-
InAs/GaSb超晶格是量子级联激光器(quantum cascade lase, QCL)和带间级联激光器 ( interband cascade lasers, ICL ) 结构中重要的组成, 特别是作为 ICL的上下超晶格波导层是由大量的超薄外延层(纳米量级)交替生长而成, 细微的晶格失配便会直接导致材料晶体质量变差, 而且每层的厚度和组分变化会强烈影响材料结构性能. 论文研究验证了 InAs/GaSb超晶格材料生长的最佳温度约在420 ℃. 通过在衬底旋转的情况下生长40周期短周期GaSb/AlSb和InAs/GaSb超晶格, 并采用XRD测量拟合获得了GaSb和AlSb层厚分别为5.448 nm和3.921 nm, 以及InAs和GaSb层厚分别为8.998 nm和13.77 nm, 误差在10%以内, 获得了 InAs/AlSb超晶格的生长最优条件. 在GaSb衬底上生长晶格匹配的40周期的InAs/AlSb超晶格波导层, 充分考虑飘逸As注入对InAs/AlSb超晶格平均晶格常数的影响, 在固定SOAK时间为3 s的条件下, 通过变化As压为1.7×10–6 mbar来调整个超晶格的平均晶格常数, 实现了其与GaSb衬底晶格匹配. 实验结果表明超晶格零阶卫星峰和GaSb衬底峰重合, 具有完美的晶格匹配, 尖锐的次阶卫星峰和重复性良好的周期结构也表明优异的超晶格材料结构质量.The InAs/GaSb superlattices (SPLs) is an important component of quantum cascade laser (QCL) and interband cascade laser (ICL). In particular, the upper and lower SPL waveguide layers of the ICL are alternately grown from a large number of ultra-film epitaxial layers (nm) by molecular beam epitaxy(MBE). Subtle lattice mismatch may directly lead to the deterioration of material crystal quality, and the change of thicknessand the composition of each layer will strongly affect the structural performance of device material. The optimal growth temperature of InAs/GaSb SPLs is about 420 ℃. By growing GaSb/AlSb and InAs/GaSb SPL both with 40 short periods under the substrate rotating, the thickness of GaSb layer and AlSb layer are 5.448 nm and 3.921 nm, and the thickness of InAs layer and GaSb layer are 8.998 nm and 13.77 nm, respectively. The error is within about 10%, and the optimal growth conditions of InAs/AlSb SPLs are obtained. A lattice matched 40-period InAs/AlSb superlattice waveguide layer is grown on GaSb substrate. The influence of drifting As injection on the average lattice constant of InAs/AlSb superlattice is fully considered. Under the condition of fixed SOAK time of 3 s, the As pressure is changed to 1.7 × 10–6 mbar to adjust the average lattice constants of the superlattices and achieve their matching with the GaSb substrate lattice. The experimental results show that the 0 order satellite peak of the SPL coincides with the peak of the GaSb substrate, and has a perfect lattice matching, and that the sharp second order satellite peak and the periodic structure good repeatability also indicate that the superlattice material has the excellent structural quality of the SPLs structure.
-
Keywords:
- molecular beam epitaxy(MBE) /
- lattice matched /
- superlattice /
- attice mismatch
[1] Bennett B R, Magno R, Boos J B, Kruppa W, Ancona M G 2005 Solid-State Electron. 49 1875
Google Scholar
[2] Cerutti L, Boissier G, Grech P, Perona A, Angellier J, Rouillard Y, Kaspi R, Genty F 2006 Electron. Lett. 42 1400
Google Scholar
[3] Delaunay P Y, Nguyen B M, Hoffman D, Hood A, Huang E K W, Razeghi M, Tidrow M Z 2008 Appl. Phys. Lett. 92 111112
Google Scholar
[4] Baranov A N, Teissier R 2015 IEEE J. Sel. Top. Quantum Electron. 21 1200612
[5] Cathabard O, Teissier R, Devenson J, Moreno J, Baranov A N 2010 Appl. Phys. Lett. 96 141110
Google Scholar
[6] Benveniste E, Vasanelli A, Delteil A, Devenson J, Teissier R, Baranov A, Andrews A M, Strasser G, Sagnes I, Sirtori C 2008 Appl. Phys. Lett. 93 131108
Google Scholar
[7] Nguyen V H, Loghmari Z, Philip H, Bahriz M, Baranov A N, Teissier R 2019 Photonics 6 31
Google Scholar
[8] Brandstetter M, Kainz M A, Zederbauer T, Krall M, Schönhuber S, Detz H, Schrenk W, Andrews A M, Strasser G, Unterrainer K 2016 Appl. Phys. Lett. 108 011109
Google Scholar
[9] Vurgaftman I, Bewley W W, Canedy C L, Kim C S, Kim M, Merritt C D, Abell J, Lindle J R, Meyer J R 2011 Nat. Commun. 2 585
Google Scholar
[10] Weih R, Kamp M, Hofling S 2013 Appl. Phys. Lett. 102 231123
Google Scholar
[11] Kroemer H 2004 Physica E 20 196
Google Scholar
[12] Li L H, Zhu J X, Chen L, Davies A G, Linfield E H 2015 Opt. Express 23 2720
Google Scholar
[13] Schmitz J, Wagner J, Fuchs F, Herres N, Koidl P, Ralston J D 1995 J. Cryst. Growth 150 858
Google Scholar
[14] Jackson E M, Boishin G I, Aifer E H, Bennett B R, Whitman L J 2004 J. Cryst. Growth 270 301
Google Scholar
[15] Xie Q H, Van Nostrand J E, Brown J L, Stutz C E 1999 J. Appl. Phys. 86 329
Google Scholar
[16] Diaz-Thomas D A, Stepanenko O, Bahriz M, Calvez S, Tournié E, Baranov A N, Almuneau G, Cerutti L 2019 Opt. Express 27 31425
Google Scholar
[17] Canedy C L, Abell J, Bewley W W, Aifer E H, Kim C S, Nolde J A, Kim M, Tischler J G, Lindle J R, Jackson E M, Vurgaftman I, Meyer J R 2010 J. Vac. Sci. Technol. B 28 C3G8
Google Scholar
[18] Haugan H J, Grazulis L, Brown G J, Mahalingam K, Tomich D H 2004 J. Cryst. Growth 261 471
Google Scholar
[19] Bracker A S, Yang M J, Bennett B R, Culbertson J C, Moore W J 2000 J. Cryst. Growth 220 384
Google Scholar
[20] 尤明慧, 祝煊宇, 李雪, 李士军, 刘国军 2021 红外与毫米波学报 40 725
Google Scholar
You M H, Zhu X Y, Li X, Li S J, Liu G J 2021 J. Infrared Millim. Waves 40 725
Google Scholar
[21] https://lase.mer.utexas.edu/mbe.php [2022-07-09]
[22] 马琳, 王玉田, 庄蔚华 1992 红外与毫米波学报 11 37
Ma L, Wang Y T, Zhunag W H 1992 J. Infrared Millim. Waves 11 37
[23] https://lelpersonal.weebly.com/uploads/1/3/4/6/13462265/report.pdf (2022.07.09)
[24] Bauer A, Dallner M, Herrmann A, Lehnhardt T, Kamp M, Höfling S, Worschech L, Forchel A 2010 Nanotechnology 21 455603
Google Scholar
[25] Tuttle G, Kroemer H, English J H 1990 J. Appl. Phys. 67 3032
Google Scholar
[26] Spitzer J, Höpner A, Kuball M, Cardona M, Jenichen B, Neuroth H, Brar B, Kroemer H 1995 J. Appl. Phys. 77 811
Google Scholar
-
图 1 GaSb衬底在410 ℃附近表面再构从(a) 3×到(b) 5× 转变
Fig. 1. The surface reconstruction of GaSb substrate changed from (a) 3× to (b) 5× at about 410 ℃.
图 2 不同温度下生长InAs材料获得的RHEED振荡曲线
Fig. 2. The oscillation curves of RHEED obtained by growing InAs materials at different temperatures.
图 3 GaSb和GaAs生长速率随Ga源炉温度的变化情况
Fig. 3. Variation of growth rate of GaSb and GaAs with temperature of Ga source furnace.
图 4 采用RHEED测量获得的AlSb生长速率随源炉温度变化情况
Fig. 4. Variation of AlSb growth rate measured by RHEED with source furnace temperature.
图 5 GaSb/AlSb和InAs/GaSb 40周期短周期超晶格结的XRD典型结果
Fig. 5. Typical results obtained from XRD measurement of 40-short period SPLs structures of GaSb/AlSb and InAs/ GaSb.
图 6 0, 3和8 nm三个不同针阀位置生长样品的XRD曲线
Fig. 6. XRD curves of samples grown at three different needle valve positions of 0, 3 and 8 nm, respectively.
图 7 AlSb和GaSb样品生长后的高分辨率XRD衍射曲线
Fig. 7. High resolution XRD diffraction curves of AlSb and GaSb samples after growth.
图 8 Sb束流SOAK时间变化对超晶格平均晶格常数的影响
Fig. 8. Effect of time variation of Sb beam SOAK on the average lattice constant of SPLs.
图 9 As束流变化对超晶格平均晶格常数的影响情况
Fig. 9. Effect of As beam variation on the average lattice constant of SPLs.
-
[1] Bennett B R, Magno R, Boos J B, Kruppa W, Ancona M G 2005 Solid-State Electron. 49 1875
Google Scholar
[2] Cerutti L, Boissier G, Grech P, Perona A, Angellier J, Rouillard Y, Kaspi R, Genty F 2006 Electron. Lett. 42 1400
Google Scholar
[3] Delaunay P Y, Nguyen B M, Hoffman D, Hood A, Huang E K W, Razeghi M, Tidrow M Z 2008 Appl. Phys. Lett. 92 111112
Google Scholar
[4] Baranov A N, Teissier R 2015 IEEE J. Sel. Top. Quantum Electron. 21 1200612
[5] Cathabard O, Teissier R, Devenson J, Moreno J, Baranov A N 2010 Appl. Phys. Lett. 96 141110
Google Scholar
[6] Benveniste E, Vasanelli A, Delteil A, Devenson J, Teissier R, Baranov A, Andrews A M, Strasser G, Sagnes I, Sirtori C 2008 Appl. Phys. Lett. 93 131108
Google Scholar
[7] Nguyen V H, Loghmari Z, Philip H, Bahriz M, Baranov A N, Teissier R 2019 Photonics 6 31
Google Scholar
[8] Brandstetter M, Kainz M A, Zederbauer T, Krall M, Schönhuber S, Detz H, Schrenk W, Andrews A M, Strasser G, Unterrainer K 2016 Appl. Phys. Lett. 108 011109
Google Scholar
[9] Vurgaftman I, Bewley W W, Canedy C L, Kim C S, Kim M, Merritt C D, Abell J, Lindle J R, Meyer J R 2011 Nat. Commun. 2 585
Google Scholar
[10] Weih R, Kamp M, Hofling S 2013 Appl. Phys. Lett. 102 231123
Google Scholar
[11] Kroemer H 2004 Physica E 20 196
Google Scholar
[12] Li L H, Zhu J X, Chen L, Davies A G, Linfield E H 2015 Opt. Express 23 2720
Google Scholar
[13] Schmitz J, Wagner J, Fuchs F, Herres N, Koidl P, Ralston J D 1995 J. Cryst. Growth 150 858
Google Scholar
[14] Jackson E M, Boishin G I, Aifer E H, Bennett B R, Whitman L J 2004 J. Cryst. Growth 270 301
Google Scholar
[15] Xie Q H, Van Nostrand J E, Brown J L, Stutz C E 1999 J. Appl. Phys. 86 329
Google Scholar
[16] Diaz-Thomas D A, Stepanenko O, Bahriz M, Calvez S, Tournié E, Baranov A N, Almuneau G, Cerutti L 2019 Opt. Express 27 31425
Google Scholar
[17] Canedy C L, Abell J, Bewley W W, Aifer E H, Kim C S, Nolde J A, Kim M, Tischler J G, Lindle J R, Jackson E M, Vurgaftman I, Meyer J R 2010 J. Vac. Sci. Technol. B 28 C3G8
Google Scholar
[18] Haugan H J, Grazulis L, Brown G J, Mahalingam K, Tomich D H 2004 J. Cryst. Growth 261 471
Google Scholar
[19] Bracker A S, Yang M J, Bennett B R, Culbertson J C, Moore W J 2000 J. Cryst. Growth 220 384
Google Scholar
[20] 尤明慧, 祝煊宇, 李雪, 李士军, 刘国军 2021 红外与毫米波学报 40 725
Google Scholar
You M H, Zhu X Y, Li X, Li S J, Liu G J 2021 J. Infrared Millim. Waves 40 725
Google Scholar
[21] https://lase.mer.utexas.edu/mbe.php [2022-07-09]
[22] 马琳, 王玉田, 庄蔚华 1992 红外与毫米波学报 11 37
Ma L, Wang Y T, Zhunag W H 1992 J. Infrared Millim. Waves 11 37
[23] https://lelpersonal.weebly.com/uploads/1/3/4/6/13462265/report.pdf (2022.07.09)
[24] Bauer A, Dallner M, Herrmann A, Lehnhardt T, Kamp M, Höfling S, Worschech L, Forchel A 2010 Nanotechnology 21 455603
Google Scholar
[25] Tuttle G, Kroemer H, English J H 1990 J. Appl. Phys. 67 3032
Google Scholar
[26] Spitzer J, Höpner A, Kuball M, Cardona M, Jenichen B, Neuroth H, Brar B, Kroemer H 1995 J. Appl. Phys. 77 811
Google Scholar
下载:
计量
- 文章访问数: 4969
- PDF下载量: 127
- 被引次数: 0
