搜索

x

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

倒装芯片上金属布线/凸点互连结构中原子的定向扩散

陆裕东 何小琦 恩云飞 王歆 庄志强

引用本文:
Citation:

倒装芯片上金属布线/凸点互连结构中原子的定向扩散

陆裕东, 何小琦, 恩云飞, 王歆, 庄志强

Directional diffusion of atoms in metal strips/bump interconnects of flip chip

Lu Yu-Dong, He Xiao-Qi, En Yun-Fei, Wang Xin, Zhuang Zhi-Qiang
PDF
导出引用
  • 采用倒装芯片互连凸点串联回路研究了高温、高电流密度条件下倒装芯片上金属布线/凸点互连结构中原子的定向扩散现象,分析了互连结构中受电应力和化学势梯度作用的各相金属原子的扩散行为.在电迁移主导作用下,Ni(V)镀层中的Ni原子的快速扩散导致原本较为稳定的Ni(V)扩散阻挡层发生快速的界面反应,造成Al互连金属与焊料的直接接触.Al原子在电子风力作用下沿电子流方向向下迁移造成窗口附近焊料中Al原子含量逐步上升,同时,空位的反向迁移、聚集形成过饱和,导致Al互连中形成大面积空洞.焊料中的Sn,Pb原子在化学势梯度
    The diffusion character of metal atoms in the interconnects of metal strips/solder bump was observed by series solder bumps on flip chip which were stressed by high density electric current under high temperature. Assumed that the diffusion of atoms was controlled by electrical stress and chemical potential gradient,the diffusion behavior of all metal atoms in interconnects was investigated. The Ni atoms in the Ni(V) finishes directionally diffuse along the electron flow and accelerate the interface reaction of Ni and Sn by electromigration. Thus the Ni(V) finishes lose the action of the diffusion barrier layer in turn that resulted in the direct connection of Al and the solder. The Al atoms migrate in the electron flow by the electron wind force induced the Al atoms content in solder near the passivation via increases with the stressed time. The vacancies move in the opposite direction with the Al atom flux,and collect in the Al strips. Then the voids appear after the supersaturation of vacancies. The Sn and Pb atoms in the solder diffuse along the concentration gradient because of the non-leading action of electromigration. The atoms in the solder driven by the chemical potential gradient and compression stress form the upward fluxes. The upward diffusion of solder erodes the Al strips,which made the Al strips failure due to the voids and corrosion. The Al and Sn/Pb atoms were driven by their respective dominant force,and result in durative mutual diffusion until the interconnects take place the open circuit because of the difference of mass flux.
    • 基金项目: 中国博士后科学基金(批准号:20080430825)、国家预研基金(批准号:51323060305)和信息产业部电子第五研究所科技发展基金(批准号:XF0726130)资助的课题.
    [1]

    [1] Zaporozhets T V,Gusak A M,Tu K N,Mhaisalkar S G 2005 J. Appl. Phys. 98 1

    [2]

    [2] He L,Du L,Zhuang Y Q,Chen C X,Wei T,Huang X J 2007 Acta Phys. Sin. 56 7176 (in Chinese) [何亮、杜磊、庄奕琪、陈春霞、卫涛、黄小君 2007 物理学报 56 7176]

    [3]

    [3] Zhang W J,Yi W B,Wu J 2006 Acta Phys. Sin. 55 5424 (in Chinese) [张文杰、易万兵、吴瑾 2006 物理学报 55 524]

    [4]

    [4] Tu K N 2003 J. Appl. Phys. 94 5451

    [5]

    [5] Lu Y D,He X Q,En Y F,Wang X,Zhuang Z Q 2009 Acta Phys. Sin. 58 1942 (in Chinese) [陆裕东、何小琦、恩云飞、王歆、庄志强 2009 物理学报 58 1942]

    [6]

    [6] Nah J W,Chen K,Tu K N,Su B R,Chen C 2007 J. Mater. Res. 22 763

    [7]

    [7] Ouyang F Y,Tu K N,Kao C L,Lai Y S 2007 Appl. Phys. Lett. 90 211914

    [8]

    [8] Shao W,Mhaisalkar S G,Sritharan T,Vairagar A V,Engelmann H J,Aubel O,Zschech E,Gusak A M,Tu K N 2007 Appl. Phys.Lett. 90 052106

    [9]

    [9] Lu Y D,He X Q,En Y F,Wang X,Zhuang Z Q 2009 Acta Mater. 57 2560

    [10]

    ] Gan Z,Gusak A M,Shao W,Chen Z,Mhaisalkar S G,Zaporozhets T,Tu K N 2007 J. Mater. Res. 22 152

    [11]

    ] Yang D,Wu B Y,Chan Y C,Tu K N 2007 J. Appl. Phys. 102 043502

    [12]

    ] Ouyang F Y,Chen K,Tu K N,Lai Y S 2007 Appl. Phys. Lett. 91 231919

    [13]

    ] Liang S W,Chang Y W,Shao T L,Chen C,Tu K N 2006 Appl. Phys. Lett. 89 022117

    [14]

    ] Lu Y D,He X Q,En Y F,Wang X,Zhuang Z Q 2009 Acta Metall. Sin. 45 178 (in Chinese) [陆裕东、何小琦、恩云飞、王歆、庄志强 2009 金属学报 45 178]

    [15]

    ] Zhang L,Ou S,Huang J,Tu K N,Gee S,Nguyen L 2006 Appl. Phys. Lett. 88 012106

  • [1]

    [1] Zaporozhets T V,Gusak A M,Tu K N,Mhaisalkar S G 2005 J. Appl. Phys. 98 1

    [2]

    [2] He L,Du L,Zhuang Y Q,Chen C X,Wei T,Huang X J 2007 Acta Phys. Sin. 56 7176 (in Chinese) [何亮、杜磊、庄奕琪、陈春霞、卫涛、黄小君 2007 物理学报 56 7176]

    [3]

    [3] Zhang W J,Yi W B,Wu J 2006 Acta Phys. Sin. 55 5424 (in Chinese) [张文杰、易万兵、吴瑾 2006 物理学报 55 524]

    [4]

    [4] Tu K N 2003 J. Appl. Phys. 94 5451

    [5]

    [5] Lu Y D,He X Q,En Y F,Wang X,Zhuang Z Q 2009 Acta Phys. Sin. 58 1942 (in Chinese) [陆裕东、何小琦、恩云飞、王歆、庄志强 2009 物理学报 58 1942]

    [6]

    [6] Nah J W,Chen K,Tu K N,Su B R,Chen C 2007 J. Mater. Res. 22 763

    [7]

    [7] Ouyang F Y,Tu K N,Kao C L,Lai Y S 2007 Appl. Phys. Lett. 90 211914

    [8]

    [8] Shao W,Mhaisalkar S G,Sritharan T,Vairagar A V,Engelmann H J,Aubel O,Zschech E,Gusak A M,Tu K N 2007 Appl. Phys.Lett. 90 052106

    [9]

    [9] Lu Y D,He X Q,En Y F,Wang X,Zhuang Z Q 2009 Acta Mater. 57 2560

    [10]

    ] Gan Z,Gusak A M,Shao W,Chen Z,Mhaisalkar S G,Zaporozhets T,Tu K N 2007 J. Mater. Res. 22 152

    [11]

    ] Yang D,Wu B Y,Chan Y C,Tu K N 2007 J. Appl. Phys. 102 043502

    [12]

    ] Ouyang F Y,Chen K,Tu K N,Lai Y S 2007 Appl. Phys. Lett. 91 231919

    [13]

    ] Liang S W,Chang Y W,Shao T L,Chen C,Tu K N 2006 Appl. Phys. Lett. 89 022117

    [14]

    ] Lu Y D,He X Q,En Y F,Wang X,Zhuang Z Q 2009 Acta Metall. Sin. 45 178 (in Chinese) [陆裕东、何小琦、恩云飞、王歆、庄志强 2009 金属学报 45 178]

    [15]

    ] Zhang L,Ou S,Huang J,Tu K N,Gee S,Nguyen L 2006 Appl. Phys. Lett. 88 012106

  • [1] 廖晶晶, 蔺福军. 混合手征活性粒子在时间延迟反馈下的扩散和分离. 物理学报, 2020, 69(22): 220501. doi: 10.7498/aps.69.20200505
    [2] 王超, 陈英才, 周艳丽, 罗孟波. 两嵌段高分子链在周期管道内扩散的Monte Carlo模拟. 物理学报, 2017, 66(1): 018201. doi: 10.7498/aps.66.018201
    [3] 李亚雄, 刘先贵, 胡志明, 高树生, 端祥刚, 常进. 页岩气滑脱、扩散传输机理耦合新方法. 物理学报, 2017, 66(11): 114702. doi: 10.7498/aps.66.114702
    [4] 吴振宇, 杨银堂, 柴常春, 刘莉, 彭杰, 魏经天. 基于微观结构的Cu互连电迁移失效研究. 物理学报, 2012, 61(1): 018501. doi: 10.7498/aps.61.018501
    [5] 吴振宇, 董嗣万, 刘毅, 柴常春, 杨银堂. 铜互连电迁移失效阻变特性研究. 物理学报, 2012, 61(24): 248501. doi: 10.7498/aps.61.248501
    [6] 何亮, 杜磊, 黄晓君, 陈华, 陈文豪, 孙鹏, 韩亮. 金属互连电迁移噪声的非高斯性模型研究. 物理学报, 2012, 61(20): 206601. doi: 10.7498/aps.61.206601
    [7] 林晓玲, 肖庆中, 恩云飞, 姚若河. 倒装芯片塑料球栅阵列封装器件在外应力下的失效机理. 物理学报, 2012, 61(12): 128502. doi: 10.7498/aps.61.128502
    [8] 黄明亮, 陈雷达, 周少明, 赵宁. 电迁移对Ni/Sn3.0Ag0.5Cu/Au/Pd/Ni-P倒装焊点界面反应的影响. 物理学报, 2012, 61(19): 198104. doi: 10.7498/aps.61.198104
    [9] 陈德彝, 王忠龙. 白交叉关联色噪声驱动的线性振子的扩散. 物理学报, 2010, 59(1): 111-115. doi: 10.7498/aps.59.111
    [10] 陆裕东, 何小琦, 恩云飞, 王歆, 庄志强. Sn3.0Ag0.5Cu倒装焊点中的电迁移. 物理学报, 2009, 58(3): 1942-1947. doi: 10.7498/aps.58.1942
    [11] 张传瑜, 高 涛, 张云光, 周晶晶, 朱正和, 陈 波. 氦对LaNi5晶体结构的影响及其扩散特性研究. 物理学报, 2008, 57(7): 4379-4385. doi: 10.7498/aps.57.4379
    [12] 何 亮, 杜 磊, 庄奕琪, 李伟华, 陈建平. 金属互连电迁移噪声的多尺度熵复杂度分析. 物理学报, 2008, 57(10): 6545-6550. doi: 10.7498/aps.57.6545
    [13] 陈春霞, 杜 磊, 何 亮, 胡 瑾, 黄小君, 卫 涛. 金属互连电迁移噪声的分形特征. 物理学报, 2007, 56(11): 6674-6679. doi: 10.7498/aps.56.6674
    [14] 何 亮, 杜 磊, 庄奕琪, 陈春霞, 卫 涛, 黄小君. 金属互连电迁移噪声的相关维数研究. 物理学报, 2007, 56(12): 7176-7182. doi: 10.7498/aps.56.7176
    [15] 王永亮, 张 超, 唐 鑫, 张庆瑜. 表面Cu原子间相互作用对Cu(001)表面跳跃扩散行为的影响. 物理学报, 2006, 55(8): 4214-4220. doi: 10.7498/aps.55.4214
    [16] 曹 博, 包良满, 李公平, 何山虎. Cu/SiO2/Si(111)体系中Cu和Si的扩散及界面反应. 物理学报, 2006, 55(12): 6550-6555. doi: 10.7498/aps.55.6550
    [17] 张文杰, 易万兵, 吴 瑾. 铝互连线的电迁移问题及超深亚微米技术下的挑战. 物理学报, 2006, 55(10): 5424-5434. doi: 10.7498/aps.55.5424
    [18] 常福宣, 陈 进, 黄 薇. 反常扩散与分数阶对流-扩散方程. 物理学报, 2005, 54(3): 1113-1117. doi: 10.7498/aps.54.1113
    [19] 宗兆翔, 杜 磊, 庄奕琪, 何 亮, 吴 勇. 超大规模集成电路互连电迁移自由体积电阻模型. 物理学报, 2005, 54(12): 5872-5878. doi: 10.7498/aps.54.5872
    [20] 杜磊, 庄奕琪, 薛丽君. 金属薄膜电迁移1/f噪声与1/f2噪声统一模型. 物理学报, 2002, 51(12): 2836-2841. doi: 10.7498/aps.51.2836
计量
  • 文章访问数:  7194
  • PDF下载量:  731
  • 被引次数: 0
出版历程
  • 收稿日期:  2009-06-17
  • 修回日期:  2009-08-18
  • 刊出日期:  2010-05-15

/

返回文章
返回