-
Atomic force microscope was used to study the adhesion of mechanical exfoliated graphene under two different atmosphere conditions, air and nitrogen. It was found that the adhesion under nitrogen was smaller. The adhesion of graphene edge was larger than that of the inner region. The relationship between the adhesion of folded graphene and the number of layers along with its frictional properties were investigated under nitrogen atmosphere. The results showed that the adhesion was independent of the number of folded graphene layers. The frictional properties of each area of the folded graphene were far beyond the SiO2 substrate. The friction coefficients of the single layer, the fold on single layer, the double layers and the fold on double layers regions were successively decreased, which were 0.049, 0.031, 0.023 and 0.021 respectively. The friction forces were successively decreased as well. The frictional property of the folded graphene was weaker than the unfolded graphene of same number of layers due to the weaker bonding force between the layers. When measuring the adhesion with a sharp tip or a ball tip, the measurement history of adhesion had little influence on subsequent adhesion. Studies on freshly folded graphene in the air showed that the friction force of the folded region was significantly higher than that of the unfolded region.
-
Keywords:
- atomic force microscope /
- folded graphene /
- adhesion /
- nanotribology
[1] Novoselov K S, Geim A K, Morozov S V, Jiang D, Zhang Y, Dubonos S V, Grigorieva I V, Firsov A A 2004 Science 306 666
Google Scholar
[2] Zang X, Zhou Q, Chang J, Liu Y, Lin L 2015 Microelectron. Eng. 132 192
Google Scholar
[3] Banhart F, Kotakoski J, Krasheninnikov A V 2011 ACS Nano 5 26
Google Scholar
[4] Deng S K, Berry V 2016 Mater. Today 19 197
Google Scholar
[5] Vasic B, Zurutuza A, Gajic R 2016 Carbon 102 304
Google Scholar
[6] 覃业宏, 唐超, 张春小, 孟利军, 钟建新 2015 物理学报 64 016804
Google Scholar
Qin Y H, Tang C, Zhang C X, Meng L J, Zhong J X 2015 Acta Phys. Sin. 64 016804
Google Scholar
[7] Yi H, Zhang X, Zhao Y, Liu Y, Song S 2017 J. Colloid Interface. Sci. 499 62
Google Scholar
[8] Gajurel P, Kim M, Wang Q, Dai W T, Liu H T, Cen C 2017 Adv. Funct. Mater. 27 8
[9] Zheng F, Duan F L 2019 Tribol. Int. 134 87
Google Scholar
[10] Kavalur A, Kim W K 2017 Comput. Mater. Sci. 137 346
Google Scholar
[11] Tripathi M, Awaja F, Bizao R A, Signetti S, Iacob E, Paolicelli G, Valeri S, Dalton A, Pugno N M 2018 ACS Appl. Mater. Interfaces 10 44614
Google Scholar
[12] Long F, Yasaei P, Yao W T, Salehi-Khojin A, Shahbazian-Yassar R 2017 ACS Appl. Mater. Interfaces 9 20922
Google Scholar
[13] Hutter J L, Bechhoefer J 1993 Rev. Sci. Instrum. 64 1868
Google Scholar
[14] Varenberg M, Etsion I, Halperin G 2003 Rev. Sci. Instrum. 74 3362
Google Scholar
[15] Butt H J, Cappella B, Kappl M 2005 Surf. Sci. Rep. 59 1
Google Scholar
[16] Farshchi-Tabrizi M, Kappl M, Cheng Y, Gutmann J, Butt H J 2006 Langmuir 22 2171
Google Scholar
[17] Munz M, Giusca C E, Myers-Ward R L, Gaskill D K, Kazakova O 2015 ACS Nano 9 8401
Google Scholar
[18] Lee C, Li Q Y, Kalb W, Liu X Z, Berger H, Carpick R W, Hone J 2010 Science 328 76
Google Scholar
[19] Gong P, Li Q Y, Liu X Z, Carpick R W, Egberts P 2017 Tribol. Lett. 65 61
Google Scholar
[20] Smolyanitsky A, Killgore J P, Tewary V K 2012 Phys. Rev. B 85 035412
Google Scholar
[21] Li S Z, Li Q Y, Carpick R W, Gumbsch P, Liu X Z, Ding X D, Sun J, Li J 2016 Nature 539 541
Google Scholar
[22] Schniepp H C, Kudin K N, Li J L, Prud'homme R K, Car R, Saville D A, Aksay I A 2008 ACS Nano 2 2577
Google Scholar
[23] Zeng X Z, Peng Y T, Yu M C, Lang H J, Cao X A, Zou K 2018 ACS Appl. Mater. Interfaces 10 8214
Google Scholar
[24] Li J J, Gao T Y, Luo J B 2018 Adv. Sci. 5 1700616
Google Scholar
[25] Liu S W, Wang H P, Xu Q, Ma T B, Yu G, Zhang C, Geng D, Yu Z, Zhang S, Wang W, Hu Y Z, Wang H, Luo J 2017 Nat. Commun. 8 14029
Google Scholar
[26] Cho D H, Wang L, Kim J S, Lee G H, Kim E S, Lee S, Lee S Y, Hone J, Lee C 2013 Nanoscale 5 3063
Google Scholar
-
图 1 不同环境和区域的粘附力
Figure 1. Adhesive forces of different areas under different environments.
图 2 折叠石墨烯的表征 (a)光镜图; (b)形貌图; (c)红线处高度图; (d)各区域粗糙度图.
Figure 2. The characterization of folded graphene: (a) Optical microscope image; (b) morphology image; (c) height image at red line; (d) roughness of each area.
图 3 折叠石墨烯粘附力和摩擦性能 (a)各区域摩擦前后粘附力值图; (b)各区域摩擦力对载荷关系图
Figure 3. The adhesive and tribological properties of folded graphene: (a) Adhesive forces before and after rubbing of each area; (b) friction force versus load curve of each area.
图 4 针尖测量历史对粘附力影响 (a)各区域粘附力变化图; (b)二氧化硅小球针尖SEM图; (c)二氧化硅小球针尖摩擦前粘附力变化图; (d)二氧化硅小球针尖摩擦前后粘附力
Figure 4. The influence of tip measurement history on adhesion: (a) Change in adhesion of each region; (b) SEM image of silica ball tip; (c) change in adhesion of silica ball tip before rubbing; (d) adhesion before and after silica ball tip rubbing.
图 5 新鲜折叠石墨烯的产生与摩擦性能 (a)−(c)折叠前的形貌图、摩擦力全图、红线处的高度图和摩擦信号图; (d)−(f)折叠后的形貌图、摩擦力全图、红线处的高度图和摩擦信号图
Figure 5. Production and tribological properties of freshly folded graphene: Morphology image, full view of friction, height and friction signal images at red line before folding (a)−(c) and after folding (d)−(f).
-
[1] Novoselov K S, Geim A K, Morozov S V, Jiang D, Zhang Y, Dubonos S V, Grigorieva I V, Firsov A A 2004 Science 306 666
Google Scholar
[2] Zang X, Zhou Q, Chang J, Liu Y, Lin L 2015 Microelectron. Eng. 132 192
Google Scholar
[3] Banhart F, Kotakoski J, Krasheninnikov A V 2011 ACS Nano 5 26
Google Scholar
[4] Deng S K, Berry V 2016 Mater. Today 19 197
Google Scholar
[5] Vasic B, Zurutuza A, Gajic R 2016 Carbon 102 304
Google Scholar
[6] 覃业宏, 唐超, 张春小, 孟利军, 钟建新 2015 物理学报 64 016804
Google Scholar
Qin Y H, Tang C, Zhang C X, Meng L J, Zhong J X 2015 Acta Phys. Sin. 64 016804
Google Scholar
[7] Yi H, Zhang X, Zhao Y, Liu Y, Song S 2017 J. Colloid Interface. Sci. 499 62
Google Scholar
[8] Gajurel P, Kim M, Wang Q, Dai W T, Liu H T, Cen C 2017 Adv. Funct. Mater. 27 8
[9] Zheng F, Duan F L 2019 Tribol. Int. 134 87
Google Scholar
[10] Kavalur A, Kim W K 2017 Comput. Mater. Sci. 137 346
Google Scholar
[11] Tripathi M, Awaja F, Bizao R A, Signetti S, Iacob E, Paolicelli G, Valeri S, Dalton A, Pugno N M 2018 ACS Appl. Mater. Interfaces 10 44614
Google Scholar
[12] Long F, Yasaei P, Yao W T, Salehi-Khojin A, Shahbazian-Yassar R 2017 ACS Appl. Mater. Interfaces 9 20922
Google Scholar
[13] Hutter J L, Bechhoefer J 1993 Rev. Sci. Instrum. 64 1868
Google Scholar
[14] Varenberg M, Etsion I, Halperin G 2003 Rev. Sci. Instrum. 74 3362
Google Scholar
[15] Butt H J, Cappella B, Kappl M 2005 Surf. Sci. Rep. 59 1
Google Scholar
[16] Farshchi-Tabrizi M, Kappl M, Cheng Y, Gutmann J, Butt H J 2006 Langmuir 22 2171
Google Scholar
[17] Munz M, Giusca C E, Myers-Ward R L, Gaskill D K, Kazakova O 2015 ACS Nano 9 8401
Google Scholar
[18] Lee C, Li Q Y, Kalb W, Liu X Z, Berger H, Carpick R W, Hone J 2010 Science 328 76
Google Scholar
[19] Gong P, Li Q Y, Liu X Z, Carpick R W, Egberts P 2017 Tribol. Lett. 65 61
Google Scholar
[20] Smolyanitsky A, Killgore J P, Tewary V K 2012 Phys. Rev. B 85 035412
Google Scholar
[21] Li S Z, Li Q Y, Carpick R W, Gumbsch P, Liu X Z, Ding X D, Sun J, Li J 2016 Nature 539 541
Google Scholar
[22] Schniepp H C, Kudin K N, Li J L, Prud'homme R K, Car R, Saville D A, Aksay I A 2008 ACS Nano 2 2577
Google Scholar
[23] Zeng X Z, Peng Y T, Yu M C, Lang H J, Cao X A, Zou K 2018 ACS Appl. Mater. Interfaces 10 8214
Google Scholar
[24] Li J J, Gao T Y, Luo J B 2018 Adv. Sci. 5 1700616
Google Scholar
[25] Liu S W, Wang H P, Xu Q, Ma T B, Yu G, Zhang C, Geng D, Yu Z, Zhang S, Wang W, Hu Y Z, Wang H, Luo J 2017 Nat. Commun. 8 14029
Google Scholar
[26] Cho D H, Wang L, Kim J S, Lee G H, Kim E S, Lee S, Lee S Y, Hone J, Lee C 2013 Nanoscale 5 3063
Google Scholar
DownLoad:
Catalog
Metrics
- Abstract views: 6429
- PDF Downloads: 106
- Cited By: 0
