, PP/Al2O3 nanodielectrics with different nano-particle contents are prepared by melt blending, and the samples are prepared by hot pressing. Their microstructures are observed by scanning electron microscopic. Isothermal surface potential decay, bulk resistivity, and dc breakdown strength of the samples are also measured. The experimental results show that the energy and density of deep traps, bulk resistivity, and dc breakdown strength first increase and then decrease with the increase in nano-Al2O3 content. The maximum values are obtained at a filer content value of 0.5 wt%, where dc breakdown strength can be increased by about 27%. Based on interface model, the relation between microstructure and trap is investigated. In view of space charge breakdown theory, the mechanism of dc breakdown for PP/Al2O3 nanodielectric is explored by trap parameters. It is indicated that the interface can provide more deep traps in PP/Al2O3 nanodielectric, while the decrease in the energy and density of deep traps can be attributed to the overlap of interfaces in electrical double layer. The increase in the energy and density of deep traps makes more carriers trapped near the injecting contact, thus reducing the effective field for carrier injection due to the internal field generated by the trapped carriers. The reduction of carrier injection can moderate the distortion of field in PP dielectric, consequently, resulting in enhancing the dc breakdown strength.
-
Keywords:
- polypropylene /
- nanodielectric /
- direct current breakdown strength /
- trap
[1] Rabuffi M, Picci G 2002 IEEE Trans. Plas. Sci. 30 1939
[2] Li H, Wang B W, Li Z W, Liu D, Lin F C, Dai L, Zhang Q, Chen Y H 2013 Rev. Sci. Instrum. 84 104707
[3] Dang Z M, Yuan J K, Yao S H, Liao R J 2013 Adv. Mater. 25 6334
[4] Wang Q, Zhu L 2011 J. Polym. Sci. Part B: Polym. Phys. 49 1421
[5] Wang Y F, Cui J, Yuan Q B, Niu Y J, Bai Y, Wang H 2015 Adv. Mater. 27 6658
[6] Kolesov S N 1980 IEEE Trans. Electr. Insul. 15 382
[7] Gao L Y, Tu D M, Zhou S C, Zhang Z L 1990 IEEE Trans. Electr. Insul. 25 535
[8] Yuan X P, Chung T C M 2011 Appl. Phys. Lett. 98 062901
[9] Tian F Q, Yang C, He L J, Han B, Wang Y, Lei Q Q 2011 Trans. China Electrotech. Soc. 26 1 (in Chinese) [田付强, 杨春, 何丽娟, 韩柏, 王毅, 雷清泉 2011 电工技术学报 26 1]
[10] Lewis T J 2005 J. Phys. D: Appl. Phys. 38 202
[11] Tanaka T, Kozako M, Fuse N, Ohki Y 2005 IEEE Trans. Electr. Insul. 12 669
[12] Raetzke S, Kindersberger J 2010 IEEE Trans. Electr. Insul. 17 607
[13] Li S T, Yin G L, Bai S N, Li J Y 2011 IEEE Trans. Electr. Insul. 18 1535
[14] Wang F P, Xia Z F, Zhang X Q, Huang J F, Shen J 2007 Acta Phys. Sin. 56 6061 (in Chinese) [王飞鹏, 夏钟福, 张晓青, 黄金峰, 沈军 2007 物理学报 56 6061]
[15] Chen G J, Rao C P, Xiao H M, Huang H, Zhao Y H 2015 Acta Phys. Sin. 64 237702 (in Chinese) [陈钢进, 饶成平, 肖慧明, 黄华, 赵延海 2015 物理学报 64 237702]
[16] Gao J G, Hu H T, Zheng J, Yu L, Zhang X H 2010 Insul. Mater. 43 47 (in Chinese) [高俊国, 胡海涛, 郑杰, 俞利, 张晓虹 2010 绝缘材料 43 47]
[17] Chi X H, Gao J G, Zheng J, Zhang X H 2014 Acta Phys. Sin. 63 177701 (in Chinese) [迟晓红, 高俊国, 郑杰, 张晓虹 2014 物理学报 63 177701]
[18] Takala M, Ranta H, Nevalainen P, Pakonen P, Pelto J, Karttunen M, Virtanen S, Koivu V, Pettersson M, Sonerud B, Kannus K 2010 IEEE Trans. Dielectr. Electr. Insul. 17 1259
[19] Virtanen S, Ranta H, Ahonen S, Karttunen M, Pelto J, Kannus K, Pettersson M 2014 J. Appl. Polymer Sci. 131 39504
[20] Rytluoto I, Lahti K, Karttunen M, Koponen M, Virtanen S, Pettersson M 2015 IEEE Trans. Dielectr. Electr. Insul. 22 2196
[21] Li S T, Min D M, Wang W W, Chen G 2016 IEEE Trans. Dielectr. Electr. Insul. 23 2777
[22] Kozako M, Yamano S, Kido R, Ohki Y, Kohtoh M, Okabe S, Tanaka T 2005 Proceedings of 2005 International Symposium on Electrical Insulating Materials Kitakyushu, Japan, June 5-9, 2005 p231
[23] Wang W W 2015 Ph. D. Dissertation (Xi'an: Xi'an Jiaotong University) (in Chinese) [王威望 2015 博士学位论文 (西安: 西安交通大学)]
[24] Li J Y, Zhou F S, Min D M, Li S T, Xia R 2015 IEEE Trans. Dielectr. Electr. Insul. 22 1723
[25] Kao K C 2004 Dielectric Phenomena in Solids (San Diego, California: Elsevier) pp327-514
[26] Dissado L A, Fothergill J C 1992 Electrical Degradation and Breakdown in Polymers (London: The Institution of Engineering and Technology) pp217-237
[27] Matsui K, Tanaka Y, Takada T, Fukao T 2005 IEEE Trans. Dielectr. Electr. Insul. 12 406
[28] Ho J, Jow T R 2012 IEEE Trans. Dielectr. Elect. Insul. 19 990
[29] Ikezaki K, Kaneko T, Sakakibara T 1981 Jpn. J. Appl. Phys. 20 609
[30] Li H, Li Z W, Xu Z J, Lin F C, Wang B W, Li H Y, Zhang Q, Wang W J, Huang X 2014 IEEE Trans. Plasm. Sci. 42 3585
[31] Liu C D, Zheng F H, An Z L, Zhang Y W 2013 J. Hubei Univ. (Nat. Sci.) 35 320 (in Chinese) [刘川东, 郑飞虎, 安振连, 张冶文 2013 湖北大学学报 (自然科学版) 35 320]
-
[1] Rabuffi M, Picci G 2002 IEEE Trans. Plas. Sci. 30 1939
[2] Li H, Wang B W, Li Z W, Liu D, Lin F C, Dai L, Zhang Q, Chen Y H 2013 Rev. Sci. Instrum. 84 104707
[3] Dang Z M, Yuan J K, Yao S H, Liao R J 2013 Adv. Mater. 25 6334
[4] Wang Q, Zhu L 2011 J. Polym. Sci. Part B: Polym. Phys. 49 1421
[5] Wang Y F, Cui J, Yuan Q B, Niu Y J, Bai Y, Wang H 2015 Adv. Mater. 27 6658
[6] Kolesov S N 1980 IEEE Trans. Electr. Insul. 15 382
[7] Gao L Y, Tu D M, Zhou S C, Zhang Z L 1990 IEEE Trans. Electr. Insul. 25 535
[8] Yuan X P, Chung T C M 2011 Appl. Phys. Lett. 98 062901
[9] Tian F Q, Yang C, He L J, Han B, Wang Y, Lei Q Q 2011 Trans. China Electrotech. Soc. 26 1 (in Chinese) [田付强, 杨春, 何丽娟, 韩柏, 王毅, 雷清泉 2011 电工技术学报 26 1]
[10] Lewis T J 2005 J. Phys. D: Appl. Phys. 38 202
[11] Tanaka T, Kozako M, Fuse N, Ohki Y 2005 IEEE Trans. Electr. Insul. 12 669
[12] Raetzke S, Kindersberger J 2010 IEEE Trans. Electr. Insul. 17 607
[13] Li S T, Yin G L, Bai S N, Li J Y 2011 IEEE Trans. Electr. Insul. 18 1535
[14] Wang F P, Xia Z F, Zhang X Q, Huang J F, Shen J 2007 Acta Phys. Sin. 56 6061 (in Chinese) [王飞鹏, 夏钟福, 张晓青, 黄金峰, 沈军 2007 物理学报 56 6061]
[15] Chen G J, Rao C P, Xiao H M, Huang H, Zhao Y H 2015 Acta Phys. Sin. 64 237702 (in Chinese) [陈钢进, 饶成平, 肖慧明, 黄华, 赵延海 2015 物理学报 64 237702]
[16] Gao J G, Hu H T, Zheng J, Yu L, Zhang X H 2010 Insul. Mater. 43 47 (in Chinese) [高俊国, 胡海涛, 郑杰, 俞利, 张晓虹 2010 绝缘材料 43 47]
[17] Chi X H, Gao J G, Zheng J, Zhang X H 2014 Acta Phys. Sin. 63 177701 (in Chinese) [迟晓红, 高俊国, 郑杰, 张晓虹 2014 物理学报 63 177701]
[18] Takala M, Ranta H, Nevalainen P, Pakonen P, Pelto J, Karttunen M, Virtanen S, Koivu V, Pettersson M, Sonerud B, Kannus K 2010 IEEE Trans. Dielectr. Electr. Insul. 17 1259
[19] Virtanen S, Ranta H, Ahonen S, Karttunen M, Pelto J, Kannus K, Pettersson M 2014 J. Appl. Polymer Sci. 131 39504
[20] Rytluoto I, Lahti K, Karttunen M, Koponen M, Virtanen S, Pettersson M 2015 IEEE Trans. Dielectr. Electr. Insul. 22 2196
[21] Li S T, Min D M, Wang W W, Chen G 2016 IEEE Trans. Dielectr. Electr. Insul. 23 2777
[22] Kozako M, Yamano S, Kido R, Ohki Y, Kohtoh M, Okabe S, Tanaka T 2005 Proceedings of 2005 International Symposium on Electrical Insulating Materials Kitakyushu, Japan, June 5-9, 2005 p231
[23] Wang W W 2015 Ph. D. Dissertation (Xi'an: Xi'an Jiaotong University) (in Chinese) [王威望 2015 博士学位论文 (西安: 西安交通大学)]
[24] Li J Y, Zhou F S, Min D M, Li S T, Xia R 2015 IEEE Trans. Dielectr. Electr. Insul. 22 1723
[25] Kao K C 2004 Dielectric Phenomena in Solids (San Diego, California: Elsevier) pp327-514
[26] Dissado L A, Fothergill J C 1992 Electrical Degradation and Breakdown in Polymers (London: The Institution of Engineering and Technology) pp217-237
[27] Matsui K, Tanaka Y, Takada T, Fukao T 2005 IEEE Trans. Dielectr. Electr. Insul. 12 406
[28] Ho J, Jow T R 2012 IEEE Trans. Dielectr. Elect. Insul. 19 990
[29] Ikezaki K, Kaneko T, Sakakibara T 1981 Jpn. J. Appl. Phys. 20 609
[30] Li H, Li Z W, Xu Z J, Lin F C, Wang B W, Li H Y, Zhang Q, Wang W J, Huang X 2014 IEEE Trans. Plasm. Sci. 42 3585
[31] Liu C D, Zheng F H, An Z L, Zhang Y W 2013 J. Hubei Univ. (Nat. Sci.) 35 320 (in Chinese) [刘川东, 郑飞虎, 安振连, 张冶文 2013 湖北大学学报 (自然科学版) 35 320]
Catalog
Metrics
- Abstract views: 8077
- PDF Downloads: 580
- Cited By: 0