-
随着近年来凝聚态物理、空间观测与量子技术的不断发展, 极低温制冷需求也日益增多. 绝热去磁制冷具有不依赖重力、结构紧凑、成本较低等特点, 可同时满足空间和地面应用. 本文设计并研制了一台50 mK多级绝热去磁制冷机. 该机为三级串联架构, 由一台GM型脉管制冷机提供4 K预冷; 采用钆镓石榴石和十二水合硫酸铬钾作为制冷工质; 研制的主动式/被动式气隙热开关, 用以控制级间传热; 针对磁屏蔽、恒温控制等构建了多个数值模型进行辅助设计. 目前该机获得的最低制冷温度为38 mK, 100 mK时制冷量约71 mJ, 温度波动10.6 μK. 本研究为后续开展50 mK连续绝热去磁制冷奠定了重要基础.
With the development of condensed matter physics, space observation, and quantum technology in recent years, the demand for ultra-low temperature refrigeration has increased. The adiabatic demagnetization refrigerator (ADR) has the advantages of being unaffected by gravity, compact structure, and relatively low cost, which can meet the needs of space and ground applications. In this paper, a 50 mK multi-stage ADR is designed and developed which comprises a GM-type pulse tube cryocooler for precooling and three ADR stages connected in series. For easy installation and maintenance, the three ADR stages are placed on a separate cold plate which is connected to the 4 K cold plate via copper columns. The Dy3Ga5O12 (GGG) is employed as the refrigerant in the first stage, whereas CrK(SO4)2 · 12H2O (CPA) is utilized for the second stage and third stage. To control heat transfer between stages and the 4 K heat sink, active gas-gap heat switch and passive gas-gap heat switch are developed, with the latter having a switching ratio over 1000. The 4 T, 2 T and 1 T superconducting magnets are utilized in the 1st, 2nd and 3rd stage, respectively, and a numerical model is used to optimize the design of magnetic shielding. In addition, an ADR simulation model with a proportional-integral-derivative (PID) controller is constructed to assist in tuning the controller parameters in the experiment. The lowest temperature achieved in the experiment is 38 mK, with a temperature fluctuation of 10.6 μK. The durations of different cooling power (1, 2 and 3 μW) at 100 mK are also measured. It is calculated that the no-load maintenance time is about 4.3 h, the leakage heat power is about 4.5 μW, and the total cooling capacity is about 71 mJ. This refrigerator is the first Chinese multi-stage ADR that can reach a temperature under 50 mK, which lays an important foundation for subsequent research on continuous adiabatic demagnetization refrigeration. [1] Serlemitsos A T, Sansebastian M, Kunes E 1992 Cryogenics 32 117
Google Scholar
[2] Serlemitsos A T, Sansebastian M, Kunes E S 1998 Advance in Cryogenic Engineering (Boston, MA: Springer) pp957–963
[3] Shirron P, Wegel D, Dipirro M 2006 Proceedings of 24th International Conference on Low Temperature Physics Orlando, Florida (USA), August 10–17, 2006 p1573
[4] Shirron P J, Kimball M O, Dipirro M J, Bials T G 2015 Phys. Procedia 67 250
Google Scholar
[5] Bartlett J, Hardy G, Hepburn I D, Blatt C B, Coker P, Crofts E, Winter B, Milward S, Aller R S, Brownhill M, Reed J, Linder M, Rando N 2010 Cryogenics 50 582
Google Scholar
[6] Bartlett J, Hardy G, Hepburn I, Milward S, Coker P, Theobald C 2012 Proceedings of SPIE Amsterdam Netherlands, September 24, 2012 p84521O
[7] Brasiliano D A P, Duval J M, Luchier N, Eserivan S D, Andre J 2016 International Cryocoolers Conference San Diego, California (USA) June 20–23, 2016 p479
[8] Shinozaki K, Mitsuda K, Yamasaki N Y, Takei Y, Dipirro M, Ezoe Y, Fujimoto R, den Herder J W, Hirabayashi M, Ishisaki Y, Kanao K, Kawaharada M, Kelley R, Kilbourne C, Kitamoto S, McCammon D, Mihara T, Murakami M, Nakagawa T, Ohashi T, Porter F S, Satoh Y, Shirron P, Sugita H, Tamagawa T, Tashiro M, Yoshida S 2008 Prococeedings of SPIE Marseille France, July 15, 2008 p70113R
[9] Shinozaki K, Mitsuda K, Yamasaki N Y, Takei Y, Masui K, Asano K, Ohashi T, Ezoe Y, Ishisaki Y, Fujimoto R, Sato K, Kanao K, Yoshida S 2010 Cryogenics 50 597
Google Scholar
[10] Shirron P J, Canavan E R, Dipirro M J, Tuttle J G, Yeager C J 2000 Advance in Cryogenics Engineering. (Boston, MA: Springer) p1629
[11] ADR Cryostats, Formfactor https://www.formfactor.com/products/quantum- cryo/?_all_filters=adr-cryostats [2023-7-4
[12] Adiabatic Demagnetization Refrigerator, Entropy https://www.entropy- cryogenics.com/products/ [2023-7-4
[13] 万绍宁, 容锡燊 1987 低温物理学报 9 133
Google Scholar
Wan S N, Rong X S 1987 Chin. J. Low Temp. Phys. 9 133
Google Scholar
[14] 冉启泽, 李金万 1990 低温物理学报 12 131
Google Scholar
Ran Q Z, Li J W 1990 Chin. J. Low Temp. Phys. 12 131
Google Scholar
[15] 王昌, 李珂, 沈俊, 戴巍, 王亚男, 罗二仓, 沈保根, 周远 2021 物理学报 70 090702
Google Scholar
Wang C, Li K, Shen J, Dai W, Wang Y N, Luo E C, Shen B G, Zhou Y 2021 Acta Phys. Sin. 70 090702
Google Scholar
[16] 王昌 2022 博士学位论文 (北京: 中国科学院大学)
Wang C 2022 Ph. D. Dissertation (Beijing: University of Chinese Academy of Sciences
[17] 禹芳秋, 沈俊, 戴巍, 李珂, 刘萍, 王昌 2022 中国工程热物理学会工程热力学与能源利用学术年会(2021)中国长沙, 4月9—10日, 2022
Yu F Q, Shen J, Dai W, Li K, Liu P, Wang C 2022 Annual Conference of Engineering Thermodynamics and Energy Utilization of The Chinese Society of Engineering Thermophysics (2021) Changsha, April 9–10, 2022
[18] Model 372 AC Resistance Bridge and Temperature Controller User’s Manual Lake Shore Cryotronics, Inc., 2019
[19] Model 2700 Multimeter/Switch System User’s Manual Keithley Instruments, 2016
[20] 李珂, 王昌, 戴巍, 沈俊 2021 中国稀土学会学术年会, 中国成都, 10月22—24日, 2021 第88页
Li K, Wang C, Dai W, Shen J 2021 Annual Conference of the Chinese Society of Rare Earths Chengdu, October 22–24, 2021 p88
-
图 1 ADR基本结构与工作原理 (a) 结构示意图; (b) ADR制冷循环
Fig. 1. Schematic and principle of ADR: (a) Schematic diagram; (b) refrigeration cycle of ADR.
图 3 磁热模块结构示意图和实物图 (a) GGG磁热模块; (b) CPA磁热模块
Fig. 3. Schematic diagram and photo of salt pills: (a) GGG salt pill; (b) CPA salt pill.
图 5 磁屏蔽的数值仿真与实验测试装置
Fig. 5. Numerical simulation and experimental measurement of magnetic shielding.
-
[1] Serlemitsos A T, Sansebastian M, Kunes E 1992 Cryogenics 32 117
Google Scholar
[2] Serlemitsos A T, Sansebastian M, Kunes E S 1998 Advance in Cryogenic Engineering (Boston, MA: Springer) pp957–963
[3] Shirron P, Wegel D, Dipirro M 2006 Proceedings of 24th International Conference on Low Temperature Physics Orlando, Florida (USA), August 10–17, 2006 p1573
[4] Shirron P J, Kimball M O, Dipirro M J, Bials T G 2015 Phys. Procedia 67 250
Google Scholar
[5] Bartlett J, Hardy G, Hepburn I D, Blatt C B, Coker P, Crofts E, Winter B, Milward S, Aller R S, Brownhill M, Reed J, Linder M, Rando N 2010 Cryogenics 50 582
Google Scholar
[6] Bartlett J, Hardy G, Hepburn I, Milward S, Coker P, Theobald C 2012 Proceedings of SPIE Amsterdam Netherlands, September 24, 2012 p84521O
[7] Brasiliano D A P, Duval J M, Luchier N, Eserivan S D, Andre J 2016 International Cryocoolers Conference San Diego, California (USA) June 20–23, 2016 p479
[8] Shinozaki K, Mitsuda K, Yamasaki N Y, Takei Y, Dipirro M, Ezoe Y, Fujimoto R, den Herder J W, Hirabayashi M, Ishisaki Y, Kanao K, Kawaharada M, Kelley R, Kilbourne C, Kitamoto S, McCammon D, Mihara T, Murakami M, Nakagawa T, Ohashi T, Porter F S, Satoh Y, Shirron P, Sugita H, Tamagawa T, Tashiro M, Yoshida S 2008 Prococeedings of SPIE Marseille France, July 15, 2008 p70113R
[9] Shinozaki K, Mitsuda K, Yamasaki N Y, Takei Y, Masui K, Asano K, Ohashi T, Ezoe Y, Ishisaki Y, Fujimoto R, Sato K, Kanao K, Yoshida S 2010 Cryogenics 50 597
Google Scholar
[10] Shirron P J, Canavan E R, Dipirro M J, Tuttle J G, Yeager C J 2000 Advance in Cryogenics Engineering. (Boston, MA: Springer) p1629
[11] ADR Cryostats, Formfactor https://www.formfactor.com/products/quantum- cryo/?_all_filters=adr-cryostats [2023-7-4
[12] Adiabatic Demagnetization Refrigerator, Entropy https://www.entropy- cryogenics.com/products/ [2023-7-4
[13] 万绍宁, 容锡燊 1987 低温物理学报 9 133
Google Scholar
Wan S N, Rong X S 1987 Chin. J. Low Temp. Phys. 9 133
Google Scholar
[14] 冉启泽, 李金万 1990 低温物理学报 12 131
Google Scholar
Ran Q Z, Li J W 1990 Chin. J. Low Temp. Phys. 12 131
Google Scholar
[15] 王昌, 李珂, 沈俊, 戴巍, 王亚男, 罗二仓, 沈保根, 周远 2021 物理学报 70 090702
Google Scholar
Wang C, Li K, Shen J, Dai W, Wang Y N, Luo E C, Shen B G, Zhou Y 2021 Acta Phys. Sin. 70 090702
Google Scholar
[16] 王昌 2022 博士学位论文 (北京: 中国科学院大学)
Wang C 2022 Ph. D. Dissertation (Beijing: University of Chinese Academy of Sciences
[17] 禹芳秋, 沈俊, 戴巍, 李珂, 刘萍, 王昌 2022 中国工程热物理学会工程热力学与能源利用学术年会(2021)中国长沙, 4月9—10日, 2022
Yu F Q, Shen J, Dai W, Li K, Liu P, Wang C 2022 Annual Conference of Engineering Thermodynamics and Energy Utilization of The Chinese Society of Engineering Thermophysics (2021) Changsha, April 9–10, 2022
[18] Model 372 AC Resistance Bridge and Temperature Controller User’s Manual Lake Shore Cryotronics, Inc., 2019
[19] Model 2700 Multimeter/Switch System User’s Manual Keithley Instruments, 2016
[20] 李珂, 王昌, 戴巍, 沈俊 2021 中国稀土学会学术年会, 中国成都, 10月22—24日, 2021 第88页
Li K, Wang C, Dai W, Shen J 2021 Annual Conference of the Chinese Society of Rare Earths Chengdu, October 22–24, 2021 p88
下载:
计量
- 文章访问数: 4791
- PDF下载量: 158
- 被引次数: 0
