-
Torsion information is important for rotating systems, industrial monitoring, transportation engineering and medical equipment. Optical fiber torsion sensors have significant advantages, such as immune to electromagnetic interference, small size and light weight. Sagnac loop interferometer (SI) torsion sensors have attracted much attention for their compact structure, high sensitivity, excellent stability and low cost. However, their nonlinear response restricts the measurement range, while the wide full width at half maximum and low signal-to-noise ratio (SNR) reduce the resolution of torsion sensors. To solve these problems, we propose a fiber ring laser torsion sensor (FRLTS) based on homemade polarization-maintaining photonic crystal fiber (PM-PCF). The torsion sensor introduces a PM-PCF based SI into the erbium-doped fiber ring cavity as a filter and torsion sensor device. Firstly, the interference spectrum of SI is derived by the transmission matrix method and simulated, and then the sensing principle of the sensor is obtained. Subsequently, the experimental system is set up to study the lasing output characteristics and torsion response of the FRLTS. By taking advantage of the narrow linewidth and high SNR of fiber ring lasers, a high-resolution fiber torsion sensor is successfully achieved. The experimental results demonstrate that the maximum linear torsion measurement range of the sensor can be extended to 480° (-260° to 220°), the maximum torsion sensitivity is 0.032 nm/°, and the resolution is as high as 0.681°. Furthermore, in the temperature range from 20℃ to 95℃, the temperature-induced wavelength variation is only 4×10-3 nm/℃, corresponding to a torsion angle measurement error of 0.16 °/℃. Compared to existing reports, its temperature stability is improved by 37.5 times, while the temperatureinduced error in angle measurements is reduced by 9.375 times. The proposed FRLTS not only successfully achieves high-resolution and widerange torsion sensing, but also effectively suppresses cross-sensitivity caused by temperature. Therefore, the torsion sensor has significant application potential in scenes such as aerospace and robotics where precise measurement of minute torsion angle is required in special environments.
-
[1] Cui J X, Cheng X, Gunawardena D S, Leong C Y, Dash J N, Lau A P T, Tam H Y 2024 Opt. Laser Technol. 174 110548
[2] Cao J Q, Wang B, Huang B S, Lou S Q, Sheng Z F, Chu P K 2024 J. Lightwave Technol. 42 5743
[3] López-Higuera J M, Cobo L R, Incera A Q, Cobo A 2011 J. Lightwave Technol. 29 587
[4] Yin G L, Xu Z, Ma J M, Zhu T 2022 J. Lightwave Technol. 41 1851
[5] Zheng Y C, Li J J, Liu Y, Li Y, Qu S L 2023 J. Lightwave Technol. 42 2513
[6] Duan J A, Xie Z, Wang C, Zhou J Y, Li H T, Luo Z, Chu D K, Sun X Y 2016 Opt. Laser Technol. 83 94
[7] Lin C Y, Wang L A, Chern G W 2001 J. Lightwave Technol. 19 1159
[8] Zhu T, Rao Y J, Mo Q J 2006 Acta Phys. Sin. 55 249 (in Chinese) [朱涛,饶云江,莫秋菊 2006 物理学报 55 249]
[9] Ghasemi P, Yam S S H 2022 J. Lightwave Technol. 40 1224
[10] Yin G L, Fu Q J, Yang P X, Zhu T 2022 Opt. Laser Technol. 156 108461
[11] Cao J Q, Lou S Q, Huang B S, Gu S, Jia H Q, Sheng X Z, Wang X 2023 Opt. Fiber Technol. 80 103431
[12] Zhang R W, Liu X J, Shang Q H, Yang J R 2023 J. Lightwave Technol. 42 921
[13] Shi L L, Zhu T, Fan Y E, Chiang K S, Rao Y J 2011 Opt. Commun. 284 5299
[14] Lou S Q, Lu W L, Wang X 2013 Acta Phys. Sin. 62 090701 (in Chinese) [娄淑琴,鹿文亮,王鑫 2013 物理学报62 090701]
[15] Chen W G, Lou S Q, Wang L W, Zou H, Lu W L, Jian S S 2011 IEEE Photonics Technol. Lett. 23 1639
[16] Huang B, Shu X W 2018 Opt. Express 26 4563
[17] Htein L, Gunawardena D S, Liu Z Y, Tam H Y 2020 Opt. Express 28 33841
[18] Lin W H, Shao L Y, Vai M I, Shum P P, Liu S Q, Liu Y B, Zhao F, Xiao D R, Liu Y H, Tan Y D, Wang W Z 2021 J. Lightwave Technol. 39 3350
[19] Liu X J, Wang F J, Yang J R, Zhang X D, Du X L 2019 SENSORS-BASEL 19 3613
[20] Cao J Q, Guo Y Y, Gao W, Wang X, Lou S Q, Sheng Z F 2024 IEEE Sens. J. 25 4647
[21] Ma X K, Lou S Q, Cao J Q, Huang B S 2025 INFRARED PHYS TECHN 147 105776
[22] Guo Y Y, Du M Z, Gao W, Cao J Q, Sheng X Z, Lou S Q, Lian Z G 2025 Chin. J. Lasers 52 1306003 (in Chinese) [郭玉颖,杜梦珠,高炜,曹佳琦,盛新志,娄淑琴,廉正刚 2025 中国激光 52 1306003]
[23] Bo W, Liu B, Liu J, He X D, Yuan J H, Wu Q 2022 IEEE Sens. J. 22 7779
[24] Zu P, Chan C C, Jin Y X, Gong T X, Zhang Y F, Chen L H, Dong X Y 2011 IEEE Photonics Technol. Lett. 23 920
[25] Chen W G, Lou Q S, Wang L W, Zou H, Lu W L, Jian S S 2011 IEEE Photonics Technol. Lett. 23 1639
[26] Chiavaioli F, Gouveia C A J, Jorge P A S, Baldini F 2017 Biosensors 7 23
[27] Shi L L, Zhu T, Fan Y E, Chiang K S, Rao Y J 2011 Opt. Commun. 284 5299
Metrics
- Abstract views: 248
- PDF Downloads: 0
- Cited By: 0