-
采用真空热压技术将电磁感应加热－自悬浮定向流法制备的铝纳米粉末压制成块体样品. 通过X射线衍射、透射电子显微镜、扫描电子显微镜及X射线能谱分析了铝纳米晶的微观结构, 并用四探针法测量了不同温度下(8-300 K)样品的电阻率, 研究了铝纳米晶的电阻率() 随温度的变化规律. 结果表明: 由于晶界(非晶氧化铝)对电子的散射以及晶界声子对电子的散射效应, 低温下(40 K), 铝纳米晶的本征电阻率随温度变化关系明显不同于粗晶铝, 不仅呈现出T4变化, 还表现出显著的T3 变化规律. 因晶界等缺陷和非晶氧化铝杂质对电子的散射, 铝纳米晶残余电阻率比粗晶铝电阻率大5-6 个数量级.The nanostructured materials have been revealed to have exclusive physical and chemical properties due to their quantum-size effects, small-size effects and a large fraction of grain boundaries. Especially, the grain boundaries play an important role in the electrical resistivity of nanostructured metal. We use the four-point probe method to measure the values of electrical resistivity () of the nanostructured aluminum samples and the coarse-grained bulk aluminum samples at temperature (T) ranging from 8 K to 300 K to explore the relationship between the electrical resistivity and temperature. The aluminum nanoparticles produced by the flow-levitation method through electromagnetic induction heating are compacted into nanostructured samples in vacuum by the hot pressing and sintering technology. The microstructures of all nanostructured aluminum samples are analyzed by X-ray diffraction (XRD), transmission electron microscope (TEM), scanning electron microscope with the energy-dispersive spectrometer (SEM-EDS). The densities of all nanostructured aluminum samples are measured by using the Archimedes method (the medium is absolute alcohol). The experimental results show that the shape of aluminum nanoparticles is found to keep spherical from the SEM images and the relative density of all nanostructured aluminum samples is about 93% of the coarse-grained bulk aluminum. The XRD spectra state that the face-centered cubic (fcc) phase dominates the samples and no diffraction peak related to impurities appears in the XRD spectrum for each of all nanostructured aluminum samples. Amorphous alumina layers (about 2 nm thick) are found to surround the aluminum nanoparticles and hence connect the grains in the nanostructured aluminum as shown in the high-resolution TEM images. Owing to the scattering of grain boundaries on electrons and the phonon-electron scattering at grain boundaries, the electrical resistivity is far larger in the nanostructured aluminum than in the coarse-grained bulk aluminum and the relationship between the electrical resistivity and temperature for nanostructured aluminum shows a different feature from that for the coarse-grained bulk aluminum. Although the temperature dependent electrical resistivity ((T)) is a function of T4 at low temperatures for the coarse-grained bulk aluminum, it varies with the temperature not only according to the relation T4, but also according to the relation T3 for the nanostructured aluminum. The residual resistivity (0) of the nanostructured aluminum sample is about 5.510-4m, 5-6 orders magnitude larger than that of the coarse-grained bulk aluminum (2.0110-10m) due to the scattering of both the grain boundaries and amorphous alumina on electrons therein.
-
Keywords:
- nanostructured aluminum /
- electrical resistivity /
- phonon-electron scattering /
- grain boundary
[1] Okuda S, Tang F 1995 Nanostruct. Mater. 6 585
[2] Kumar K S, van Swygenhoven H, Suresh S 2003 Acta. Mater. 51 5743
[3] Ederth J, Kish L B, Olsson E, Granqvist C G 2002 J. Appl. Phys. 91 1529
[4] Andrews P V 1965 Phys. Lett. 19 558
[5] Huang Y K, Menovsky A A, de Boer F R 1993 Nanostruct. Mater. 2 505
[6] Riedel S, Rber J, GeBner T 1997 Microelectron. Eng. 33 165
[7] Okram G S, Soni A, Rawat R 2008 Nanotechnology 19 185711
[8] Zeng H, Wu Y, Zhang J X, Kuang C J, Yue M, Zhou S X 2013 Prog. Nal. Sci.: Mater. Int. 23 18
[9] Ziman J M 1960 Electrons and Phonons (Oxford: Clarendon Press) pp334-335
[10] Bid A, Bora A, Raychaudhuri A K 2006 Phys. Rev. B 74 035426
[11] Charles K (translated by Xiang J Z, Wu X H) 2005 Introduction to Solid State Physics (Beijing: Chemical Industry Press) p105 (in Chinese) [基泰尔 著, (项金钟, 吴兴惠 译)2005 固体物理导论 (北京:化学工业出版社)第105页
[12] Moussouros P K, Kos J F 1977 Can. J. Phys. 55 2071
[13] Qian L H, Lu Q H, Kong W J, Lu K 2004 Scripta Mater. 50 1407
[14] Barmak K, Darbal A, Ganesh K J, Ferreira P J, Rickman J M, Sun T, Yao B, Warren A P, Coffey K R 2014 J. Vac. Sci. Technol. A 32 061503
[15] Arenas C, Henriquez R, Moraga L, Munoz E, Munoz R C 2015 Appl. Surf. Sci. 329 184
[16] Mayadas A F, Shatzkes M1970 Phys. Rev. B 1 1382
[17] Wei J J, Li C Y, Tang Y J, Wu W D, Yang X D 2003 High Power Laser and Particle beams 15 359 (in chinese) [韦军建, 李超阳, 唐永建, 吴卫东, 杨向东 2003 强激光与离子束 15 359]
[18] Li Y 2014 M. S. Dissertation (Mianyang: Southwest University of Science and Technology) (in Chinese) [李裕 2014 硕士学位论文(绵阳: 西南科技大学)]
[19] Song Y H, Luo J S, Fan X Q, Xing P F, Yi Y, Yang M S, Li K, Lei H L 2015 At. Energ. Sci. Technol. 49 354 (in Chinese) [宋言红, 罗江山, 范晓强, 邢丕峰, 易勇, 杨蒙生, 李凯, 雷海乐 2015 原子能科学技术 49 354]
[20] Huang K, Han R Q 2006 Solid State Physics (Beijing: Higher Education Press) p300 (in Chinese) [黄昆, 韩汝琦 2006 固体物理学(北京: 高等教育出版社)第300页]
[21] Kasap S O (translated by Wang H) 2009 Principles of Electronic Materials and Devices (Vol.1) Third Edition (Xian: Xian Jiaotong University Press) pp98-108 (in Chinese) [萨法卡萨普 著 (汪宏 译)2009 电子材料与器件原理(上册) 第三版(西安: 西安交通大学出版社)第 98-108 页]
[22] Tomchuk P M 1992 Int. J. Electron. 73 949
[23] Hodak J H, Henglein A, Hartland G V 2000 J. Chem. Phys. 112 5942
[24] Ma W G, Wang H D, Zhang X, Wang W 2010 J. Appl. Phys. 108 064308
[25] Lu K 1996 Mater. Sci. Eng. 16 161221
[26] Van Hove M A, Weinberg W H, Chan C M 1986 Low-energy Electron Diffraction (Berlin: Springer-Verlag) pp45-48
[27] Hu X, Wang G, Wu W, Jiang P, Zi J 2001 J. Phys.: Condens. Matter 13 835
[28] Lei H L, Li J, Liu Y Q, Liu X 2013 Europhys. Lett. 101 46001
[29] Kubakaddi S S 2007 Phy. Rev. B 75 075309
[30] Kara A, Rahman T S 1998 Phys. Rev. Lett. 81 1453
[31] Dobierzewska-Mozrzymas E, Warkusz F 1979 Electrocomponent Sci. Technol. 5 223
[32] Berry R J 1972 Phys. Rev. B 6 2994
[33] Dworin L 1971 Phys. Rev. Lett. 26 1244
-
[1] Okuda S, Tang F 1995 Nanostruct. Mater. 6 585
[2] Kumar K S, van Swygenhoven H, Suresh S 2003 Acta. Mater. 51 5743
[3] Ederth J, Kish L B, Olsson E, Granqvist C G 2002 J. Appl. Phys. 91 1529
[4] Andrews P V 1965 Phys. Lett. 19 558
[5] Huang Y K, Menovsky A A, de Boer F R 1993 Nanostruct. Mater. 2 505
[6] Riedel S, Rber J, GeBner T 1997 Microelectron. Eng. 33 165
[7] Okram G S, Soni A, Rawat R 2008 Nanotechnology 19 185711
[8] Zeng H, Wu Y, Zhang J X, Kuang C J, Yue M, Zhou S X 2013 Prog. Nal. Sci.: Mater. Int. 23 18
[9] Ziman J M 1960 Electrons and Phonons (Oxford: Clarendon Press) pp334-335
[10] Bid A, Bora A, Raychaudhuri A K 2006 Phys. Rev. B 74 035426
[11] Charles K (translated by Xiang J Z, Wu X H) 2005 Introduction to Solid State Physics (Beijing: Chemical Industry Press) p105 (in Chinese) [基泰尔 著, (项金钟, 吴兴惠 译)2005 固体物理导论 (北京:化学工业出版社)第105页
[12] Moussouros P K, Kos J F 1977 Can. J. Phys. 55 2071
[13] Qian L H, Lu Q H, Kong W J, Lu K 2004 Scripta Mater. 50 1407
[14] Barmak K, Darbal A, Ganesh K J, Ferreira P J, Rickman J M, Sun T, Yao B, Warren A P, Coffey K R 2014 J. Vac. Sci. Technol. A 32 061503
[15] Arenas C, Henriquez R, Moraga L, Munoz E, Munoz R C 2015 Appl. Surf. Sci. 329 184
[16] Mayadas A F, Shatzkes M1970 Phys. Rev. B 1 1382
[17] Wei J J, Li C Y, Tang Y J, Wu W D, Yang X D 2003 High Power Laser and Particle beams 15 359 (in chinese) [韦军建, 李超阳, 唐永建, 吴卫东, 杨向东 2003 强激光与离子束 15 359]
[18] Li Y 2014 M. S. Dissertation (Mianyang: Southwest University of Science and Technology) (in Chinese) [李裕 2014 硕士学位论文(绵阳: 西南科技大学)]
[19] Song Y H, Luo J S, Fan X Q, Xing P F, Yi Y, Yang M S, Li K, Lei H L 2015 At. Energ. Sci. Technol. 49 354 (in Chinese) [宋言红, 罗江山, 范晓强, 邢丕峰, 易勇, 杨蒙生, 李凯, 雷海乐 2015 原子能科学技术 49 354]
[20] Huang K, Han R Q 2006 Solid State Physics (Beijing: Higher Education Press) p300 (in Chinese) [黄昆, 韩汝琦 2006 固体物理学(北京: 高等教育出版社)第300页]
[21] Kasap S O (translated by Wang H) 2009 Principles of Electronic Materials and Devices (Vol.1) Third Edition (Xian: Xian Jiaotong University Press) pp98-108 (in Chinese) [萨法卡萨普 著 (汪宏 译)2009 电子材料与器件原理(上册) 第三版(西安: 西安交通大学出版社)第 98-108 页]
[22] Tomchuk P M 1992 Int. J. Electron. 73 949
[23] Hodak J H, Henglein A, Hartland G V 2000 J. Chem. Phys. 112 5942
[24] Ma W G, Wang H D, Zhang X, Wang W 2010 J. Appl. Phys. 108 064308
[25] Lu K 1996 Mater. Sci. Eng. 16 161221
[26] Van Hove M A, Weinberg W H, Chan C M 1986 Low-energy Electron Diffraction (Berlin: Springer-Verlag) pp45-48
[27] Hu X, Wang G, Wu W, Jiang P, Zi J 2001 J. Phys.: Condens. Matter 13 835
[28] Lei H L, Li J, Liu Y Q, Liu X 2013 Europhys. Lett. 101 46001
[29] Kubakaddi S S 2007 Phy. Rev. B 75 075309
[30] Kara A, Rahman T S 1998 Phys. Rev. Lett. 81 1453
[31] Dobierzewska-Mozrzymas E, Warkusz F 1979 Electrocomponent Sci. Technol. 5 223
[32] Berry R J 1972 Phys. Rev. B 6 2994
[33] Dworin L 1971 Phys. Rev. Lett. 26 1244
计量
- 文章访问数: 4760
- PDF下载量: 260
- 被引次数: 0
下载:
