-
采用直流三极溅射装置制备获得了CuInS2薄膜, 其中溅射靶采用一定面积比的[Cu]/[In]混合靶,反应气体采用CS2气体. 本文中主要研究了0.02 Pa分压反应气体条件下不同面积比的[Cu]/[In]混合靶和沉积基板温度对CuInS2薄膜结构和成分的影响, 其中CuInS2薄膜制备所用时间为2 h生长的厚度为1—2 μm. 通过对CuInS2薄膜的EPMA, X射线衍射测试分析表明, 最佳的CuInS2薄膜可在面积比[Cu]/[In]混合靶为1.4:1和可控温度(150, 250和350 ℃)的条件下制备获得, 并且其结构被确认为黄铜矿结构. 通过实验结果计算出CuInS2薄膜层有约为8.9%的C杂质含量.CuInS2 thin films are deposited on Pyrex slide glass substrates by direct current triode sputtering using CS2 as a reactive gas and Cu/In mixed metal plate as sputtering target. The effects of substrate temperature and area ratio of Cu to In on the crystalline structure and composition of CuInS2 films are discussed under the same growth condition (0.02 Pa of CS2 partial pressure). When sputtering time is 2 h, their thickness are obtained to be 1-2 μm. The CuInS2 films are characterized by EPMA, XRD, and so on. The results show that the optimal CuInS2 films are obtained at a ratio of 1.4 and growth temperatures of 150 ℃, 250 ℃ and 350 ℃, and that these films each have a chalcopyrite structure. The content of carbon impurity in each of the as-deposited CuInS2 films is found to be about 8.9%.
-
Keywords:
- chalcopyrite semiconductor /
- reactive sputtering /
- CuInS2 films /
- EPMA
[1] Shay J L, Tell B, Kasper H M, Schiavone L M 1972 Phys. Rev. B 5 5003
[2] Klaer J, Bruns J, Henninger R, Siemer K, Klenk R, Ellmer K, Braunig D 1998 Semiconductor. Sci. Technol. 13 1456
[3] Kobayashi S, Kozakai H, Vequizo R M, Oishi K, Kaneko F 2005 Jpn. J. Appl. Phys. 44 999
[4] Plank, 于丹阳 CN201110362187.6 [2011年11月16日]
[5] Hwang H L, Sun C Y, Fang C S, Chang S D, Cheng C H, Yang M H, Lin H H, Tuwan-mu T 1981 J. Cryst. Growth 55 116
[6] Hwang H L, Cheng C L, Liu L M, Liu Y C, Sun C Y 1980 Thin Solid Films 67 83
[7] Pamplin B, Feigelson R S 1979 Thin Solid Films 60 141
[8] 小林康之, 于丹阳, サリナント M M, 小林敏志, 金子双男, 川上貴浩 信学技報 (Vol.94) (日本新潟市:電子情報通信学会) 1994-09-12 CPM94-56~64
[9] Kittel C 1988 Introduction to Solid State Physics (6th) 宇野良清, 津屋昇, 森田章, 山下次郎共訳1988 (第6版) (日本: 日本丸善株式会社) p1—86
[10] Shay J L, Wernick J H 1975 Ternary Chalcopyrite Semiconductors, Growth, Electrical Properties and Applications (Pergamon Press, 1975)
[11] Kobayashi S, YU D Y, Sarinanto M M, Kobayashi Y, Kaneko F, Kawakami T 1995 Jpn. J. Appl. Phys. 34 L513
-
[1] Shay J L, Tell B, Kasper H M, Schiavone L M 1972 Phys. Rev. B 5 5003
[2] Klaer J, Bruns J, Henninger R, Siemer K, Klenk R, Ellmer K, Braunig D 1998 Semiconductor. Sci. Technol. 13 1456
[3] Kobayashi S, Kozakai H, Vequizo R M, Oishi K, Kaneko F 2005 Jpn. J. Appl. Phys. 44 999
[4] Plank, 于丹阳 CN201110362187.6 [2011年11月16日]
[5] Hwang H L, Sun C Y, Fang C S, Chang S D, Cheng C H, Yang M H, Lin H H, Tuwan-mu T 1981 J. Cryst. Growth 55 116
[6] Hwang H L, Cheng C L, Liu L M, Liu Y C, Sun C Y 1980 Thin Solid Films 67 83
[7] Pamplin B, Feigelson R S 1979 Thin Solid Films 60 141
[8] 小林康之, 于丹阳, サリナント M M, 小林敏志, 金子双男, 川上貴浩 信学技報 (Vol.94) (日本新潟市:電子情報通信学会) 1994-09-12 CPM94-56~64
[9] Kittel C 1988 Introduction to Solid State Physics (6th) 宇野良清, 津屋昇, 森田章, 山下次郎共訳1988 (第6版) (日本: 日本丸善株式会社) p1—86
[10] Shay J L, Wernick J H 1975 Ternary Chalcopyrite Semiconductors, Growth, Electrical Properties and Applications (Pergamon Press, 1975)
[11] Kobayashi S, YU D Y, Sarinanto M M, Kobayashi Y, Kaneko F, Kawakami T 1995 Jpn. J. Appl. Phys. 34 L513
计量
- 文章访问数: 5970
- PDF下载量: 390
- 被引次数: 0