-
针对充放电模式对电极储锂性能的影响开展综合实验研究与机理分析. 设计了4种充放电模式, 进行不同充放电模式下还原氧化石墨烯电极的储锂性能实验, 并从电极动态反应性能和应变两方面开展实验分析充放电模式对储锂时间和容量的影响机理. 实验结果显示, 不同充放电模式下电极储锂时间越短容量折损越多, 综合数据分析指出电荷转移阻抗、扩散系数、过电位和应变均表现出了非线性和阶段性的特点. 最后提出“大电流-小电流”模式为可行的充放电优化方案, 利用电化学进程的非线性平衡了快充技术中时间和容量之间的矛盾, 为快速充电技术的设计和优化提供了一定的指导.In this paper we conduct comprehensive experimental research and analyze the effect of charge-discharge modes on the performance of lithium storage. Four charge-discharge modes are designed, and the lithium storage performance experiments of the reduced graphene oxide electrode under different charge-discharge modes are carried out to analyze the effect mechanism of charge-discharge mode on lithium storage time and capacity from two aspects of electrode dynamic reaction performance and strain. The experimental results show that the shorter the lithium storage time of the electrode, the more the capacity loss under different charge-discharge modes. Comprehensive data analysis indicates that the charge transfer resistance, diffusion coefficient, overpotential and strain in the electrochemical process show non-linear and staged characteristics, resulting in the different lithium storage performances’ mechanism of different stages under different charge-discharge modes. Finally, “High current-low current” mode is proposed as a feasible optimization plan for charging and discharging. In the initial stage-I, the dual role of large electric field drive and concentration gradient drive enhances the migration and diffusion rate and shortens the lithium storage time; in the stage-II, the small current relieves local concentration accumulation and increases the amount of lithium inserted, thereby giving full play to the greatest advantage of current in each stage and balance the discrepancy between time and capacity. And this discussion provides certain guidance for designing and optimizing the fast charging technology.
-
Keywords:
- charge-discharge mode /
- lithium storage performance /
- dynamic process /
- mechanism analysis
[1] Cai W, Yao Y X, Zhu G L, Yan C, Jiang L L, He C, Huang J Q, Zhang Q 2020 Chem. Soc. Rev. 49 3806
Google Scholar
[2] Xie W, Liu X, He R, Li Y, Yang S 2020 J. Energy Storage 32 101837
Google Scholar
[3] Tomaszewska A, Chu Z Y, Feng X N, O'Kane S, Liu X H, Chen J Y, Ji C Z, Endler E, Li R H, Liu L S, Li Y L, Zheng S Q, Vetterlein S, Gao M, Du J Y, Parkes M, Ouyang M G, Marinescu M, Offer G, Wu B 2019 eTransportation 1 100011
Google Scholar
[4] 张兴玉 2020 物理学报 69 248201
Zhang X Y 2020 Acta Phys. Sin. 69 248201
[5] Keil P, Jossen A 2016 J. Energy Storage 6 125
Google Scholar
[6] Pharr M, Suo Z G, Vlassak J J 2014 J. Power Sources 270 569
Google Scholar
[7] Jung H, Gerasopoulos K, Talin A A, Ghodssi R 2017 J. Power Sources 340 89
Google Scholar
[8] Zheng Y, He Y B, Qian K, Li B H 2015 Electrochim. Acta 176 270
Google Scholar
[9] Abe Y, Hori N, Kumagai S 2019 Energies 12 4507
Google Scholar
[10] Shi B Q, Han B, Xie H M, Kang Y, Zhang Q 2021 Electrochim. Acta 378 138151
Google Scholar
[11] Xie H M, Song H B, Guo J G, Kang Y, Yang W, Zhang Q 2019 Carbon 144 342
Google Scholar
[12] Khan A B, Choi W 2018 IEEE Trans. Energy Convers. 33 1132
Google Scholar
[13] Ji D Y, Chen L D, Ma T Y, Jing, Wang S Q 2019 J. Power Sources 437 226911
Google Scholar
[14] Anseán D, Gonzalez M, Viera J C, Garcia V M, Blanco C, Valledor M 2013 J. Power Sources 239 9
Google Scholar
[15] Xu M, Wang R, Reichman B, Wang X 2018 J. Energy Storage 20 298
Google Scholar
[16] Suresh R, Rengaswamy R 2018 Comput. Chem. Eng. 119 326
Google Scholar
[17] Wu X G, Shi W W, Du J Y 2017 Energies 10 1271
Google Scholar
[18] Hu X, Li S, Peng H, Sun F 2013 J. Power Sources 239 449
Google Scholar
[19] Waldmann T, Kasper M, Wohlfahrt-Mehrens M 2015 Electrochim. Acta 178 525
Google Scholar
[20] Liu Y H, Hsieh C H, Luo Y F 2011 IEEE Trans. Energy Convers. 26 654
Google Scholar
[21] Wen K, Xia M, Deng P, Lv W, He W 2019 Chem. Eng. Sci. 200 80
Google Scholar
[22] Sethuraman V A, Srinivasan V, Newman J 2013 J. Electrochem. Soc. 160 A394
[23] Ko Y, Cho Y G, Song H K 2014 RSC Adv. 4 16545
Google Scholar
[24] Finegan D P, Quinn A, Wragg D S, Colclasure A M, Lu X, Tan C, Heenan T M, Jervis R, Brett D J, Das S 2020 Energy Environ. Sci. 13 2570
Google Scholar
[25] An F Q, Zhang R, Wei Z G, Li P 2019 RSC Adv. 9 21489
Google Scholar
[26] Zhang S S 2006 J. Power Sources 161 1385
Google Scholar
[27] Pham-Cong D, Ahn K, Hong S W, Jeong S Y, Choi J H, Doh C H, Jin J S, Jeong E D, Cho C R 2014 Curr. Appl. Phys. 14 215
Google Scholar
[28] Song H B, Na R, Hong C Y, Zhang G, Li X F, Kang Y L, Zhang Q, Xie H M 2022 Carbon 188 146
[29] Cançado L G, Jorio A, Ferreira E H M, Stavale F, Achete C A, Capaz R B 2011 Nano Lett. 11 3190
Google Scholar
[30] Song H B, Xie H M, Xu C C, Kang Y L, Zhang Q 2019 J. Phys. Chem. C 123 18861
Google Scholar
[31] Wang G X, Shen X P, Yao J, Park J 2009 Carbon 47 2049
Google Scholar
[32] 闻雷, 刘成名, 宋仁升, 罗洪泽, 石颖, 李峰, 成会明 2014 化学学报 72 333
Google Scholar
Wen L, Liu C M, Song R S, Luo H Z, Shi Y, Li F, Cheng H M 2014 Acta Chim. Sin. 72 333
Google Scholar
[33] Liu Z H, Kang Y L, Song H B, Zhang Q, Xie H 2020 Chin. Phys. B 30 016201
Google Scholar
[34] Liang H Z, Zhang X Y, Yang L, Wu Y K, Chen H S, Song W L, Fang D N 2019 Sci. China:Technol. Sci. 62 1277
Google Scholar
[35] 庄全超, 杨梓, 张蕾, 崔艳华 2020 化学进展 32 761
Google Scholar
Zhuang Q C, Yang Z, Zhang L, Cui Y H 2020 Prog. Chem. 32 761
Google Scholar
[36] Barsoukov E, Kim J H, Kim J H, Yoon C O, Lee H 1999 Solid State Ionics 116 249
Google Scholar
[37] Zhu Y J, Gao T, Fan X L, Han F, Wang C 2017 Acc. Chem. Res. 50 1022
Google Scholar
[38] Kang Y L, Qiu Y, Lei Z K, Hu M 2005 Opt. Laser Eng. 43 847
Google Scholar
[39] 陆敬予, 柯承志, 龚正良, 李德平, 慈立杰, 张力, 张桥保 2020 物理学报 70 198102
Google Scholar
Lu J Y, Ke C Z, Gong Z L, Li D P, Ci L J, Zhang L, Zhang Q B 2020 Acta Phys. Sin. 70 198102
Google Scholar
[40] Zabel J, Nair R R, Ott A, Georgiou T, Geim A K, Novoselov K S, Casiraghi C 2012 Nano Lett. 12 617
Google Scholar
[41] Zeng Z, Liu N, Zeng Q, Lee S W, Mao W L, Cui Y 2016 Nano Energy 22 105
Google Scholar
[42] Stampfer C, Molitor F, Graf D, Ensslin K, Jungen A, Hierold C, Wirtz L 2007 Appl. Phys. Lett. 91 241907
Google Scholar
[43] Lu B, Song Y C, Zhang J Q 2016 J. Power Sources 320 104
Google Scholar
[44] Lu B, Ning C, Shi D, Zhao Y, Zhang J 2020 Chin. Phys. B 29 026201
Google Scholar
-
图 1 4组放电模式示意图 (a) 参考组A, 恒定小电流模式; (b) 实验组B, 大电流-小电流模式; (c) 实验组C, 小电流-大电流模式; (d) 参考组D, 恒定大电流模式(I1表示大电流阶段的电流密度, I2表示小电流阶段的电流密度)
Fig. 1. Schematic diagram of four discharge modes: (a) Reference group A, constant low current mode; (b) experiment group B, high current-low current mode; (c) experiment group C, low current-high current mode; (d) reference group D, constant high current mode (I1 represents the current density at the high current stage, I2 represents the current density at the low current stage).
图 2 (a) rGO 电极的拉曼光谱图; (b) 改进的CR2032纽扣电池结构示意图, 具有可视的Kapton窗口以实现拉曼测量
Fig. 2. (a) Raman spectrum of rGO electrode; (b) schematic diagram of the modified CR2032 coin-cell assembly including a visible Kapton window to realize Raman measurement.
图 3 放电模式对循环第4圈比容量(左轴)和时间(右轴)的影响
Fig. 3. Effects of discharge modes on the specific capacity (left axis) and time (right axis) of the 4th cycle.
图 4 (a) 4组放电模式下rGO电极容量保持率(左轴)和库仑效率(右轴)随循环圈数的演化; (b) 4组放电模式下rGO电极能耗比率随循环圈数的变化; (c) 第3/25/50圈循环下放电模式对能耗比率的影响
Fig. 4. (a) Evolve of capacity retention rate (left axis) and coulomb efficiency (right axis) of the rGO electrode with the cycles under four discharge modes; (b) evolve of energy consumption rate of rGO electrode with the cycles under four discharge modes; (c) influence of discharge modes on the energy consumption of the 3/25/50 cycle.
图 5 (a) rGO电极主要动态反应过程示意图; (b) rGO电极的标准电化学阻抗图谱和等效电路; (c) 第4圈嵌锂过程中4组放电模式的电荷转移阻抗增量
$\bar{R}_{\rm{ct} }$ 随嵌锂阶段的变化; (d) 第4圈嵌锂过程中4组放电模式的扩散系数随嵌锂阶段的变化Fig. 5. (a) Schematic diagram of the main dynamic reaction process of rGO electrode; (b) standard electrochemical impedance spectrum and equivalent circuit of the rGO electrode; (c) evolve of charge transfer resistance with the degree of lithiation under four discharge modes of the 4th cycle; (d) evolve of diffusion coefficient with the degree of lithiation under four discharge modes of the 4th cycle.
图 6 第4圈嵌锂过程rGO电极的原位拉曼光谱-应变测量 (a) 参考组A (恒定小电流)、(b) 实验组B (大电流-小电流)、(c) 实验组C (小电流-大电流)和 (d) 参考组D (恒定大电流)的G峰谱线信息和电位曲线随时间的演化; (e) 4种放电模式下G峰频移随时间的演化及线性拟合结果
Fig. 6. In-situ Raman spectroscopy-strain measurement of rGO electrode during the 4th lithiation process: The evolution of the G peak spectral line information and potential curves with time of (a) reference group A (constant low current), (b) experimental group B (high current-low current), (c) experimental group C (low current-high current) and (d) reference group D (constant high current); (e) evolution and linearity of G peak frequency shift and fitting result under four discharge modes.
图 7 两阶段恒流模式下锂化过程示意图 (a) 实验组B (大电流-小电流); (b) 实验组C (小电流-大电流)
Fig. 7. Schematic diagram of the lithiation process under two-stage constant current modes: (a) Experimental group B (high current-low current); (b) experimental group C (low current-high current).
图 8 “大电流-小电流”两阶段恒流模式的优化机理 (a) 阶段-I主要优化时间; (b) 阶段-II主要优化容量
Fig. 8. Optimization mechanism of “High current-Low current” two-stage constant current mode: (a) Stage-I mainly optimizes time; (b) stage-II mainly optimizes capacity.
表 1 实验组B (大电流-小电流)加载流程示意
Table 1. Schematic diagram of the process of experimental group B (high current-low current).
实验步骤 工步模式 电流密度 结束条件 1 静置 0 t = 1 min 2 放电 I1 = 160 mA·g–1 SOC = 45% 3 放电 I2 = 40 mA·g–1 V ≤ 0.1 V 4 静置 0 t = 10 min 5 充电 I2 = 40 mA·g–1 V ≥ 2 V 
下载: 导出CSV
表 2 4组放电模式下第4圈嵌锂过程80% SOC时电极应变值
Table 2. Microstrain of the electrode at 80% SOC during the 4th lithiation process under four discharge modes.
实验组别 80% SOC处
频移/cm–180% SOC处
应变/%参考组A (恒定小电流) 1579.44 0.2596 实验组B (大电流-小电流) 1580.22 0.2693 实验组C (小电流-大电流) 1573.23 0.3812 参考组D (恒定大电流) 1581.86 0.2438
下载: 导出CSV
表 3 两阶段恒流模式下第4圈嵌锂过程中电极电荷转移阻抗和应变增加速率的分阶段响应
Table 3. Phased response of charge transfer impedance and strain rate of the 4th cycle during lithiation process under two-stage constant current modes.
嵌锂阶段 电荷转移阻抗$ \bar{R}_{{\rm{ct}}} $增量 应变增加速率 实验组B 实验组C 实验组B 实验组C 阶段-I 0.19 0.15 15.37 4.28 阶段-II 0.39 0.72 3.57 27.84
下载: 导出CSV
表 4 B, C, D放电模式下rGO电极综合储锂性能参数相较于参考组A的增量百分比
Table 4. Percentage increase of comprehensive lithium storage performance parameters of the rGO electrode compared to the reference group A in the B, C, D discharge modes.
实验组别 循环第4圈 循环第50圈 时间 比容量 电荷转移阻抗$\bar{R}_{\rm{ct}}$ 扩散系数 80% SOC过电位/V 应变 容量保持率 库仑效率 能量比率 实验组B –34.9% –5.2% 3.8% 45.3% 0.005 3.5% –1.8% 1.3% 10.2% 实验组C –48.3% –21.7% 22.8% 47.8% 0.029 46.8% –14.2% –2.4% 35.5% 参考组D –80.9% –25.5% 26.6% 96.8% 0.031 –6.1% –21.2% –1.7% 46.8%
下载: 导出CSV
-
[1] Cai W, Yao Y X, Zhu G L, Yan C, Jiang L L, He C, Huang J Q, Zhang Q 2020 Chem. Soc. Rev. 49 3806
Google Scholar
[2] Xie W, Liu X, He R, Li Y, Yang S 2020 J. Energy Storage 32 101837
Google Scholar
[3] Tomaszewska A, Chu Z Y, Feng X N, O'Kane S, Liu X H, Chen J Y, Ji C Z, Endler E, Li R H, Liu L S, Li Y L, Zheng S Q, Vetterlein S, Gao M, Du J Y, Parkes M, Ouyang M G, Marinescu M, Offer G, Wu B 2019 eTransportation 1 100011
Google Scholar
[4] 张兴玉 2020 物理学报 69 248201
Zhang X Y 2020 Acta Phys. Sin. 69 248201
[5] Keil P, Jossen A 2016 J. Energy Storage 6 125
Google Scholar
[6] Pharr M, Suo Z G, Vlassak J J 2014 J. Power Sources 270 569
Google Scholar
[7] Jung H, Gerasopoulos K, Talin A A, Ghodssi R 2017 J. Power Sources 340 89
Google Scholar
[8] Zheng Y, He Y B, Qian K, Li B H 2015 Electrochim. Acta 176 270
Google Scholar
[9] Abe Y, Hori N, Kumagai S 2019 Energies 12 4507
Google Scholar
[10] Shi B Q, Han B, Xie H M, Kang Y, Zhang Q 2021 Electrochim. Acta 378 138151
Google Scholar
[11] Xie H M, Song H B, Guo J G, Kang Y, Yang W, Zhang Q 2019 Carbon 144 342
Google Scholar
[12] Khan A B, Choi W 2018 IEEE Trans. Energy Convers. 33 1132
Google Scholar
[13] Ji D Y, Chen L D, Ma T Y, Jing, Wang S Q 2019 J. Power Sources 437 226911
Google Scholar
[14] Anseán D, Gonzalez M, Viera J C, Garcia V M, Blanco C, Valledor M 2013 J. Power Sources 239 9
Google Scholar
[15] Xu M, Wang R, Reichman B, Wang X 2018 J. Energy Storage 20 298
Google Scholar
[16] Suresh R, Rengaswamy R 2018 Comput. Chem. Eng. 119 326
Google Scholar
[17] Wu X G, Shi W W, Du J Y 2017 Energies 10 1271
Google Scholar
[18] Hu X, Li S, Peng H, Sun F 2013 J. Power Sources 239 449
Google Scholar
[19] Waldmann T, Kasper M, Wohlfahrt-Mehrens M 2015 Electrochim. Acta 178 525
Google Scholar
[20] Liu Y H, Hsieh C H, Luo Y F 2011 IEEE Trans. Energy Convers. 26 654
Google Scholar
[21] Wen K, Xia M, Deng P, Lv W, He W 2019 Chem. Eng. Sci. 200 80
Google Scholar
[22] Sethuraman V A, Srinivasan V, Newman J 2013 J. Electrochem. Soc. 160 A394
[23] Ko Y, Cho Y G, Song H K 2014 RSC Adv. 4 16545
Google Scholar
[24] Finegan D P, Quinn A, Wragg D S, Colclasure A M, Lu X, Tan C, Heenan T M, Jervis R, Brett D J, Das S 2020 Energy Environ. Sci. 13 2570
Google Scholar
[25] An F Q, Zhang R, Wei Z G, Li P 2019 RSC Adv. 9 21489
Google Scholar
[26] Zhang S S 2006 J. Power Sources 161 1385
Google Scholar
[27] Pham-Cong D, Ahn K, Hong S W, Jeong S Y, Choi J H, Doh C H, Jin J S, Jeong E D, Cho C R 2014 Curr. Appl. Phys. 14 215
Google Scholar
[28] Song H B, Na R, Hong C Y, Zhang G, Li X F, Kang Y L, Zhang Q, Xie H M 2022 Carbon 188 146
[29] Cançado L G, Jorio A, Ferreira E H M, Stavale F, Achete C A, Capaz R B 2011 Nano Lett. 11 3190
Google Scholar
[30] Song H B, Xie H M, Xu C C, Kang Y L, Zhang Q 2019 J. Phys. Chem. C 123 18861
Google Scholar
[31] Wang G X, Shen X P, Yao J, Park J 2009 Carbon 47 2049
Google Scholar
[32] 闻雷, 刘成名, 宋仁升, 罗洪泽, 石颖, 李峰, 成会明 2014 化学学报 72 333
Google Scholar
Wen L, Liu C M, Song R S, Luo H Z, Shi Y, Li F, Cheng H M 2014 Acta Chim. Sin. 72 333
Google Scholar
[33] Liu Z H, Kang Y L, Song H B, Zhang Q, Xie H 2020 Chin. Phys. B 30 016201
Google Scholar
[34] Liang H Z, Zhang X Y, Yang L, Wu Y K, Chen H S, Song W L, Fang D N 2019 Sci. China:Technol. Sci. 62 1277
Google Scholar
[35] 庄全超, 杨梓, 张蕾, 崔艳华 2020 化学进展 32 761
Google Scholar
Zhuang Q C, Yang Z, Zhang L, Cui Y H 2020 Prog. Chem. 32 761
Google Scholar
[36] Barsoukov E, Kim J H, Kim J H, Yoon C O, Lee H 1999 Solid State Ionics 116 249
Google Scholar
[37] Zhu Y J, Gao T, Fan X L, Han F, Wang C 2017 Acc. Chem. Res. 50 1022
Google Scholar
[38] Kang Y L, Qiu Y, Lei Z K, Hu M 2005 Opt. Laser Eng. 43 847
Google Scholar
[39] 陆敬予, 柯承志, 龚正良, 李德平, 慈立杰, 张力, 张桥保 2020 物理学报 70 198102
Google Scholar
Lu J Y, Ke C Z, Gong Z L, Li D P, Ci L J, Zhang L, Zhang Q B 2020 Acta Phys. Sin. 70 198102
Google Scholar
[40] Zabel J, Nair R R, Ott A, Georgiou T, Geim A K, Novoselov K S, Casiraghi C 2012 Nano Lett. 12 617
Google Scholar
[41] Zeng Z, Liu N, Zeng Q, Lee S W, Mao W L, Cui Y 2016 Nano Energy 22 105
Google Scholar
[42] Stampfer C, Molitor F, Graf D, Ensslin K, Jungen A, Hierold C, Wirtz L 2007 Appl. Phys. Lett. 91 241907
Google Scholar
[43] Lu B, Song Y C, Zhang J Q 2016 J. Power Sources 320 104
Google Scholar
[44] Lu B, Ning C, Shi D, Zhao Y, Zhang J 2020 Chin. Phys. B 29 026201
Google Scholar
下载:
计量
- 文章访问数: 4581
- PDF下载量: 54
- 被引次数: 0
